Professional Documents
Culture Documents
Agricultural-Engineering (Set 2)
Agricultural-Engineering (Set 2)
2 of 18 sets
106. A white shiny talc powder and glucose solution is added to the rice during
A. Polishing
B. Glazing
C. Whitening
D. Hulling
Answer:B
114. In thresher, the percentage of healthy grain dropped from sieve with respect
to healthy grain received from main outlet is
A. Cylinder loss
B. Blower loss
C. Sieve loss
D. Visible loss
Answer:C
115. The minimum application rate with air blast sprayer for crchards may be
123. The harvesting of wheat, barley and grams are mostly done under
A. Immature condition
B. Mature condition
C. Over mature condition
D. Dry condition
Answer:C
130. Spattering of small soil particles, caused by raindrop impact on wet soil is
called as
136. The volume of liquid required for ground spraying of field crop is
A. 100 litres/ha
B. 200 litres/ha
C. 300 litres/ha
D. 400 litres/ha
Answer:D
138. The grain that is carried over the rear of the sieve with chaff and blown out of
the combine is
A. Cylinder loss
B. Rack loss
C. Sieve loss
D. None of these
Answer:C
139. The production of gas from one kilogram of wet dung in biogas plant is
A. 0.037 m3
B. 0.085 m3
C. 1.0 m3
D. 1.5 m3
Answer:A
156. In four-stroke cycle engine, one power stroke is obtained after every
A. Half revolution of crankshaft
B. One revolution of crankshaft
C. Two revolution of crankshaft
D. Three revolution of crankshaft
Answer:C
177. A soil consistency in the characteristics of the soil at various moisture content
when influenced by physical force is
A. Cohesion
B. Adhesion
C. Both (a) and (b)
D. None of these
Answer:C
181. Of the following the main parts of syndicator type thresher are
A. Corrugated flywheel
B. Serrated chopping knives
C. Closed cylinder casing
D. All are correct
Answer:D
182. When the knife section of cutter bar stops in the center of its guard after every
stroke is
A. Alignment
B. Registration
C. Reel index
D. Stroke length
Answer:B
184. A machine used to cut herbage crops and leave them in swath is
A. Reaper
B. Mower
C. Combine
D. Baler
197. The internal angle between the gangs of single action disc harrow is
A. Less than 90?
B. Exactly 90?
C. More than 90?
D. None of above
Answer:C
200. In bucket elevtors, the total stretch of belt under maximum load should not
exceed more than
A. 1-2 % of belt length
B. 1-2.5 % of belt length
C. 1-3% of belt length
D. 1-3.5% of belt length
Answer:A