Professional Documents
Culture Documents
HC2019 Application Data Sheet-Slew Drive-US Metric
HC2019 Application Data Sheet-Slew Drive-US Metric
HC2019 Application Data Sheet-Slew Drive-US Metric
Fields highlighted in grey show our standard options. In case of insufficient customer information we take these as the basis of our calculation.
2. Application In case of several slew drives per application, please fill in a separate application data sheet for each slew drive.
Description of plant/system (please provide a sketch):
Jib Crane 10 m (Height) / 19 m (Boom) / Rated Load 10.00 Tonnes
Current solution?
Use a WD-L-0620/250a slew drive.
3. Special requirements
Military/Nuclear Application: No Yes, Military Yes, Nuclear
Special environmental conditions? IMO-Standard (dust & water spray) Seawater Food industry
Other:
5. Additional attachments
Drive: Without motor IMO-Standard (default hydraulic motor)
Frequency 50 Hz 60 Hz
Holding brake: Not required Yes (IMO recommendation for 100% safe hold)
Slew angle monitoring: Not required Yes, IMO default type (» see Application Data Sheet - Encoder - FM AEA 002)
Axis of
rotation
Axis of rotation
α = °
Are safety factors included in the loads above? No Yes, which (value)?
Should additional load increasing factors be included in the loads? No Yes, which (value)?
Desired life time in years: 25 a Slewing time for one cycle of operation: 2400 s
Slewing time of slew drive per year (slew drive is turning): 48 h/a Operation cycles of plant/system per hour: 1 1/h
Description of load cases: We recommend providing at least one normal load case with a higher time share (e.g. 90%) and one extreme load case with a
lower time share (e.g. 10%) for a better calculation result.
7. Commercial data
Expected yearly demand: units/year Required batch size: units/delivery
8. Comments
Are there any additional customer requirements (e.g. standards and certification, special packaging, quality control agreements) that must be considered?
Additional helpful information from the customer (e.g. application description, operating cycle description, drawings, photos, etc.)?
9. Customer confirmation
I herewith confirm the correctness of the data provided above as the basis for the design and offer.