Professional Documents
Culture Documents
Calibration Slim 3B6 - EN
Calibration Slim 3B6 - EN
• Open the cable winder door on the front of the jib with an Allen key.
Remove the electronics card from the cable winder and turn the white potentiometer gears
clockwise to the end of their stroke.
• Switch on.
• Support the machine on the stabilisers and in line with the chassis.
(06/07/2011) 80-04-M146EN
16
Electrical control and adjustment
• When the image shown above appears on the display, press the key
• When the image shown above appears on the display, press the key
• At this point the password setting page appears, press key several times to move the
asterisk placing it over the first 4, then with the arrow keys change the number 4
to number 2.
• After setting the first level password (that is the type of vehicle) press key and then the
pushbutton
80-04-M146EN (06/07/2011)
17
Electrical control and adjustment
• Fully retract the telescopic element and lower the jib to the maximum then press the
key and then push the index ( turtle / rabbit button )
• At this point you will have set the system minimum point.
80
• Fully raise the jib and extend it as far as possible.
• At this point you will have set the system maximum point.
(06/07/2011) 80-04-M146EN
18
Electrical control and adjustment
• Press the pushbutton and wait until DONE (finished) appears on the display.
80
80-04-M146EN (06/07/2011)