and compacting an aggregate subbase course on a prepared subgrade in accordance with this Specification and the lines, grades and cross-sections shown on the Plans, or as directed bythe Engineer. *hard, durable particles or fragments of 1.crushed stone 2. crushed slag 3. crushed or natural gravel 4. filler of natural or crushed sand or other finely divided mineral matter. The composite material shall be free from vegetable matter and lumps or balls of clay, and shall be of such nature that it can be compacted readily to form a firm, stable subbase Sieve Designation Standard Alternate US Standards Mass Percent Passing 50 2” 100 25 1” 55-85 10 3/8” 40-75 0.75 No. 200 0-12 1. The fraction passing the 0.75 mm (200) sieve should not be greater than 2/3 of the fraction passing the 0.425 mm No. 40 sieve 2. The fraction passing the 0.425mm sieve should have a liquid limit not greater than 25 and plastic index not more than 12. 3. The coarse portion retained on a 3mm sieve should have a mass percent of wear not to exceed 5o by the Los Angeles Abrasion Tests. 1. Preparation of existing Surface 2. Placing 3. Spreading and Compacting 4. Trial Sections 5. Tolerances Before placing the sub-base materials, the existing surface must be graded and finished The aggregate sub base material shall be placed at a uniform mixture on a prepared sub grade in a quantity in which it will provide the desired compacted thickness. When uniformly mixed, the mixture shall be spread to the plan thickness, for compaction Before the subbase construction is started , spreading and compacting trial is done , in order to ensure suitability of materials and equipment to be used. ALLOWABLE TOLERANCES Permitted Variation from Design ± 20 mm THICKNESS OF LAYER Permitted Variation from Design +10 mm LEVEL OF SURFACE -20 mm Permitted Surface Irregularity 20mm Measured by 3-m straight- edge Permitted Variation from Design ± 0.3% CROSSFALL OR CAMBER Permitted Variation from Design ± 0.1% LONGITUDINAL GRADE over 25m in length Presented by: ▪ LESTER L. MAGBUTONG