Professional Documents
Culture Documents
89222030-07 B7FB MWM7A Euro3
89222030-07 B7FB MWM7A Euro3
89222030-07 B7FB MWM7A Euro3
Wiring Diagram
B7FB, CHID 403622-
Foreword
The descriptions and service procedures contained in this manual are based on designs and
methods studies carried out up to October 2015.
The products are under continuous development. Vehicles and components produced after the
above date may therefore have different specifications and repair methods. When this is judged
to have a significant bearing on this manual, an updated version of this manual will be issued to
cover the changes.
In service procedures where the title incorporates an operation number, this is a reference to V.
S.T. (Volvo Standard Times).
Service procedures which do not include an operation number in the title are for general
information and no reference is made to V.S.T.
The following levels of observations, cautions and warnings are used in this Service
Documentation:
Note: Indicates a procedure, practice, or condition that must be followed in order to have the
vehicle or component function in the manner intended.
Caution: Indicates an unsafe practice where damage to the product could occur.
Warning: Indicates an unsafe practice where personal injury or severe damage to the product
could occur.
Danger: Indicates an unsafe practice where serious personal injury or death could occur.
All rights reserved. No part of this publication may be reproduced, stored in retrieval system,
or transmitted in any forms by any means, electronic, mechanical, photocopying, recording or
otherwise, without the prior written permission of Volvo Bus Corporation .
ENG73070
Contents
Example of wiring diagram ........................................................................................................1
Illustrations............................................................................................................................ 26
Fuses..................................................................................................................................... 31
Relays.................................................................................................................................... 33
List of connectors................................................................................................................... 34
List of components................................................................................................................. 38
+ Battery voltage.
+ 30 Voltage with S12 key connected (main switch).
+ DR Voltage with the ignition key in the drive position, the
preheating position and the start position.
Connection point.
Fuse.
Switch.
Relay.
Connector MB pin 9.
BA Engine ECU.........................................................................................
...................................... page 6
BB ........................................... page 7
Gateway .........................................................................................
BX Telematics .......................................................................
.......................................................... page 8
CG ..................................... page 10
Auxiliary fog lights ................................................................................
CL ................................................ page 12
Exhaust brake ...........................................................................
EA ................................................ page 15
Reversing light...........................................................................
EZ ........................... page 16
Extra switch for bodybuilder ...........................................................................
FA ................................................................ page 17
Horn...........................................................................
HM ................................ page 20
Fuel filter heater.........................................................................................
NC ..................................................... page 22
Tachograph...........................................................................
C3107131
Note: The following illustrations show the locations of connectors in their respective components. Some connectors may not
appear to be connected because the location of their components varies according to the design of the bodybuilder.
C3075206
C3065030
Note: Fuse identification codes in the vehicle are different from those in the wiring diagram. The table below shows fuse
identification codes in the vehicle and their respective identification codes in the wiring diagram.
WHITE:B2 {OA 2 B}
WHITE:B4 {CE 2 B}
WHITE:B5 {OA 3 C}
WHITE:B7 {CG 3 B}
WHITE:B8 {CE 2 B}
WHITE:B9 {CE 3 B}
WHITE:B10 {CE 1 B}
WHITE:B11 {CE 4 A}
YELLOW8:3 {OA 1 B}
YELLOW8:8 {CE 1 C}
YELLOW:A1 {CE 1 C}
YELLOW:A2 {NA 1 B}
YELLOW:A3 {NA 1 B}
YELLOW:A4 {CG 3 C}
YELLOW:A6 {GA 1 B}
YELLOW:A9 {AA 3 B}
YELLOW:A10 {OA 0 B}
YELLOW:A11 {AA 0 C}
YELLOW:A13 {AA 0 C}
YELLOW:B1 {CE 2 C}
YELLOW:B2 {NA 2 B}
4.2 Ground stud, cab upper {ZA 3 E12L Lamp, roof position light, left
C} {CE 1 D}
51-TM1 Fuse Holder 1 - Pole {AA 3 B} E13RF Lamp, direction indicator, right
front {CN 2 E}
A03 Instrument cluster {NA 0 B}
E13RS Lamp, direction indicator, right
side {CN 3 E}
A33 Tachograph {NC 0 B}
earth10_19 Grond stud, Auxiliary Fog earth47_91 Grond stud, Auxiliary Fog
Lights {CG 3 C} Lights {CG 2 D}
earth11_19 Grond stud, Auxiliary Fog earth47_126 Ground stud, Earth Connec-
Lights {CG 1 B} tions {CM 2 E}
earth19_21 Ground stud, Brake Light {CK 1 earth48_91 Grond stud, Auxiliary Fog
B} Lights {CG 3 D}
earth32_21 Ground stud, Earth Connec- earth50_91 Ground stud, Earth Connec-
tions {ZA 3 D} tions {GA 2 D}
earth34_91 Ground stud, Earth Connec- earth51_36 Ground stud, Head, Position,
tions {CE 0 D} spot Lights {CE 2 B}
earth35_91 Ground stud, Earth Connec- earth52_36 Ground stud, Head, Position,
tions {CE 0 D} spot Lights {CE 3 B}
earth36_91 Ground stud, Earth Connec- earth52_91 Ground stud, Earth Connec-
tions {CE 0 D} tions {GA 0 D}
earth37_91 Ground stud, Earth Connec- FB1 Fuse Box, Chassis {AA 1 C}
tions {CE 0 D}
G01C Battery {AA 1 D}
earth39_91 Ground stud, Head, Position,
spot Lights {CE 1 E}
G01D Battery {AA 1 D}
S49 Closing cont/ Rev. lights {EA 0 X01 Connector, vehicle diagnostics
C} {BB 0 D}
S58B Position switch, clutch pedal, X04 Trailer connection, 7-pole unit,
NO. {BA 1 B} 24 N {CE 1 E} {CK 2 D} {CN 1
E} {EA 2 C}
S90 Position switch, Neutral {AA 3
B} X10 B+ pass through, Cab {AA 1 B}
S105 Switch, Hazard warning light Y01 Solenoid valve, exhaust brake
{CN 2 B} {CL 1 B}
BL.................................................... Blue
BN ................................................... Brown
GN................................................... Green
GR................................................... Grey
OR................................................... Orange
P...................................................... Pink
R...................................................... Red
SB ................................................... Black
VO................................................... Violet
W..................................................... White
Y...................................................... Yellow
Note: If an electrical cable has two colours, it will be marked as shown below: Y/R = Yellow/Red.
Last page