Professional Documents
Culture Documents
Saic D 2005
Saic D 2005
EQUIPMENT ID NUMBER(S) EQUIPMENT DESCRIPTION EQPT CODE SYSTEM ID. PLANT NO.
LAYOUT DRAWING NUMBER REV. NO. PURCHASE ORDER NUMBER EC / PMCC / MCC NO.
SCHEDULED INSPECTION DATE & TIME ACTUAL INSPECTION DATE & TIME QUANTITY INSP. MH's SPENT TRAVEL TIME
SAUDI ARAMCO USE ONLY
SAUDI ARAMCO TIP NUMBER SAUDI ARAMCO ACTIVITY NUMBER WORK PERMIT REQUIRED?
ITEM
ACCEPTANCE CRITERIA REFERENCE PASS FAIL N/A RE-INSP DATE
No.
Equipment storage, handling and preservation procedure was submitted Sch Q, Att IV
A1
and approved by S.Aramco . Project Specific
Vessels that were not externally coated at the fabrication shop are
provided with a hard temporary preservative appropriate for the metallurgy 32-SAMSS-004
A2
of the vessel and can be easily removed at site prior to surface Par. 19.3.1 (a)
preparation & application of Saudi Aramco coating & paint system.
Stainless Steel vessels, which were shipped via ocean freight, are
32-SAMSS-004
A3 protected using a temporary protective system compatible with stainless
Par. 19.3.1(c)
steel & suitable outdoor exposure.
Vessels that are partially shop fabricated and/or likely to suffer from
distortion have the following protection:
a) Adequate* bracing 32-SAMSS-004
A4
b) All open ends are covered to prevent ingress of dirt and other Par. 19.1.4
foreign matters.
The internal of vessel is completely and thoroughly dried and cleaned 32-SAMSS-004
A5
from all loose scales, weld slag, dirt and debris. Par. 19.1.2
Vessels internally protected by corrosion inhibitor are sealed vapor tight 32-SAMSS-004
A7
using metallic covers. Par. 19.2.2.6
Telltale holes in reinforcing pads shall be protected with wooden plugs or 32-SAMSS-004
A9
packed with rust preventative grease. Par. 19.3.2
Flanges with permanent blind flanges or covers shall be secured with the 32-SAMSS-004
A12
gaskets and bolting specified for service. Par. 19.3.5
A General Requirements (Vessels) … Use the latest Revision of 32-SAMSS-004 along with this checklist
Prepare the surface and apply primer and final coatings as per the Saudi 32-SAMSS-004
A3
Aramco paint and coating system. Par. 19.3.1 (b)
REMARKS:
Attachment 1 . 32-SAMSS-030 Small Metallic Atmospheric Storage Tank Protection and Preservation Reqmts
REFERENCE DOCUMENTS:
1- 32-SAMSS-004 -- Manufacture of Pressure Vessels, (1 February 2018)
2- 32-SAMSS-030, Manufacture of Small Metallic Atmospheric Storage Tank (31 December 2016)
Contractor / Third-Party Saudi Aramco
Construction Representative* PMT Representative
Work is Complete and Ready for Inspection: T&I Witnessed QC Record Reviewed Work Verified
Name, Initials and Date: Name, Initials and Date: