Professional Documents
Culture Documents
(Solved) - 1. For The Components Shown in Fig. 13.60 To 13.62, Make Part... (1 Answer) Transtutors
(Solved) - 1. For The Components Shown in Fig. 13.60 To 13.62, Make Part... (1 Answer) Transtutors
(Solved) - 1. For The Components Shown in Fig. 13.60 To 13.62, Make Part... (1 Answer) Transtutors
Questions » Engineering » Mechanical Engineering » 1. For the components shown in Fig. 13.60 to...
REVIEW PLEASE
to 13.62, make part programs for
machining on a CNC...
1 answer below »
1. For the components shown in Fig. 13.60 to 13.62, make part programs
for machining on a CNC machining centre equipped with the ISO
controller. Clearly show the set point and axes on the sketch of the part.
Show all the necessary calculations.
2. For the components shown in Fig. 13.63 to 13.65 make part programs
for machining on a CNC turret drill press equipped with the ISO controller
using absolute programming. Choose the datum as the bottom left-
hand corner of the part. Clearly show the set point and axes on the sketch
of the part. The cutting speed to be used is 50 m/min and the feed rate is
0.08 mm/rev. Show all the necessary calculations.
1 Approved Answer
Attachments:
6375191902687....jpg
PREVIOUS NEXT
Related Questions
Q: It is estimated that a jig for machining a part with three holes costs
$400 and with it the operation takes 15 min/part. The operation can
be done without a jig on a numerically controlled drill press in 5
min. Assume that any other conditions are...
Posted 2 months ago
View Answer ►
Q: It is estimated that a jig for machining a part with three holes costs
$400 and with it the operation takes 15 min per part. The operation
can be done without a jig on a numerically controlled drill press in 5
min. Assume that any other conditions...
Posted 2 years ago
View Answer ►
Plagiarism Checker
more questions »
Study Quick
Help Links