Professional Documents
Culture Documents
CA1010 FDT
CA1010 FDT
CA1010 FDT
Technical Data
Product Name CA1010 Mastinox Chromate Free Jointing Compound
Product Description Single component non-drying, non-chromate corrosion
inhibitive jointing compound.
Key Features Non toxic pigmented jointing compound, which inhibits the corrosion
between dissimilar metals. It has a service temperature range from -
54°C to 160°C.
Performance Characteristics
Viscosity 66 Pa.s (RVT 7@50)
Specific gravity 1.37g/cm³
Non-volatile content 92%
Pigment content 43%
Solubility in water 2%
Exposure to heat @ 40°C 95% RH for 1000 hours
- Aluminium / Stainless steel - easy removal, no corrosion.
Exposure to dry heat @ 120ºC for 1000 hours
- Easy removal, compound still tacky
Corrosion tests by galvanic cell method (3% salt water solution)
- Aluminium / Titanium couple, 336 hours – no corrosion
Stainless steel / Titanium couple, 336 hours – no corrosion
Corrosion tests by salt spray for 336 hours
- Aluminium - easy removal, no corrosion.
Pack Size 6 floz Semco cartridge
Surface Preparation CA1010 is to be applied over substrates properly degreased with the
help of appropriate solvents.
Equipment Cleaning Clean equipment as soon as possible after the product has been
applied and always before the material has dried.
Special Notes
14/01/2008
Page1of2
Technical Data
Physical Characteristics
Colour White
Shelf Life Cr free Mastinox can be stored 12 months in its unopened containers at
recommended storage temperatures.
This product is safe to use and apply when recommended precautions are observed. Before using this product it is
important to read and understand the Material Safety Data Sheet. This provides information on health, physical and
environmental hazards, handling precautions and first aid recommendations. Material Safety Data Sheets are
available on request.
In case of overexposure, wash with soap and water and seek medical advice.
All recommendations, statements and technical data contained herein are based on tests we reasonably believe to be reliable
and correct, but the accuracy and completeness of such tests are not guaranteed and are not to be construed as a warranty,
either express or implied. The User shall rely on its own information and tests to determine the suitability of any product for its
intended use and the User agrees to assume all risks and liability arising in relation to its use of such product (other than death or
injury resulting from our negligence) and accordingly we shall not assume any such risks or liability unless we specifically agree to
the contrary in writing. If we specifically agree to assume any such risks or liability then (except for death or injury resulting from
our negligence) our sole responsibility if any product supplied to the User by us is defective shall be to replace that portion of such
product which is defective. Recommendations or statements other than those specifically agreed in writing by us shall not be
legally binding on us.
14/01/2008
Page2of2