Professional Documents
Culture Documents
Solar PVSitesurvey V20 EPCChoice II
Solar PVSitesurvey V20 EPCChoice II
Solar PVSitesurvey V20 EPCChoice II
0
Assessor name:
Signature:
Semi bung No
Det Property
Flat *
Tile Dimensions: If measurements can be taken from ground level Height (mm) Width (mm) Depth (mm)
Is the roof surface flat? Y/N If not, estimate how much undulation? Slight(<50mm) / Moderate(500mm-150mm) / High(>150mm)
Access Requirements: Good Access Narrow Access Lack of Parking Other (Specify)
Scaffold Location: Front Rear Left Hand Side Right Hand Side
Additional
Information:
Inverter Location (Area required of approx 1m2):- Loft Garage External Other (Specify)
Type of surface is the inverter going to be place on? Brick/Stone Block Frame Mounted Other (Specify)
Additional
Information:
DC Cable Run
AC Cable Run
Space on consumer unit for an extra way (This must be a spare slot with a blanking plate or a confirmed spare fuse) Yes No
Is earth bonding clearly visible by the consumer unit and on mains gas/water - Please Answer Y (Yes) or N (No) or N/V (Not Visible) E G W
Is there space within the roof space for the inverter (wall or board mounted) NO CHIMNEY MOUNT Yes No
Does client require alternative location for inverter if so supply images and dimensions of space (1m2) Yes No
Is the proposed installation attached to the property where consumer unit is located (i.e. not a detached garage) Yes No
Page 1
Internal Roof Structure Details
Visible Issues in Roof Structure, Wet/Rotten rafters, Broken rafters, Alteration work etc:
The below Template has been given to help assist you. In some cases it may not represent the cross section of this particular property in this instance
produce you own Cross Section on Page 4. Please ensure if the cross section is showing a Typical Cut Roof, That you also show measurements 'D' & 'E'
on the diagram. If a Dormer is present add this to the diagram with the measurement shown.
What is the roof construction? Actual Roof Pitch ⁰ (Internal) Timber Dimensions
Traditional Cut Roof (Purlin Roof) PV Roof 1 PV Roof 2 PV Roof 3 Size of Rafter: Width mm Depth mm
(Internal) Joist to
M
Ridge (C) (Internal) Distance From Purlin
to Wall Plate: (E)
(If Applicable)
M
M
Notes
Page 2
Roof Layout - Measurements Must be External measurement
Using the template below indicate the roof dimensions of the proposed roof (Birdseye View Diagram), Measurements of any roof obstructions must be
noted on the diagram as these may effect the proposed layout. Indicate the proposed layout of the panels on the diagram, Showing the panels in either
Portrait or Landscape layout indicating the amount that will fit on the usable roof space. (Ensure there is a 500mm gap to the edge of the roof on all sides)
If Panel size is not provided consider each individual panel to measure 1014mm x 1662mm (This dimension takes into account the space between each
panels) If more than 1 PV roof duplicate this page.
The below has been given to help assist you. In some cases it may not represent the actual roof. In this case use page 4 to produce your own.
PV Panel Chimney Velux Window Area affected by Shading Soil Vent Pipe Roof Tile Vent
M M
Length: mm
Width: mm
M PV
(External) Height of the
ridge from the ground:
(F)
(External) Height of
M gutter from ground: (H)
(External)Span of
roof: (E)
No. Of panels
Page 4