Professional Documents
Culture Documents
26 July
26 July
26 July
Quotes
USE MAX DISCOUNT CODE Y579
The super-plasticizers are used as admixture for the following
purpose:
(a) To decrease the cement content
(b) To disperse particles, remove air bubbles and to retard setting
(c) To disperse particles only
(d) To decrease the setting time
USE MAX DISCOUNT CODE Y579
TYPES OF CHEMICAL
The super-plasticizers are ADMIXTURES
used as admixture for the following
purpose:
These are normally
(a) To decrease categorised
the cement content as follows –
1.(b)Plasticizers or water
To disperse particles, reducing
remove agents
air bubbles and to retard setting
2.(c)Superplasticizers or high range water reducers
To disperse particles only
3. Accelerators
(d) To decrease the setting time
4. Retarders
5. Air entrainers
6. Others
USE MAX DISCOUNT CODE Y579
Fat lime is used for best performance in.
(a) Masonry mortar
(b) Lime concrete
(c) Plaster work
B
(d) None
USE MAX DISCOUNT CODE Y579
The most commonly used material in the production of cement is-
(a) Graphite
(b) Sand stone
(c) Slate
(d) Lime stone
USE MAX DISCOUNT CODE Y579
Which of the following evoporimeter is adopted by Indian
standard IS: 5973-1970 for estimation of evaporation?
(a) Pan of 1.22 m in diameter and 25.5 cm in depth.
-
When liquefaction occurs, the strength of the soil decreases, and, the ability of a
soil deposit to support foundations for buildings is reduced.
Liquefied soil also exerts higher pressure on retaining walls, which can cause them
to tilt or slide. This movement can cause settlement of the retained soil.
Increased water pressure can also trigger landslides and cause the collapse of
dams.
USE MAX DISCOUNT CODE Y579
What will be the value of maximum shear force for the given beam
in figure below?
++11!!!kwim
(a) 18 kN.
(b) 06 kN.
(c) 09 kN.
M -
6m -
(d) 27 kN.
USE MAX DISCOUNT CODE Y579
A rainfall of 2.0 cm occurred in a 4-hour storm and the 𝝋-index
was 0.25 cm/hour. What was the rainfall excess?
(a) 1.0 cm.
(b) 2.25 cm.
(c) 2.0 cm.
(d) 1.75 cm.
USE MAX DISCOUNT CODE Y579
Which of the following expression represents the angularity
number for the aggregate, used in highway construction?
C = weight of cylinder, W = weight of aggregate in the cylinder, G =
specific gravity of aggregate.
𝟏𝟎𝟎𝑮
(a) 67 – 𝑪𝑾
𝟔𝟕𝑮
(b) 100 –
𝑪𝑮
𝟏𝟎𝟎𝑪
(c) 67 –
𝑾𝑮
Se 𝟏𝟎𝟎𝑾
(d) 67 –
𝑪𝑮
USE MAX DISCOUNT CODE Y579
What should be the maximum spacing between the expansion
joints with rough interface layer, in cement concrete pavements as
per IRC?
(a) 100 m.
(b) 60 m.
(c) 140 m.
(d) 50 m.
USE MAX DISCOUNT CODE Y579
The delta of a crop is 0.864 m and the base period is 130 days.
What is het duty of the crop (in hectares/cumec)?
(a) 864
(b) 1300
(c) 130
(d) 13000
USE MAX DISCOUNT CODE Y579
In highway pavement design, the ratio of contact pressure to tyre
pressure is known as:
(a) Stress ratio factor
(b) Rigidity factor
If
solid waste.
(b) Rubbish includes rags paper pieces, broken pieces of glass and
furniture, card-boards, etc.
(c) Rubbish includes all non-putrescible wastes except ashes.
(d) Rubbish has a density varying between 50 to 400 kg/m³
USE MAX DISCOUNT CODE Y579
Which of the following pairs is not correctly matched regarding
types of road surface and IRC recommended value of camber in
very heavy rainfall range place?
(a) Water bound macadam, and gravel pavement → 1 in 33.
(b) Earth surface → 1 in 25
(c) Cement concrete and high type bituminous surface → 1 in 50
④
Mr
the coefficient of volume
1 lochange.
+