Professional Documents
Culture Documents
Agricultural-Engineering (Set 13)
Agricultural-Engineering (Set 13)
13 of 18 sets
1202. In MB plough, the perpendicular distance from wing of share to the line
joining the point of the share and heel of landside is
A. Width of furrow
o m
B. Size of plough
. c
C. Plough width
te
D. All are correct
a
Answer:B
q M
c
M
1203. A device mould to cut the furrow slice vertically from a land ahead of bottom
is
A. Jointer
B. Coulter
C. Gunnel
D. None of these
Answer:B
1205. The erosion caused by concentration flow in small channels or rills is called
A. Gully erosion
B. Rill erosion
C. Torrent erosion
D. All are correct
Answer:B
1213. Solar energy reaching per square metre of the earth atmosphere is called
A. Solar coefficient
B. Solar constant
C. Solar radiation
D. All are correct
Answer:B
1221. A brick or stone masonry linings are recommended for lining watercourses
from channels where discharge is
A. Less than 30 lit/sec
B. More than 30 lit/min
C. Only 30 lit/sec
D. None of these
Answer:A
1223. The proportion of wet cow dung and water in slurry seed to the digester is
A. 1;1
B. 1;2
C. 1;3
D. 1;4
Answer:A
1224. The offset disc harrow are mostly suitable for working in
A. Garden
B. Orchard
C. Field
D. All are correct
Answer:B
1240. In pressurized water cooling. The boiling point of coolant can be increased
by increasing its
1251. A seed metering mechanism has double faced wheel, one face has a larger
opening for larger seeds and other face has smaller opening for smaler seeds is
A. Cell feed
B. Internal double run
C. Cup feed type
D. All are correct
Answer:B
1258. After pre-treatment (pulse with oil) the pulses are kept on floors for oil
diffusion for about
A. 6 hours
B. 8 hours
C. 12 hours
D. 16 hours
Answer:C
1261. The useful life of walking type ploughs may take about
A. 1000 hrs
B. 1500 hrs
C. 2000 hrs
D. 2500 hrs
Answer:B
1262. A fuel has higher octone number its ignition quality of fuel will be
A. Poor
B. Better
C. Not affected
D. All are correct
Answer:B
1269. The tillage practice is desirable in the areas of having hard or compacted
layers below the plough depth is
A. Minimum tillage
B. Conservation tillage
C. Sub soiling
D. None of these
1271. The part of MB plough to which the plough bottom and handle attached is
A. Beam
B. Standard
C. Frog
D. All are correct
Answer:B
1272. The science which deal with the measurement of flow is known as
A. Hydro-meteorology
B. Hydrometry
C. Hypsometry
D. None of these
Answer:B
1280. A device for regulating the fuel supply in main jet of carburetor is
A. Choke
B. Throttle
C. Economizer
D. All are correct
Answer:C
1283. In hill drop metering mechanism the cells round the edge of the plate admits
A. One seed at a time
B. Two seeds at a time
C. Several seed at a time
D. None of these
Answer:C
1289. A cipoletti weir has a breadth of 60 cm at its crest and head of water flowing
over the crest is 30 cm, the discharge of weir will be
A. 180 lit/sec
B. 180 lit/min
C. 186 lit/sec
D. 183 lit/min
1297. The process of removing husk and bran of the paddy in one: operation is
called
A. Hulling
B. Shelling
C. Milling
D. All are correct
Answer:A
1298. A MB plough that throws furrow slice on one side to the direction of travel is
A. One-way plough
B. Two-way plough
C. Turn wrest plough
D. Irreversible plough
Answer:A