Professional Documents
Culture Documents
Table 1
Table 1
Table 1
Coating Specification for New & Existing Constructions of Offshore and Onshore Structures SP-1170 (Rev.0)
TABLE 1
INSPECTION AND TESTS
4 Coating Application
(1)
Dust test ISO8502-3 Spot Checks
Cleaning of each
4.2
coat Water soluble ISO8502-6 (1) 2
Spot Checks (20 mg/m2)
salts ISO8502-9
ASTM D 4541
To be performed on test panels
4.5 Adhesion TYPE III, IV or Spot Checks (1)
V adhesion Minimum value 5MPa
tester
No sagging, contaminations, orange
Visual and
4.6 Visual examination 100% of surfaces peel, cracking, blistering, rust,
ISO 46281÷6
damages and any other defects
NACE SP0188
4.7 Holiday Testing (2) 100% of surface Free of holidays and pinholes
Note:
(1) Number and location shall be defined and agreed during pre-job meeting.
(2) The test shall be performed according to the following requirements:
microns Low-Voltage Wet sponge testing according to the requirements of standard NACE SP0188
DFT > 500 microns High-Voltage Spark testing according to the voltage values listed in Table 1 of standard NACE
SP0188
Copyright © 2017 Abu Dhabi Marine Operating Company ADMA-OPCO. All rights reserved
Abu Dhabi Marine Operating Company
Coating Specification for New & Existing Constructions of Offshore and Onshore Structures SP-1170 (Rev.0)
TABLE 1
INSPECTION AND TESTS
1 Preliminary Tests
Distilled water
3.2 Welding flux removal 100% pH neutral (6.5 7.5)
and litmus paper
Specification Requirements
3.4 Protection of fittings and accessories Visual 100%
(Ref. Item 3.14)
3.5 Compressed air ASTMD4285 Every 2 hours Free of oil and moisture
To meet BS EN 14594
3.6 Breathing air XX Twice per day
requirements
3.7 Abrasive materials ASTM D4940 Every Batch 300 μS/cm at 20°C
Maximum rating
3.11 Dust test ISO8502-3 Spot Checks (1)
ISO8502-6
Spot Checks (1)
2
3.12 Water soluble salts (20 mg/m2)
ISO8502-9
Copyright © 2017 Abu Dhabi Marine Operating Company ADMA-OPCO. All rights reserved