Professional Documents
Culture Documents
Site Investigation
Site Investigation
Site Investigation
FOUNDATION ENGINEERING
هندسة األساسات
COURSE CODE: STE 423
FOUNDATION ENGINEERING
CHAPTER (1)
SITE INVESTIGATION
استكشاف الموقع
Ds1
Ds2 ≈ 0.1 Ds1
D
ممكن أن يتم تحديد عمق الجسة
بالعمق الذى تصل عنده قيمة
اإلجهادات إلى 0.10من قيمة
اإلجهادات عند منسوب
التأسيس
1 February 2014
Ds2 Site Investigation, Tarek Nageeb 14
ii- Distribution of Borings for
Different Structures
تحديد عدد الجسات وتوزيعها
Type of Structure Spacing (m)
300 m2, with 2 min. for each
Multistory Building
structure
One story industrial building 300 – 500 m2
Highways 250 – 500 linear meter
Residential sub-divisions 200 x 200 up to 400 x 400
Dams 50 up to 200 m
+ + +
+ + +
+ + +
+ + +
Tripod
سبيه Sand Bags or Weights
Wire Rope أوزان أو شكاير رمل
سلك Wooden Platform with Handle
to be Operated Manually
Winch منصه خشبية بيد تدار يدويا
ونش
Drilling Rod
أداة حفر
Casing Pipes, f 4" to 6"
of 1.50 to 2.0 m length
بوصه6 إلى4 مواسير قطر من
متر2 إلى1.5 وطول من
المطرقة أو
المنداله
1 February 2014 Site Investigation, Tarek Nageeb 61
Standard Penetration Test (SPT)
1- Standard Penetration Test (SPT):
- 140 lb hammer is dropped over a 1.5 ft long
standard spoon.
- The hammer drop height is 2.5 ft.
- The spoon is driven 1.5 ft in three stages, each
stage is 6 inch long.
- SPT (N) value = Number of hammer drops that
will drive the standard spoon 1 ft long into the
soil, if N > 50 means refusal.
- The first reading is neglected (seating), the 2nd
and 3rd readings are summed up to give N.
1 February 2014 Site Investigation, Tarek Nageeb 62
اختبار االختراق القياسى
طريقة إجراء االختبار (االختبار يجرى أثناء أخذ الجسة):
-يتم إسقاط مطرقة وزنها 140رطل ( 62.5كجم) من ارتفاع
مقداره 2.50قدم ( 75سم) على ملعقة قياسية ارتفاعها 1.50
قدم ( 45سم).
-يتم دق تلك المعلقة على ثالثة مراحل طول كل مرحلة 6بوصه
( 15سم).
-يتم إهمال قراءة الـ 15سم األولى وتسمى ).(Seating
-يتم جمع القرائتين الثانية والثالثة ومجموعهم يسمى ).(N
-قراءة = (SPT) Nعدد الدقات التى تتسبب فى اختراق الملعقة
القياسية للتربة لمسافة 30سم.
-إذا كانت القراءة ) (Nأكبر من 50دقة تسمى امتناع ويمكن فى
هذه الحالة كتابة الرقم الحقيقى أو كتابة > .50
1 February 2014 Site Investigation, Tarek Nageeb 63
Standard Penetration Test (SPT)
SAND
CLAY
N
1 February 2014 Site
Site Investigation, Tarek Nageeb 69 69
Relation between SPT (N) value and unconfined
compressive strength of clay
SPT (N) Consistency qu (kg/cm2)
<2 Very soft 0.25
2–4 Soft 0.25 – 0.50
4–8 Medium Stiff 0.50 – 1.00
8 – 15 Stiff 1.00 – 2.00
15 – 30 Very Stiff 2.00 – 4.00
> 30 Hard > 4.00
Cone
Jack
Plate
جاك هيدروليكى
لوح التحميل
B 1.5 B
1 February 2014
Plate Load Test Setup
Site Investigation, Tarek Nageeb 95
6- Plate Load Test اختبار لوح التحميل
-Used in homogeneous soils يستخدم فى التربة المتجانسة
-Theoretical affected zone = 2 x Plate diameter
قطر اللوح2 = ) الحيز الذى يؤثر فيه لوح التحميل (نظريا-
-Loading till sudden yield, or 25 mm settlement, or
negligible settlements with load increase, or 3 times
working load.
مم أو توقف25 يتم التحميل لحين حدوث خضوع مفاجى للتربة أو هبوط-
.زيادة الهبوط أو حتى ثالثة أضعاف الحمل التصميمى
-Loading is performed is steps followed by unloading
يتم التحميل على خطوات يتبعه رفع الحمل على خطوات أيضا-
-Reloading may be applied in special cases.
. يمكن إعادة التحميل مرة أخرى فى بعض الحاالت الخاصة-
1 February 2014 Site Investigation, Tarek Nageeb 96
qult (b) qult (a) Stress
S = 25 mm
E 1 - m
Vp
g /g 1 - 2 m 1 m
Where:
E = Soil Young’s modulus )kN/m2); معامل التربة
g = Soil unit weight (kN/m3); كثافة التربة
g = Acceleration of gravity (m/sec2); عجلة الجاذبية األرضية
m = Soil Poisson’s ratio )-). نسبة بواسون للتربة
1 February 2014 Site Investigation, Tarek Nageeb 102
7-1- Seismic Refraction Method
- A graph is plot between the wave arrival times (t1, t2,
and t3) against the distance between the wave source
and recording point (x1, x2, x3).
يتم رسم عالقة بين أزمنة وصول الموجات والمسافات بين مصدر-
bc وab وعلى ذلك تكون ميول الخطوط.الموجات وأماكن المجسات
I, II, III خالل الطبقاتV1, V2, and V3 هى السرعاتcd و
- The slope of the lines ab, bc, and cd will be the wave
velocities, V1, V2, and V3, in layers I, II, and III
respectively, as follows:
1 1
Slope of ab Slope of bc etc.
V1 V2
1 February 2014 Site Investigation, Tarek Nageeb 103
1 February 2014 Site Investigation, Tarek Nageeb 104
7-1- Seismic Refraction Method
- The thickness of layers can be obtained by:
: يتم تحديد سمك طبقات التربة من العالقات التالية-
V2 - V1
Z1 0.50 xc
V2 V1
2
V3 - V12
V3 V2
Z 2 0.50 Ti2 - 2 Z1 2 2
V V
3 1 V3 - V2
Vs
L
Vs
G Vs2
g
G
t g g g
Where:
Vs: is the shear wave velocity. سرعة موجة القص
G: is the soil shear modulus, used mostly in soil
dynamics. معامل القص للتربة ويستخدم فى تطبيقات ديناميكا التربة
k
Q L
log e
2.0 L H r
B- Open End Test: اختبار النفاذية ذو النهاية المفتوحة
Q
k
5.5 r H
Where:
Q: Constant rate of flow into the hole; معدل السريان للحفرة
r: Radius of hole;قطر الحفرة
L: Length of hole portion under test;طول الجزء المختبر من الحفرة
H: Difference in the pressure head. فرق ضغط المياه
1 February 2014 Site Investigation, Tarek Nageeb 112
8- Field Permeability Test
Testing Theory
Experience