factors in the assessment of serviceability is load. For the evaluation of frame drift, ten-year recurrence interval winds are recommended due to the non-catastrophic nature of serviceability issues and because of the need to provide a standard consistent with day-to-day behavior and average perceptions. The 50-year recurrence interval winds that strength design wind loads are based upon are special events. In lieu of using the precision of a map with ten-year wind speed isobars, the authors recommend using 75 percent of 50-year wind pressure as a reasonable (plus or minus 5 percent) approximation of the ten-year wind pressures. The Commentary to Appendix B of ASCE 7-02 recommends 70 percent. For further discussion of suggested recurrence intervals for loads in serviceability designs, see Davenport (1975), Ellingwood (1989), Galambos and Ellingwood (1986), ISO Standard 6897 (1984), Hansen, Reed and Vanmarcke (1973), Irwin (1978), Irwin (1986) and the Commentary to Appendix B of ASCE 7-02. Foundation-Supported Cladding for Gravity Loads When vertical support along the foundation supports the cladding, there is no connection between frame and cladding for vertical loads and the limits on vertical deflection are: 1. Roof and floor beams must have deflections compatible with the type of vertical slip connections detailed to laterally support the cladding. 2. Roof beams must have deflections compatible with the perimeter termination of the roofing membrane to cladding. 3. Floor beams must have deflection compatible with the detailing between wall and floor finish. 4. Floor and roof members must have deflection compatible with the detail of ceilings and cladding. Because this method of vertical support is only useful for relatively short buildings (one or two stories), the shortening of columns is not a concern. However, it is possible that differential thermal expansion could be a concern and this requires care in detailing the joint between interior partitions and the cladding, requiring an isolation joint.