Professional Documents
Culture Documents
ECM Assignment CO-4
ECM Assignment CO-4
1) A rectangular section 200 mm wide and 400 mm deep is used on a span of 6 m for the
loading shown in Figure 1. Find the maximum value of W so that the permissible
bending stress of 50 MPa is not exceeded in the material.
Figure 1
2) A cantilever beam of 500mm length carries a UDL of 5 kN/m from support to mid span.
It carries a point load of 6kN at the tip of a cantilever, If the beam section is 50mm wide
x 150 mm deep throughout the length, determine maximum bending stress. Neglect the
self-weight of the beam.
3) A Simply supported timber beam 150 mm wide and 300 mm deep is simply supported
over a span of 4.5 m. It is loaded with a uniform load of 8 kN/m.
a) Shear stress developed on a layer 60 mm above neutral axis of a section located
at 1.5 m from left support.
b) Maximum shear stress on the above section
c) Maximum shear stress anywhere in the beam.
4) Define the terms section modulus, modulus of rupture, bending moment, and moment
of resistance.
5) Explain with examples the limitations of the shear stress distribution equation.