Professional Documents
Culture Documents
RRU3203 Technical Specifications (V100R016C10 - 01) (PDF) - EN
RRU3203 Technical Specifications (V100R016C10 - 01) (PDF) - EN
V100R016C10
Technical Specifications
Issue 01
Date 2020-04-07
and other Huawei trademarks are trademarks of Huawei Technologies Co., Ltd.
All other trademarks and trade names mentioned in this document are the property of their respective
holders.
Notice
The purchased products, services and features are stipulated by the contract made between Huawei and
the customer. All or part of the products, services and features described in this document may not be
within the purchase scope or the usage scope. Unless otherwise specified in the contract, all statements,
information, and recommendations in this document are provided "AS IS" without warranties, guarantees
or representations of any kind, either express or implied.
The information in this document is subject to change without notice. Every effort has been made in the
preparation of this document to ensure accuracy of the contents, but all statements, information, and
recommendations in this document do not constitute a warranty of any kind, express or implied.
Website: https://www.huawei.com
Email: support@huawei.com
Contents
Product Versions
The following table lists the base station product versions related to the RRU.
Intended Audience
This document is intended for:
● Network planners
● Onsite engineers
● System engineers
Organization
01 (2020-04-07)
This is the first commercial release.
Compared with Draft A (2020-01-20), this issue does not include any new topics
or changes, or exclude any topics.
Draft A (2020-01-20)
This is a draft.
RRU3203 Technical Specifications is a separate document created for this release.
Its content derives from section RRU3203 Technical Specifications under RRU
Technical Specifications. In this and subsequent releases, this content is removed
from RRU Technical Specifications and constitutes a separate document.
Compared with section RRU3203 Technical Specifications under RRU Technical
Specifications of Issue 05 (2019-10-25) in V100R015C10, this issue does not
include any new topics or changes, or exclude any topics.
Table 3-1 Frequency bands and RATs supported by an RRU3203 (700 MHz)
a: ATBR in the TX/RX Mode column indicates that the RF module uses A
transmit channels and B receive channels.
b: The bandwidth information in Supported Bandwidth is the standard
bandwidth that can be configured for a single-mode carrier when only one
carrier is configured. In any carrier combination scenario, the total bandwidth of
all carriers cannot exceed the IBW value. For details about the bandwidth that
can be configured for each carrier in each carrier combination scenario, see
Output Power Configuration in the following table. For details about the non-
standard bandwidths that can be configured for LTE FDD carriers, see Compact
Bandwidth (FDD).
Table 3-3 Output power and carrier configurations of an RRU3203 (700 MHz)
a: AxC W in the Maximum Output Power column indicates that the number of
TX channels of the RF module is A and the maximum output power of each TX
channel is C W.
NOTE
Receiver Sensitivity
NOTE
The LTE FDD receiver sensitivity, as recommended in 3GPP TS 36.141, is measured under a 5
MHz bandwidth based on the FRC A1-3 in Annex A.1 (QPSK, R = 1/3, 25 RBs) standard.
RF Compliance Standards
Input Power
NOTE
DC RRUs can use external power modules to support AC scenarios. For details about the
types of external power modules supported by each type of RRU, see section "RRU Auxiliary
Devices" in the corresponding RRU hardware description. For details about the external
power modules, see user guides of the corresponding models.
Table 3-8 Power consumption of the DBS (-48 V DC) (configured with the
RRU3203 700 MHz)
a: For an LTE base station, one UMPTb1 and one LBBPd1 are configured in the
BBU when one carrier is used, and one UMPTb1 and one LBBPd3 are configured
when two carriers are used.
b: "AxB MHz, C carriers" is used for LTE, indicating that A cells are configured,
the bandwidth of each cell is B MHz, and there are C carriers in total. Unless
otherwise specified, this document assumes that one sector is configured with
one RF module.
c: The typical power consumption of LTE is measured when the ambient
temperature is 25°C (77°F) and the traffic load reaches 50%. The actual power
consumption has a 10% deviation from this value.
d: The maximum power consumption of LTE is measured when the ambient
temperature is 25°C (77°F) and the traffic load reaches 100%. The actual power
consumption has a 10% deviation from this value.
Environmental Specifications
Item Specification
NOTE
The output power of an RRU temporarily decreases when it operates at temperature ranges
10ºC (18ºF) less than or equal to its maximum rated value. This is dependent on
installation scenario, traffic load, and carrier configuration.
NOTE
● Unless otherwise specified, the lightning protection specifications depend on the surge
waveform of 8/20 μs.
● Unless otherwise specified as maximum discharge current, all the surge current items refer
to nominal discharge current.
a: The validity period is one year. The product can function properly within the
validity period if the storage environment meets the preceding standards.
Table 3-12 CPRI port protocol and rate of an RRU3203 (700 MHz)
Number of CPRI Ports Protocol Type Port Rate (Gbit/s)
2 CPRI 1.25/2.5
LTE FDD When the CPRI data rate is ● When the LBBPc or LBBPd1
2.5 Gbit/s: is configured: 20
● Cell bandwidth ≤ 5 MHz: 3 ● When the LBBPd2 or UBBP
● Cell bandwidth = 10 MHz: is configured: 40
2 ● When the LBBPd3 is
● Cell bandwidth ≥ 15 MHz: configured: 40 (number of
cascading not cells ≤ 3); 20 (number of
recommended cells ≥ 4)
NOTE
● For details about the CPRI topologies supported by each RRU model, see RF Unit and
Topology Management.
● For details about the ALD capabilities supported by each RRU model (for example, the
capabilities of RF ports supporting RET antennas and TMAs), see ALD Management.
General Rules
● For an nT RF module (n is 2, 4, or 8), the restriction is as follows: