Professional Documents
Culture Documents
Download Microelectronic Circuit Design 5th edition 2015 Richard C. Jaeger pdf full chapter
Download Microelectronic Circuit Design 5th edition 2015 Richard C. Jaeger pdf full chapter
Download Microelectronic Circuit Design 5th edition 2015 Richard C. Jaeger pdf full chapter
https://textbookfull.com/product/wideband-circuit-design-first-
edition-carlin/
https://textbookfull.com/product/design-of-biomedical-devices-
and-systems-4th-edition-richard-c-fries/
https://textbookfull.com/product/foundations-for-microstrip-
circuit-design-fourth-edition-edwards/
https://textbookfull.com/product/power-electronics-circuit-
analysis-and-design-issa-batarseh/
Microelectronic Circuits Adel S. Sedra
https://textbookfull.com/product/microelectronic-circuits-adel-s-
sedra/
https://textbookfull.com/product/electronic-design-automation-
for-ic-implementation-circuit-design-and-process-technology-2nd-
edition-luciano-lavagno/
https://textbookfull.com/product/microwave-integrated-circuit-
components-design-through-matlab-1st-edition-s-raghavan/
https://textbookfull.com/product/circuit-design-with-vhdl-the-
mit-press-3rd-edition-volnei-a-pedroni/
https://textbookfull.com/product/applied-international-
economics-5th-edition-richard-l-sprinkle/
Another random document with
no related content on Scribd:
Pivoted Searchlight Made of an Old
Milk Strainer
By JOHN J. SPAULDING
In the large farm kitchen, in the workshop, and even for firing a
small furnace, a coal hopper that will hold considerable coal, and
that can be rolled along the floor easily, is a convenience. Such an
arrangement, made from a section of galvanized-iron pipe, 10 in. in
diameter and 30 in. long is shown in the sketch. The pipe was cut at
one end, as shown, so that when the coal was poured into the
hopper, it would feed out. A truck, mounted on casters, was made,
12 in. wide, 5 in. high, and 25 in. long. The hopper was mounted on
one end of it, and bolted securely at the sides and end. The coal is
shoveled into the hopper at the bin, and the load pushed to the
furnace, where it can be easily used as needed. The construction
can be made larger for use with a coal scoop, in firing a boiler or
large furnace.—L. R. Markwood, Factoryville, Pa.
Taking Photographs in Falling Snow
Falling snowflakes in a camera photograph—the large feathery,
slow falling kind—often make an exquisitely beautiful picture out of a
commonplace scene. And while the great majority of the attempts to
get them prove failures, the photographer—usually an amateur-
needs only to provide an avenue in front of his lens a short distance,
that is free from falling flakes by the use of a shelter such as a tree
or porch. The slow snapshot necessary in cloudy weather will not
stop the motion of the flakes nearest the camera and these passing
through greater angles of space in equal length of time than those
farther away, will blur on the negative. We made some excellent
outdoor views in deep snow, while heavy snow was falling, with
flakes splendidly decorating the darker regions of figures and foliage,
by holding a felt hat and two umbrellas in a line in front of the
camera, and above the range of the lens.—J. Cecil Alter, Cheyenne,
Wyo.
A Double-Contact Vibrator
When the Vibrator Touches One Contact, the Coil on the Opposite Side
Attracts the Vibrator, This Process being Repeated Alternately
The Amateur can Practice the Morse Code Handily on This Sounder, Made
from a Buzzer
A practical use to which stumps, left from the felling of trees, are
put in a city park is as supports for lawn benches. This obviates the
need of grubbing them out, while the work of preparing them to
receive the seats is less than would be required to remove the
stumps. Of course, the location of the stump will determine whether
it is worth while as a support for a seat, or had better be grubbed out.
Many designs are possible, and the position and size of the stumps
available will suggest suitable construction. The woodwork for the
seats is simple, and the benches can be made removable for the
winter if desired.—C. L. Meller, Fargo, N. D.
A Hinged Box Cover Made without Hinges
When a wooden box with a hinged cover is desired, especially a
small one, hinges are not always at hand, and are sometimes
difficult to obtain. Under these circumstances a good substitute is to
make the box as shown in the sketch, using the extension of one
end and nails, or screws, driven through the back corners of the lid,
as a hinge arrangement. This makes the use of hinges unnecessary,
and is serviceable even for permanent use. Where hinges projecting
from the surface of the box are objectionable, this method of
construction is especially desirable. It is best to make the hinged
ends with the grain vertical, and to round off the hinged corners of
the lid slightly.—R. J. Rohn, Chicago, Ill.
Automatic Flash Light Snaps Chicken-Coop
Marauder
This Photographic Evidence Was Proof Positive as to the Identity of the
Thief in the Night
After the wire fence around the chicken house had been torn up,
and the place entered 13 nights in two weeks, I decided on more
preparedness. Various ways and means failed, so I used a
comparatively slight knowledge of photography in the process.
I mounted my flash lamp on a piece of board, 1 by 4 by 8 in. long,
and fastened this to a base, as shown. I attached a weight to the
lamp, which was supported by a hinged drop, halfway down the
upright board, which in turn was supported by a nail, to which was
attached a string. The flash was set off by a slight pull of the string,
which dropped the weight. This contrivance I concealed in the
chicken yard, and the camera in the chicken house. That night I
opened the lens of the camera in the dark, and attached the string to
a loose board in the fence. The next morning, before daybreak, I
closed the lens again. The flash had been set off during the night.
Also there were drops of blood on the ground. I could hardly wait
until the plate was developed. The result, as reproduced, was hardly
what I expected.—H. U. Scholz, Medford, Ore.
A Fishing-Tackle Outfit in a Shotgun Shell
At the camp or on the trail, an emergency fishing-tackle outfit is
almost as handy as matches, compass, and knife, and it may even
be the means of saving one’s life. A convenient way to carry such an
outfit is in two old shotgun shells, telescoped. The hooks, on a cork,
and the sinkers are fitted snugly into the shell. Several yards of line
are then wound on the outside. This outfit can be stowed into a
pocket handily, always ready for use.—E. Everett Buchanan, Jr.,
Elmira, N. Y.
A Split-Bamboo Lettering Pen
This Pen, Cut from a Piece of Bamboo and Fitted with a Spring Fountain
Device, Is Especially Useful for Marking Packages