Professional Documents
Culture Documents
TL - TDM - ETH - Italia
TL - TDM - ETH - Italia
TL - TDM - ETH - Italia
TL IP/TDM
management & characteristics
Training manual
11/04/2014
TL configuration
V V or H V
H H
ACCP CCDP
ACAP
(With Xpic)
CCDP = CoChannel Double Polarisation
3 11/04/2014
Double Terminal Configuration
Virtual Split
Flexible System
Configurations at
Lower Cost Repeater Site
DT DT
Single NE = One SV unit
4 11/04/2014
RPS Channel Allocation
TL terminal
Flexible Capacity Split &
Flexible slot allocation
RPS-GP1 RPS-GP2
N+1 M+1
or n+0 or m+0
TRMD Shelf
Max. 16
Always 1 NE even
Complete sys in case of DT
configuration
N+M: Max. 14
N+m: Max. 15
N+M: Max.15
n+m: Max. 16
11/04/2014
Various System Configurations (1/13)
SDH
Only
Ethernet
Only 8 x RF carriers
SDH/Ethernet (each direction)
Mixed (Hybrid)
8 x TRMD 8 x TRMD
7 x STM1 7 x STM1
8 x STM1 8 x STM1
12 x TRMD 12 x TRMD
10 x STM1 10 x STM1
9 x TRMD 9 x TRMD
8 x TRMD 16 x TRMD
8 x TRMD 8 x TRMD
2 x GE ports 2 x GE ports
(Max. 2 Gbps) (Max. 2 Gbps)
16 x TRMD 16 x TRMD
4 x GE ports 4 x GE ports
(Max. 4 Gbps) (Max. 4 Gbps)
16 x TRMD 16 x TRMD
8 x TRMD 16 x TRMD
* SV Dual Terminal
2 x GE ports 4 x GE ports License is required
(Max. 2 Gbps) (Max. 4 Gbps)
20 11/04/2014
TL Configuration Tree (2/2)
21 11/04/2014
RPS Uni-Polar Stage Switch
TL terminal
BB INTF TRMD
MD TR
USW
PROT
BB INTF TRMD
MD TR
USW
W1
Native Ethernet
Hybrid and/or
Transport Native TDM (SDH)
BB INTF
TRMD
MD TR
USW
Wn
22 11/04/2014
SDH Clock Synchronization
TL terminal
23 11/04/2014
Flexible Branching Filter Allocation
24 11/04/2014
BRU Cable Connection (1/3)
25 11/04/2014
BRU Cable Connection (2/3)
1 x TRMD ADPT connects
BPF (CH2’) 2x TRMD blades
SD BPF (CH1’) at the rear side of a rack.
BPF (CH2’)
Rx BPF (CH1’)
TRMD ADPT
BPF (CH2)
Tx BPF (CH1)
BPF
VENT
VENT
1 x VENT unit
for 2 x TRMD blades
TRMD TRMD
2 x TRMD supplies TRMD
power to 1 x VENT unit (CH1) (CH2)
TRMD TRMD
(Prot) (W1)
BB-INTF BB-INTF
27 11/04/2014
Other TL details
Low Power Consumption (200W / 1+1)
No need for hardware setting of SD DADE adjustment
XPIC DADE adjustment by software
Short and Simplified XPIC cables
ACM
IP/Ethernet Features
No need for Delay-Equalizer (D-EQL) module
Firmware Upgrade Capability for TRMD
Fine adjustment settings for Transmitter Power Control
No need for HK unit for STM1 OPT interface alarm/control
28 11/04/2014
Upgrade by License Key
License Key function that enables system upgrade
License Key Procedure
• Customer informs Serial No. of relevant cards to Siae.
(ex. high power output, inform TRMD serial No.)
• Siae creates license key file that enables optional
upgrade and delivers the customer with cost.
• Customer downloads license key file to the relevant
cards from Web-based Local Terminal (WebLT) and
optional upgrade is enabled.
• License key file is only effective for the relevant card
and it is also highly digitally encoded .
1+1 with SD
Power
Power
Unit Consumption NOTE
Q’ty Consumption
(W)
(W)
TRMD 86.0 2.0 172.0 +30dBm Tx Output for 64QAM or
+29dBm Tx Output for 128QAM
VENT 5.0 1.0 5.0 One VENT unit is for 2 TRMD units
30 11/04/2014
Throughput for 1518 bytes packet size
For each
For each channel
Modulation channel at
at 40 MHz
30 MHz
31 11/04/2014
N+1 Radio Protection Switching (RPS)
Protection
Traffic TRMD Prot
BB INTF BB INTF card is
Occasional always required
USW BPF
STM-1 on Prot channel.
TRMD M1
BB INTF
Main 1
USW BPF
STM-1
TRMD M2
BB INTF
Main 2
USW BPF
STM-1
TRMD M3
BB INTF
Main 3 BPF
STM-1 USW
USW (Uni-polar Switching)
- For Countermeasure to fading BRU
- Hitless - Uni-directional
32 11/04/2014
N+0 Unprotected Configuration
TRMD M2
BB INTF
Main 2
USW BPF
STM-1
TRMD M3
BB INTF
Main 3
USW BPF
STM-1
TRMD M4
BB INTF
Main 4 BPF
STM-1 USW
BRU
33 11/04/2014
Optional STM1 Interface Redundancy
In case BB INTF (STM1 user interface) redundancy is a mandatory
requirement, BB-INTF redundancy option can be proposed.
Note that this feature is not available in V7.0.
BB INTF (X)
TRMD Prot
SEL SEL
Occasional
/ USW / BPF
STM-1 DIV DIV
BB INTF (Y)
BB INTF (Y)
BRU
HPA OUT
• Adaptive compensation of
HPA non-linear distortion
(6)
(5) (1) • Accurate detection of
(4) (3) (2) distortion noise
• Digital control to minimize
HPA
distortion noise
Main Signal
Distortion
35 11/04/2014
36 11/04/2014
37 11/04/2014
38 11/04/2014
Engineering Orderwire (OW) in SOH
Using E1 byte only (E2 byte not used)
OW 4-Wire interface (to/from other equipment)
Orderwire telephone calling operations in WebLT menu
1. [A & B] Set provisioning parameters to enable “OW” function in WebLT
2. [A] Push an “LED TEST” button to activate OW line at A
3. [A] Operate WebLT control menu from A to B in order to ring a buzzer tone on SV_B
4. [B] Push an “LED TEST” button to stop the buzzer tone and to activate OW line at A
A B
SV SV SV SV
AUX
11/04/2014
WebLT:
use only Internet Explorer 8 and up
11/04/2014
WebLT
Default address is : 192.168.0.10
And if you don’t know the address of SV card ?
1) Extract SV card
2) Move pin7 of SW24A to ON
3) Insert SV card
4) Access to WebLT with default address 192.168.0.10
5) With WebLT insert new IP address
6) Extract SV card and move pin7 of SW24A to OFF
7) Insert SV card and use new IP address
11/04/2014
Configuration
N+0=4+0
N+1=3+1
11/04/2014
Configuration
11/04/2014
Delay Equalizer
NONE
BOTH
11/04/2014
Configuration
11/04/2014
Configuration
11/04/2014
Configurations
Disable when SD
antenna absent
11/04/2014
Configurations
11/04/2014
Configurations
11/04/2014
Configurations
11/04/2014
Line up Adjust
Warning: on TRMD change DADE Adjust must be done for the new TRMD
11/04/2014
Readings
11/04/2014
Save, restore configuration
To SAVE configuration
11/04/2014
IP Network Applications
GP1 GP1
BB TRMD TRMD BB
GE SW
1 – 8 RF 1 – 8 RF
GE SW
GP2 GP2
BB TRMD TRMD BB
Max. 2Gbit/s
GE SW
GE SW
1 – 8 RF 1 – 8 RF
channels channels
Max. 2Gbit/s
BB TRMD TRMD BB
55 11/04/2014
TRMD connections to Gigabit Ethernet Line ports
GE SW v2
Line Radio TRMD Max.
Port port Port 8 CH
Radio Agg
1
51 Group1
R-1 Work1
R-2 Work2
2
61 WAN
R-3 Work3
L2SW /SEL
N:N Radio Agg
3
71 Group2
L1SW
R-4 Work4
R-5 Work5
4
81
R-6 Work6
R-7 Work7
R-8 Work8
11/04/2014
TRMD connections to Gigabit Ethernet Line ports (Example)
TRMD TRMD TRMD TRMD TRMD TRMD TRMD TRMD
W1=R1 W2=R2 W3=R3 W4=R4 W5=R5 W6=R6 W7=R7 W8=R8
11/04/2014
GESWv2
Always
Enable
11/04/2014
GESWv2
Switch port 5
Switch port 8
11/04/2014
GESWv2
11/04/2014
GESWv2
Qos for not classified packets
INPUT POLICY
11/04/2014
GESWv2
OUTPUT POLICY
Strict
Q6 Q7
- - Strict priority from Q7 to Q6
-
-
-
-
Weighted priority from Q5 to Q0
- -
- -
- - In this case only internal port 5 has
- -
- - some queues with Weighted priority
8 Queues
11/04/2014
GESWv2
OUTPUT POLICY
DWRR =
Deficit Weighted Round Robin
Q7 max
priority
11/04/2014
GESWv2 SyncE
To Restore configuration
11/04/2014
NMS5LX TL MANAGER
11/04/2014
NMS5LX TL MANAGER
11/04/2014
NMS5LX TL MANAGER
11/04/2014
NMS5LX TL MANAGER
11/04/2014
Performance monitoring
11/04/2014
Line and Radio Loopback
72 11/04/2014
Line and Radio Loopback
73 11/04/2014
Line and Radio Loopback
74 11/04/2014
GESWv2
OUTPUT POLICY
Q7 max priority
11/04/2014
GESWv2
OUTPUT POLICY
11/04/2014
Browser compatibility
The only browser that must
be used are :
Internet Explore 8 or 9.
IE 10 must run in compatibility
mode
11/04/2014
All informations contained in this presentation can be subject