Professional Documents
Culture Documents
Shy 1st Edition Ashish Rastogi Full Chapter
Shy 1st Edition Ashish Rastogi Full Chapter
https://ebookmeta.com/product/rainbow-primary-composition-
book-1st-edition-shy-panda-notebooks/
https://ebookmeta.com/product/puck-shy-carolina-comets-1-1st-
edition-teagan-hunter/
https://ebookmeta.com/product/exploring-macos-a-journey-through-
the-mac-ecosystem-1st-edition-sagar-rastogi/
https://ebookmeta.com/product/physics-galaxy-mechanics-vol-i-1st-
edition-ashish-arora/
Managing Risks in Digital Transformation 1st Edition
Ashish Kumar
https://ebookmeta.com/product/managing-risks-in-digital-
transformation-1st-edition-ashish-kumar/
https://ebookmeta.com/product/exposure-milfs-unleash-a-shy-stud-
the-first-collection-1st-edition-morgan-troy/
https://ebookmeta.com/product/a-prayer-for-the-crown-shy-monk-
robot-2-1st-edition-becky-chambers/
https://ebookmeta.com/product/a-prayer-for-the-crown-shy-monk-
robot-2-1st-edition-becky-chambers-2/
https://ebookmeta.com/product/synthesis-of-medicinal-agents-from-
plants-1st-edition-ashish-tewari-editor/
Another random document with
no related content on Scribd:
Asbestos Table Mats Reinforced with Wire
Netting
Ordinarily heavy pieces of sheet asbestos are used for the mats
placed under hot dishes on the dining table. These are easily broken
if bent, and a simple method of overcoming this breakage is to make
mats as follows: Cut two pieces of sheet asbestos, each about one-
half the thickness of that usually used, one having about ³⁄₄ in.
around the edge which may be used as a binder in pasting the
sheets together. Cut notches into this edge, at intervals of about 2
in., and insert a disk of wire window screening between the pieces of
asbestos. Turn the edges of the larger piece over and paste in place.
Device for Corrugating Strips
¶Wire mesh is useful for drawer bottoms in tool cases where dirt is
likely to accumulate.
Reel for Use with Seed-Planting Guide String
To save groping about in the dark for my flash light when suddenly
awakened in the night, I devised the arrangement shown in the
sketch and by which a “flash” is used as a wall night light, without
lessening its common uses. The holder B and the board A are of
wood, and into the box is fitted a metal clip, C, to hold the light. A
round hole of proper size is cut through the top of the box and the
light set through it so that the bottom end rests in the clip, the tin
ferrule pressing against it firmly. A light spring, D, makes contact with
the upper terminal of the push switch without closing it. The
apparatus is fastened to the wall, and insulated wires, soldered, one
to the clip C, and the other to the spring D, are connected to a switch
placed in a convenient position. This switch replaces that on the
light. The ceiling serves to reflect and distribute the light rays.—B. L.
Dobbins, Harwich, Mass.
Pie-Plate Gas Heater
A satisfactory gas heater to take the chill out of the air in a small
room by fitting a pie plate over a gas burner was made by me, as
shown in the sketch. The wires which formerly held the glass shade
were fitted into holes punched in the rim of the plate. It could thus be
removed quickly when not needed and the glass shade put back in
place.—Morris Tinsky, Chicago, Illinois.
A Folding Table with Split-Bamboo Tray for Top