Professional Documents
Culture Documents
Agricultural-Engineering (Set 15)
Agricultural-Engineering (Set 15)
15 of 18 sets
1405. The solar radiation receives from the sun after its direction has been changed
is
A. Beam radiation
B. Diffuse radiation
C. Direct radiation
D. All are correct
Answer:B
1408. An implement that attached to a tractor along hinge axis and controlled
directly by tractor steering unit is
A. Trailed implements
B. Mounted implements
C. Semi mounted implements
D. All are correct
Answer:C
1412. The condition of soil that determines the optimum condition for tillage is
A. Plastic
B. Hard
C. Crumbly
D. Cemented
Answer:C
1413. For belt conveying of paddy, the most suitable trough angle is
A. 10?C
B. 15?C
C. 20?C
D. 25?C
Answer:C
1415. The belt speed for transportation of grams should not increase by
A. 3.5 m/s
1420. Starting motor is engaged with ring gear of engine with the help of
A. Bevel gear
1434. Maximum noise level from a tractor mear the operator's ear should not
exceed
A. 85 dB
B. 90dB
C. 95 dB
D. 100 dB
Answer:B
1438. Rational formula is only appicable to small size catchments which has an
area
A. Less than 50 km2
B. More than 50 km2
C. Less than 5000 km2
D. More than 5000 km2
Answer:A
1441. Hammer mill and Burr grinder are used for grinding the
A. Grain
B. Oil seed
C. Pulse
D. All are correct
Answer:A
1449. A latitude for wave energy in both Northern and Southern Hemispheres is
between
A. 10 and 20?
B. 20 and 30?
C. 30% and 50?
D. 40 and 60?
1451. A machine that cuts the crops and ties them into a knot and uniform sheaves
is called
A. Combine
B. Reaper
C. Reaper binder
D. All are correct
Answer:C
1455. The percent saving of water in bed sowing of wheat as compared to flat
sowing is
A. 10%
B. 20%
C. 30%
D. 40%
Answer:D
1461. In two-stroke cycle engine, one power stroke is obtained after every
A. Half revolution of crankshaft
B. One revolution of crankshaft
C. Two revolution of crankshaft
D. Three revolution of crankshaft
Answer:B
1471. Solar energy can be directly converted into electrical energy, by a method is
A. Thermoelectric
B. Thermionic
C. Magneto hydrodynamic
D. All are correct
Answer:D
1472. A plough that works effectively in hard, dry and sticky soil is
A. Mould board plough
B. Disc plough
C. Harrow plough
D. Indigenous plough
Answer:B
1474. In case of raw rice, the average yield obtained from huller is
A. 52%
B. 56%
C. 60%
D. 65%
1480. The separation of grain in magnetic separator is carried out on the basis of
A. Specific gravity
B. Surface texture
C. Roundness
D. Relative length
Answer:B
1492. The procedure of testing seed drill for correct seed rate is
A. Metering
B. Calibration
C. Calculation
D. None of these
Answer:B
1495. When knife and pitman run in a straight line, then cutter bar is in
A. Proper registration
B. Improper registration
C. Proper alignment
D. Improper alignment
Answer:C