Professional Documents
Culture Documents
Body Fever Scanner Field Application Setup (New)
Body Fever Scanner Field Application Setup (New)
Body Fever Scanner Field Application Setup (New)
∙ Camera height needs to be about 180 ~ ∙ Best to setup the camera at a tilting
200cm higher than average people down angle of 10~15°
height
4
Equipment Installation Requirement
• PC Computer: CPU Intel I5 and above , 4GB RAM, 500GB space for system software, 1TB for
recording data storage, Screen, WIN10 OS, Keyboard/Mouse
• Network Cable:1 pcs (length depend on the PC and the camera distance)
• Stand: 1/4 "standard connection screw, camera height needs to be about 180 ~ 200cm higher
than average people height
5
Software installation
6
Main Console interface
7
System Setup Management
8
Add IP-Camera
9
Alarm Linkage Setup—Alarm Sound
In the setup at the bottom right corner of the T-Guard main menu,
•
1
set the alarm linkage in order to effectively and quickly identify the
triggered hot target.
• After entering Setup, select "Alarm linkage settings", and add the new one → Heat source
event → Alarm sound → Alarm sound file (select the built-in sound file or import it
yourself), and then press OK → Save to complete the setting.
2
• Note that the
(Repeat Play) 6
option ( 8 ) in 5
step 4 needs to
4
be unchecked.
3
10 9
10
Alarm Linkage Setup—Photo Capture
• After entering Setup menu, select "Alarm linkage settings", and then click Add → Heat
source event → Take photo → Link Camera, then click the corresponding device, and then
press OK → Apply to complete the setting.
5
4
8
9 7
11
Alarm Linkage Setup—Photo Capture
• Click "System Settings", check "Show photos taken in the lower right corner of the lens"
below, and uncheck "Enable watchdog", press Apply and close the window when finished.
4 5
12
Thermal Image Setup—Overlay Image Setting
• This function is used to make the visible camera image and the thermal image overlap and
display on the same screen.
• Move the cursor to the position of the image display screen, right-click, and select "Thermal
Image Setting" from the menu
• As shown in the figure below, move the cursor over the thermal imager and hold it down,
then drag the thermal image to superimpose the visible image
• In order to clearly identify the person being detected, you must move the pull bar of
"Thermal Picture Filter" and "Superimposed Transparency" to the far left
Thermal Image
• After entering the setting menu of the thermal image, you can refer to the setting methods
and parameters in the red box in the figure below to check and fill in the values.
14
Effective Screening Temperature Value Setting
• In order to effectively screen those suspected of
having a fever, the system compares the actual
body temperature before the rush hour in the
morning, noon, and night, as the basis for
setting the screening temperature.
• The red square in the "Select Detection Area" screen indicates that when a person or
object passes through the area, the temperature information is collected.
16
System Setup—Parameter Setting Backup
• When the T-Guard software version needs to be reinstalled due to an update, the
previously set configuration files and parameters can be backed up by exporting the setting.
17
System Setup—Parameter Setting Import
18
Thank You!