Professional Documents
Culture Documents
MP-08 - Bumper Hose Change
MP-08 - Bumper Hose Change
2. Inform Driller to Isolate Switched and Trapped pressure 2C M Bleed of pressure from pump discharge & stand
PUMP, Bleed of any trapped valves Pump turn on while change 3B M pipes
pressure, Lock out pump Lock / Tag out the pump. Put safety pin on
Overcome pressure from other 1C L local switch of DC motor
pump Make sure discharge valve is fully closed
3. Line up other stand pipe and Valves & Finger/hand injuries 1C L Make sure the valves are fully closed
circulate at low rate manifold Pinch points
4. Hold Bumper hose properly Bumper hose Finger/hand injuries 2C M Hold the Bumper hose with slings & stay away
and remove the safety chain Slings, shackles, Pinch points, from the Bumper hose
chain block or Bumper hose falling 1C L Make sure lifting equipment in good conditions.
crane
5. Disconnect the Bumper hose Hammer wrench, Finger/hand injuries, back 2D M Ensure the Hammer, wrench in good condition and
form down side (under hammer, chain strain used properly.
Cantilever) block or crane Pinch points 2D M Use the correct Hammer, wrench. Clean hammer
Liner falling. handle from grease or mud
Personnel falling down 1C L Ensure Bumper hose holed correctly & do not stay
under the Bumper hose while disconnecting it.
1C M Wear work vest and safety harness
6. Disconnect the Bumper hose Hammer wrench, Finger/hand injuries, back 2D M Ensure the Hammer, wrench in good condition and
form up side (under rig floor) hammer, chain strain used properly.
block or crane 2D M Use the correct Hammer, wrench. Clean hammer
Pinch points handle from grease or mud
1C M Ensure Bumper hose holed correctly & do not stay
Liner falling. under the Bumper hose while disconnecting it.
767776087.doc Page 1 of 2
MUD PUMP (MP)
7. Connect Bumper hose form Hammer wrench, Finger/hand injuries, back 2D M Ensure the Hammer, wrench in good condition and
down side (under Cantilever) hammer, chain strain used properly.
block or crane Pinch points 2D M Use the correct Hammer, wrench. Clean hammer
handle from grease or mud
Liner falling. 1C L Ensure Bumper hose holed correctly & do not stay
under the Bumper hose while connecting it.
Slip and fall down 1C L Wear work vest and safety harness
8. Connect Bumper hose form up Hammer wrench, Finger/hand injuries, back 2D M Ensure the Hammer, wrench in good condition and
side (under rig floor) hammer, chain strain used properly.
block or crane Pinch points 2D M Use the correct Hammer, wrench. Clean hammer
handle from grease or mud
Liner falling. 1C L Ensure Bumper hose holed correctly & do not stay
under the Bumper hose while connecting it.
9. Secure hose properly with safety Safety chains Pinch points, stuck in 2B M Stay away from opening holes
chains and shackles between
10. Cover any opening holes around Grating Pinch points, stuck in 2B M Never put your fingers in pinch point
the hose between
11. Pressure testing bumper hose Leaks under high pressure 2C M Re-tight the hose connection to proper value
using heavy hammer, remove all hand tools
Line burst under high 2C M Check relief valve setting.
pressure Personnel to stay away from the pump
767776087.doc Page 2 of 2