Professional Documents
Culture Documents
Functional Test of The LP Fuel Shut Off Valves
Functional Test of The LP Fuel Shut Off Valves
Functional Test of The LP Fuel Shut Off Valves
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
Task 28-24-00-720-001-A
Functional Test of the LP Fuel Shut Off Valves
WARNING: PUT THE SAFETY DEVICES AND THE WARNING NOTICES IN POSITION BEFORE YOU
START A TASK ON OR NEAR:
• THE FLIGHT CONTROLS
• THE FLIGHT CONTROL SURFACES
• THE LANDING GEAR AND THE RELATED DOORS
• COMPONENTS THAT MOVE.
MOVEMENT OF COMPONENTS CAN KILL OR CAUSE INJURY TO PERSONS AND/OR CAN
CAUSE DAMAGE TO THE EQUIPMENT.
WARNING: BE CAREFUL WHEN YOU USE CONSUMABLE MATERIALS. OBEY THE MATERIAL
MANUFACTURER'S INSTRUCTIONS AND YOUR LOCAL REGULATIONS.
FIN 12QM , 13QM
1. Reason for the Job
NOTE: Two persons are necessary to do this procedure, one person in the cockpit to operate the
fuel pumps and one person at the engine.
2. Job Set-up Information
A. Fixtures, Tools, Test and Support Equipment
REFERENCE QTY DESIGNATION
No specific AR ACCESS PLATFORM 3M (10 FT)
No specific AR CONTAINER 200 L (53 USGAL)
No specific AR SAFETY BARRIER(S)
No specific AR SAFETY CLIP - CIRCUIT BREAKER
No specific AR WARNING NOTICE(S)
** On A/C 851-908 911-999
No specific Torque wrench: range
to between 60 and 70 LBF.IN (0.68 and 0.79 M.DAN)
** On A/C 154-200 246-300 351-352 356-356 358-372 378-379 381-425 427-428 430-433 435-450
501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529 531-536 540-550 561-567
571-571 582-600
No specific Torque wrench: range
to between 0.51 and 0.62 M.DAN (45.13 and 54.87 LBF.IN)
** On A/C 001-009 011-050 101-150 605-608 610-611 615-709 712-712 717-718 725-725 729-750
801-850
No specific Torque wrench: range
to between 1.24 and 1.36 M.DAN (109.73 and 120.35 LBF.IN)
** On A/C ALL
B. Consumable Materials
REFERENCE DESIGNATION
** On A/C 154-200 246-300 351-352 356-356 358-372 378-379 381-425 427-428 430-433 435-450
501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529 531-536 540-550 561-567
571-571 582-600
Material No: CP5070 vaseline
Material No: CP8001 lockwire 0.032 in. (0.8 mm) dia.
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 1 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
** On A/C ALL
C. Work Zones and Access Panels
ZONE/ACCESS ZONE DESCRIPTION
** On A/C 001-009 011-050 101-150 154-200 246-300 351-352 356-356 358-372 378-379 381-425
427-428 430-433 435-450 501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529
531-536 540-550 561-567 571-571 582-600 605-608 610-611 615-709 712-712 717-718 725-725
729-750 801-850
622AB
** On A/C 851-908 911-999
622XB
** On A/C ALL
FOR 12QM (VALVE-LP FUEL, ENG 1)
** On A/C 851-908 911-999
522XB
** On A/C 001-009 011-050 101-150 154-200 246-300 351-352 356-356 358-372 378-379 381-425
427-428 430-433 435-450 501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529
531-536 540-550 561-567 571-571 582-600 605-608 610-611 615-709 712-712 717-718 725-725
729-750 801-850
522AB
** On A/C ALL
FOR 13QM (VALVE-LP FUEL, ENG 2)
** On A/C 001-009 011-050 101-150 154-200 246-300 351-352 356-356 358-372 378-379 381-425
427-428 430-433 435-450 501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529
531-536 540-550 561-567 571-571 582-600 605-608 610-611 615-709 712-712 717-718 725-725
729-750 801-850
622AB
** On A/C 851-908 911-999
622XB
** On A/C ALL
D. Expendable Parts
FIG.ITEM DESIGNATION IPC-CSN
** On A/C 851-908 911-999
2 PACKING 73-11-02-01-280
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 2 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
** On A/C 154-200 246-300 351-352 356-356 358-372 378-379 381-425 427-428 430-433 435-450
501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529 531-536 540-550 561-567
571-571 582-600
2 PACKING 73-11-10-01-290
** On A/C 001-009 011-050 101-150 605-608 610-611 615-709 712-712 717-718 725-725 729-750
801-850
1 PACKING 73-12-42-80-090
** On A/C ALL
E. Referenced Information
REFERENCE DESIGNATION
24-41-00-861-002-A Energize the Aircraft Electrical Circuits from the External Power
24-41-00-861-002-A-01 Energize the Aircraft Electrical Circuits from the APU
24-41-00-861-002-A-02 Energize the Aircraft Electrical Circuits from Engine 1(2)
24-41-00-862-002-A De-energize the Aircraft Electrical Circuits Supplied from the External
Power
24-41-00-862-002-A-01 De-energize the Aircraft Electrical Circuits Supplied from the APU
24-41-00-862-002-A-02 De-energize the Aircraft Electrical Circuits Supplied from the Engine
1(2)
27-80-00-866-004-A Extending the Slats on the Ground
27-80-00-866-005-A Retracting the Slats on the Ground
28-00-00-910-001-A Fuel Safety Procedures
31-60-00-860-001-A EIS Start Procedure
57-41-37-000-004-A Removal of the Pressure Relief Panels
57-41-37-400-002-A Installation of the Pressure Relief Panels
** On A/C 001-009 011-050 101-150 605-608 610-611 615-709 712-712 717-718 725-725 729-750
801-850
70-23-11-911-013-A General Torque Tightening Techniques
70-23-13-911-010-A Procedures for the Installation of Preformed Packings
71-13-00-010-010-A Opening of the Fan Cowls 437AL(447AL),438AR(448AR)
** On A/C 154-200 246-300 351-352 356-356 358-372 378-379 381-425 427-428 430-433 435-450
501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529 531-536 540-550 561-567
571-571 582-600
71-13-00-010-040-B Opening of the Fan Cowl Doors
** On A/C 851-908 911-999
71-13-00-010-802-A Opening of the Fan Cowl Doors
** On A/C 001-009 011-050 101-150 605-608 610-611 615-709 712-712 717-718 725-725 729-750
801-850
71-13-00-410-010-A Closing of the Fan Cowls 437AL(447AL),438AR(448AR)
** On A/C 154-200 246-300 351-352 356-356 358-372 378-379 381-425 427-428 430-433 435-450
501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529 531-536 540-550 561-567
571-571 582-600
71-13-00-410-040-B Closing of the Fan Cowl Doors
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 3 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
** On A/C 001-009 011-050 101-150 154-200 246-300 351-352 356-356 358-360 501-501
503-504 506-506 508-508 510-512 517-525 527-527 529-529 531-536 540-550 561-567
571-571 582-600 605-608 610-611 615-709 712-712 717-718 725-725 729-750
(Ref. Fig 28-24-00-991-00200-B - Component Location - Cockpit)
** On A/C ALL
** On A/C 001-009 011-050 101-150 605-608 610-611 615-709 712-712 717-718 725-725
729-750 801-850
(Ref. Fig 28-24-00-991-00100-B - Component Location and Detail)
** On A/C ALL
** On A/C 154-200 246-300 351-352 356-356 358-372 378-379 381-425 427-428 430-433
435-450 501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529 531-536
540-550 561-567 571-571 582-600 851-908 911-999
(Ref. Fig 28-24-00-991-00100-A - Component Location and Detail)
** On A/C ALL
** On A/C 378-379
(Ref. Fig 28-24-00-991-00200-L - Component Location - Cockpit)
** On A/C ALL
** On A/C 001-009 011-050 101-150 605-608 610-611 615-709 712-712 717-718 725-725
729-750 801-850
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 4 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
** On A/C 154-200 246-300 351-352 356-356 358-372 378-379 381-425 427-428 430-433
435-450 501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529 531-536
540-550 561-567 571-571 582-600
(Ref. Fig 28-24-00-991-01300-C - Fuel Drain Plug - Location and Detail)
** On A/C ALL
FOR 12QM (VALVE-LP FUEL, ENG 1)
57-41-37-400-002-A Installation of the Pressure Relief Panels
3. Job Set-up
SUBTASK 28-24-00-941-058-A
A. Safety Precautions
WARNING: OBEY THE FUEL SAFETY PROCEDURES. THIS CAN PREVENT INJURY AND
DAMAGE.
(1) You must obey the fuel safety procedures when you do work on the fuel system (Ref. TASK
28-00-00-910-001-A).
(2) Put the SAFETY BARRIER(S) in position.
(3) Put a WARNING NOTICE(S) in the cockpit to tell persons not to operate the APU or bleed air.
** On A/C 001-009 011-050 101-150 154-200 246-300 351-352 356-356 358-372 378-379
381-425 427-428 430-433 435-450 501-501 503-504 506-506 508-508 510-512 517-525
527-527 529-529 531-536 540-550 561-567 571-571 582-600 605-608 610-611 615-709
712-712 717-718 725-725 729-750 801-850
SUBTASK 28-24-00-010-050-A
B. Get Access
(1) Put the ACCESS PLATFORM 3M (10 FT) in position below the applicable access panels.
(2) Remove the applicable access panels
(Ref. TASK 57-41-37-000-004-A)
:
B. Get Access
(1) Put the ACCESS PLATFORM 3M (10 FT) in position below the applicable access panels.
(2) Remove the applicable access panels
(Ref. TASK 57-41-37-000-004-A)
:
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 5 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
Remove 622XB.
** On A/C ALL
SUBTASK 28-24-00-860-060-A
4. Procedure
** On A/C 001-009 011-050 101-150 154-200 246-300 351-352 356-356 358-360 501-501
503-504 506-506 508-508 510-512 517-525 527-527 529-529 531-536 540-550 561-567
571-571 582-600 605-608 610-611 615-709 712-712 717-718 725-725 729-750
(Ref. Fig 28-24-00-991-00200-B - Component Location - Cockpit)
** On A/C 001-009 011-050 101-150 605-608 610-611 615-709 712-712 717-718 725-725
729-750 801-850
(Ref. Fig 28-24-00-991-00100-B - Component Location and Detail)
** On A/C 154-200 246-300 351-352 356-356 358-372 378-379 381-425 427-428 430-433
435-450 501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529 531-536
540-550 561-567 571-571 582-600 851-908 911-999
(Ref. Fig 28-24-00-991-00100-A - Component Location and Detail)
** On A/C 361-372 381-425 427-428 430-433 435-450 801-908 911-999
(Ref. Fig 28-24-00-991-00200-D - Component Location - Cockpit)
** On A/C 378-379
EMB SB 28-1206 FOR A/C 378-379
(Ref. Fig 28-24-00-991-00200-L - Component Location - Cockpit)
** On A/C ALL
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 6 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
SUBTASK 28-24-00-210-053-A
B. Removal of the Fuel Drain Plug from Engine 1 Fuel Filter (To Do a Test of Engine (ENG) 1 LP Fuel-Valve
(12QM))
(Ref. Fig 28-24-00-991-01300-D - Fuel Drain Plug - Location and Detail)
(1) Open the applicable fan cowl doors
(Ref. TASK 71-13-00-010-802-A)
.
(2) Open the applicable Thrust Reverser (T/R) cowl doors
(Ref. TASK 78-36-00-010-802-A)
.
(3) Remove the fuel drain plug (1) from engine 1 fuel filter as follows:
(a) Put the CONTAINER 200 L (53 USGAL) in position below engine 1 fuel filter.
(b) Loosen the drain plug bolt (3).
(c) Turn and remove the fuel drain plug (1) from engine 1 fuel filter.
(d) Remove and discard the packing (2) from the fuel drain plug (1).
(e) Drain the fuel into the CONTAINER 200 L (53 USGAL).
(f) Put the CONTAINER 200 L (53 USGAL) below the fuel drain plug (1) to do a check of the fuel flow
during the test:
1 Make sure that you do not put fuel that you drained from the engine back into the fuel
system.
** On A/C 001-009 011-050 101-150 605-608 610-611 615-709 712-712 717-718 725-725
729-750 801-850
SUBTASK 28-24-00-020-050-C
B. Removal of the Fuel Drain Plug from Engine 1 Fuel Filter (To Do a Test of Engine (ENG) 1 LP Fuel-Valve
(12QM))
(Ref. Fig 28-24-00-991-01300-B - Fuel Drain Plug - Location and Detail)
(1) Open the applicable fan cowl doors
(Ref. TASK 71-13-00-010-010-A)
.
(2) Open the applicable Thrust Reverser (T/R) halves
(Ref. TASK 78-32-00-010-010-A)
.
(3) Remove the fuel drain plug (2) from engine 1 fuel filter as follows:
(a) Put the CONTAINER 200 L (53 USGAL) below engine 1 fuel filter.
WARNING: USE PROTECTIVE GOGGLES AND GLOVES EACH TIME YOU CUT LOCKWIRE.
DISCARD LOOSE OR USED LOCKWIRE IMMEDIATELY. LOOSE OR USED
LOCKWIRE CAN CUT YOU OR MAKE YOU BLIND.
(b) Cut, remove and discard the lockwire from the fuel drain plug (2).
(c) Remove the fuel drain plug (2) from engine 1 fuel filter.
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 7 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
(d) Remove and discard the packing (1) from the fuel drain plug (2).
(e) Drain the fuel into the CONTAINER 200 L (53 USGAL).
(f) Put the CONTAINER 200 L (53 USGAL) below the fuel drain plug (2) to do a check of the fuel flow
during the test:
1 Make sure that you do not put the fuel that you drained from the engine back into the fuel
system.
** On A/C 154-200 246-300 351-352 356-356 358-372 378-379 381-425 427-428 430-433
435-450 501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529 531-536
540-550 561-567 571-571 582-600
SUBTASK 28-24-00-020-050-E
B. Removal of the Fuel Drain Plug from Engine 1 Fuel Filter (To Do a Test of Engine (ENG) 1 LP Fuel-Valve
(12QM))
(Ref. Fig 28-24-00-991-01300-C - Fuel Drain Plug - Location and Detail)
(1) Open the applicable fan cowl doors
(Ref. TASK 71-13-00-010-040-B)
.
(2) Open the applicable Thrust Reverser (T/R) cowl doors
(Ref. TASK 78-36-00-010-040-B)
.
(3) Remove the fuel drain plug (1) from engine 1 fuel filter as follows:
(a) Put the CONTAINER 200 L (53 USGAL) below engine 1 fuel filter.
WARNING: USE PROTECTIVE GOGGLES AND GLOVES EACH TIME YOU CUT LOCKWIRE.
DISCARD LOOSE OR USED LOCKWIRE IMMEDIATELY. LOOSE OR USED
LOCKWIRE CAN CUT YOU OR MAKE YOU BLIND.
(b) Cut, remove and discard the lockwire or safety cable from the fuel drain plug (1).
(c) Remove the fuel drain plug (1) from engine 1 fuel filter.
(d) Remove and discard the packing (2) from the fuel drain plug (1).
(e) Drain the fuel into the CONTAINER 200 L (53 USGAL).
(f) Put the CONTAINER 200 L (53 USGAL) below the fuel drain plug (1) to do a check of the fuel flow
during the test:
1 Make sure that you do not put the fuel that you drained from the engine back into the fuel
system.
** On A/C ALL
SUBTASK 28-24-00-720-050-A
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 8 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
WARNING: MAKE SURE THAT YOU HAVE THE CORRECT FIRE FIGHTING EQUIPMENT
AVAILABLE.
(2) For valve 12QM, do this test:
ACTION RESULT
• ENG 1 LP valve MOTOR 2 SUPPLY and
1.On panel 121VU:
CONTROL are isolated.
• Open, safety and tag the circuit breaker(s)
that follow(s). Use the SAFETY CLIP -
CIRCUIT BREAKER as necessary.
3QG (FUEL/LP VALVE/MOT2/ENG1).
2.On the ECAM control panel, push the FUEL On the ECAM lower DU:
pushbutton switch. • The FUEL system page comes into view.
• The LEFT LP valve indication shows that
the valve is closed (amber cross-line).
3.On LP valve actuator 9QG, feel the position of • The position of the indicator identifies that
the valve is closed.
the mechanical see/feel indicator with your hand.
• The OFF light goes off.
4.Push L TK PUMPS 1 or 2 pushbutton switch.
• The fuel feed line of the LP valve is
pressurized.
• On the ECAM lower DU, the LEFT LP valve
5.On panel 115VU, set ENG/MASTER 1 switch
indication shows that the valve is open
to the ON position.
(green in-line).
• The actuator motor must not operate for
6.On LP valve actuator 9QG, do the steps that
more than 5 seconds.
follow:
• The indicator position identify that the valve
• Listen to the actuator motor and record
is open.
the time of its operation until the LP valve
opens.
• When ENG/MASTER 1 switch is in the ON
position, make sure that the fuel flows into
the CONTAINER 200 L (53 USGAL).
• Feel the position of the see/feel indicator
with your hand.
• On the ECAM lower DU, the LEFT LP valve
7.On panel 115VU, set ENG/MASTER 1 switch
indication shows that the valve is closed
to the OFF position.
(amber cross-line).
• The actuator motor must not operate for
8.On LP valve actuator 9QG, do the steps that
more than 5 seconds.
follow:
• The position of the indicator identifies that
• Listen to the actuator motor and record
the valve is closed.
the time of its operation until the LP valve
closes.
• When ENG/MASTER 1 switch is in the
OFF position, make sure that the fuel flows
into the CONTAINER 200 L (53 USGAL).
• Feel the position of the see/feel indicator
with your hand.
• The OFF light comes on.
9.Release L TK PUMPS 1 or 2 pushbutton
switch.
• ENG 1 LP valve MOTOR 2 SUPPLY and
10.On panel 121VU:
CONTROL are energized.
• Remove the SAFETY CLIP - CIRCUIT
BREAKER and the tag(s) and close this
(these) circuit breaker(s):
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 9 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
(a) Apply lubricant, aircraft turbine engine (Material No: P03-001 ) to the new (IPC-CSN
73-11-02-01-280 ) PACKING (2).
(b) Install the packing (2) on the fuel drain plug (1).
(c) Install and turn the fuel drain plug (1) on the washer (4) and the drain plug bolt (3) of engine 1 fuel
filter.
(d) TORQUE the drain plug bolt (3)
to between 60 and 70 LBF.IN (0.68 and 0.79 M.DAN)
.
(2) Remove the CONTAINER 200 L (53 USGAL).
(3) Discard the drained fuel in the approved area.
(4) Close the applicable T/R cowl doors
(Ref. TASK 78-36-00-410-802-A)
.
(5) Close the applicable fan cowl doors
(Ref. TASK 71-13-00-410-802-A)
.
** On A/C 001-009 011-050 101-150 605-608 610-611 615-709 712-712 717-718 725-725
729-750 801-850
SUBTASK 28-24-00-420-052-D
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 11 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
E. Close Access
(1) Fully extend the slats
(Ref. TASK 27-80-00-866-004-A)
.
(2) FOR 12QM (VALVE-LP FUEL, ENG 1)
Install pressure relief panel 522AB
(Ref. TASK 57-41-37-400-002-A)
.
** On A/C 851-908 911-999
SUBTASK 28-24-00-410-066-B
E. Close Access
(1) Fully extend the slats
(Ref. TASK 27-80-00-866-004-A)
.
(2) FOR 12QM (VALVE-LP FUEL, ENG 1)
Install pressure relief panel 522XB
(Ref. TASK 57-41-37-400-002-A)
.
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 12 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
** On A/C ALL
SUBTASK 28-24-00-210-054-A
G. Removal of the Fuel Drain Plug from Engine 2 Fuel Filter (To Do a Test of Engine (ENG) 2 LP Fuel-Valve
(13QM))
(Ref. Fig 28-24-00-991-01300-D - Fuel Drain Plug - Location and Detail)
(1) Open the applicable fan cowl doors
(Ref. TASK 71-13-00-010-802-A)
.
(2) Open the applicable T/R cowl doors
(Ref. TASK 78-36-00-010-802-A)
.
(3) Remove the fuel drain plug (1) from engine 2 fuel filter as follows:
(a) Put the CONTAINER 200 L (53 USGAL) in position below engine 2 fuel filter.
(b) Loosen the drain plug bolt (3).
(c) Turn and remove the fuel drain plug (1) from engine 2 fuel filter.
(d) Remove and discard the packing (2) from the fuel drain plug (1).
(e) Drain the fuel into the CONTAINER 200 L (53 USGAL).
(f) Put the CONTAINER 200 L (53 USGAL) below the fuel drain plug (1) to do a check of the fuel flow
during the test:
1 Make sure that you do not put fuel that you drained from the engine back into the fuel
system.
** On A/C 001-009 011-050 101-150 605-608 610-611 615-709 712-712 717-718 725-725
729-750 801-850
SUBTASK 28-24-00-020-051-C
G. Removal of the Fuel Drain Plug from Engine 2 Fuel Filter (To Do a Test of Engine (ENG) 2 LP Fuel-Valve
(13QM))
(Ref. Fig 28-24-00-991-01300-B - Fuel Drain Plug - Location and Detail)
(1) Open the applicable fan cowl doors
(Ref. TASK 71-13-00-010-010-A)
.
(2) Open the applicable T/R halves
(Ref. TASK 78-32-00-010-010-A)
.
(3) Remove the fuel drain plug (2) from engine 2 fuel filter as follows:
(a) Put the CONTAINER 200 L (53 USGAL) below engine 2 fuel filter.
WARNING: USE PROTECTIVE GOGGLES AND GLOVES EACH TIME YOU CUT LOCKWIRE.
DISCARD LOOSE OR USED LOCKWIRE IMMEDIATELY. LOOSE OR USED
LOCKWIRE CAN CUT YOU OR MAKE YOU BLIND.
(b) Cut, remove and discard the lockwire from the fuel drain plug (2).
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 13 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
(c) Remove the fuel drain plug (2) from engine 2 fuel filter.
(d) Remove and discard the packing (1) from the fuel drain plug (2).
(e) Drain the fuel into the CONTAINER 200 L (53 USGAL).
(f) Put the CONTAINER 200 L (53 USGAL) below the fuel drain plug (2) to do a check of the fuel flow
during the test:
1 Make sure that you do not put the fuel that you drained from the engine back into the fuel
system.
** On A/C 154-200 246-300 351-352 356-356 358-372 378-379 381-425 427-428 430-433
435-450 501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529 531-536
540-550 561-567 571-571 582-600
SUBTASK 28-24-00-020-051-E
G. Removal of the Fuel Drain Plug from Engine 2 Fuel Filter (To Do a Test of Engine (ENG) 2 LP Fuel-Valve
(13QM))
(Ref. Fig 28-24-00-991-01300-C - Fuel Drain Plug - Location and Detail)
(1) Open the applicable fan cowl doors
(Ref. TASK 71-13-00-010-040-B)
.
(2) Open the applicable T/R cowl doors
(Ref. TASK 78-36-00-010-040-B)
.
(3) Remove the fuel drain plug (1) from engine 2 fuel filter as follows:
(a) Put the CONTAINER 200 L (53 USGAL) below engine 2 fuel filter.
WARNING: USE PROTECTIVE GOGGLES AND GLOVES EACH TIME YOU CUT LOCKWIRE.
DISCARD LOOSE OR USED LOCKWIRE IMMEDIATELY. LOOSE OR USED
LOCKWIRE CAN CUT YOU OR MAKE YOU BLIND.
(b) Cut, remove and discard the lockwire or safety cable from the fuel drain plug (1).
(c) Remove the fuel drain plug (1) from engine 2 fuel filter.
(d) Remove and discard the packing (2) from the fuel drain plug (1).
(e) Drain the fuel into the CONTAINER 200 L (53 USGAL).
(f) Put the CONTAINER 200 L (53 USGAL) below the fuel drain plug (1) to do a check of the fuel flow
during the test:
1 Make sure that you do not put the fuel that you drained from the engine back into the fuel
system.
** On A/C ALL
SUBTASK 28-24-00-720-051-A
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 14 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 15 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 16 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
16.On panel 115VU, set ENG/MASTER 2 switch On the ECAM lower DU, the RIGHT LP valve
to the OFF position. indication shows that the valve is closed (amber
cross-line).
17.On LP valve actuator 10QG, do the steps that • The actuator motor must not operate for
more than 5 seconds.
follow:
• The indicator position identify that the valve
• Listen to the actuator motor and measure
is closed.
the time that it operates for as the LP valve
closes.
• When ENG/MASTER 2 switch is in the
OFF position, make sure that the fuel flows
into the CONTAINER 200 L (53 USGAL).
• Feel the position of the mechanical see/feel
indicator with your hand.
• The OFF light comes on.
18.Release R TK PUMPS 1 or 2 pushbutton
switch.
• ENG 2 LP valve MOTOR 1 SUPPLY and
19.On panel 49VU:
CONTROL are energized.
• Remove the SAFETY CLIP - CIRCUIT
BREAKER and the tag(s) and close this
(these) circuit breaker(s):
2QG (FUEL/LP VALVE/MOT1/ENG2).
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 17 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
(c) Install the fuel drain plug (2) on engine 2 fuel filter.
(d) TORQUE the fuel drain plug (2)
to between 1.24 and 1.36 M.DAN (109.73 and 120.35 LBF.IN)
(Ref. TASK 70-23-11-911-013-A)
.
WARNING: USE PROTECTIVE GOGGLES AND GLOVES EACH TIME YOU CUT LOCKWIRE.
DISCARD LOOSE OR USED LOCKWIRE IMMEDIATELY. LOOSE OR USED
LOCKWIRE CAN CUT YOU OR MAKE YOU BLIND.
(e) Safety the fuel drain plug with lockwire (Material No: V02-147).
(2) Remove the CONTAINER 200 L (53 USGAL).
(3) Discard the drained fuel in the approved area.
** On A/C 154-200 246-300 351-352 356-356 358-372 378-379 381-425 427-428 430-433
435-450 501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529 531-536
540-550 561-567 571-571 582-600
SUBTASK 28-24-00-420-053-F
A. Close Access
(1) Make sure that the work area is clean and clear of tools and other items.
(2) Close the applicable thrust reverser halves
(Ref. TASK 78-32-00-410-010-A)
.
(3) Close the applicable fan cowl doors
(Ref. TASK 71-13-00-410-010-A)
.
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 18 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
A. Close Access
(1) Make sure that the work area is clean and clear of tools and other items.
(2) Close the applicable thrust reverser cowl doors
(Ref. TASK 78-36-00-410-802-A)
.
(3) Close the applicable fan cowl doors
(Ref. TASK 71-13-00-410-802-A)
.
(4) Fully extend the slats
(Ref. TASK 27-80-00-866-004-A)
.
(5) Install pressure relief panel 622XB
(Ref. TASK 57-41-37-400-002-A)
.
** On A/C 154-200 246-300 351-352 356-356 358-372 378-379 381-425 427-428 430-433
435-450 501-501 503-504 506-506 508-508 510-512 517-525 527-527 529-529 531-536
540-550 561-567 571-571 582-600
SUBTASK 28-24-00-410-050-E
A. Close Access
(1) Make sure that the work area is clean and clear of tools and other items.
(2) Close the applicable thrust reverser cowl doors
(Ref. TASK 78-36-00-410-040-B)
.
(3) Close the applicable fan cowl doors
(Ref. TASK 71-13-00-410-040-B)
.
(4) Fully extend the slats
(Ref. TASK 27-80-00-866-004-A)
.
(5) Install pressure relief panel 622AB
(Ref. TASK 57-41-37-400-002-A)
.
** On A/C ALL
SUBTASK 28-24-00-860-061-A
C. Removal of Equipment
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 19 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
(1) Remove the CONTAINER 200 L (53 USGAL) and discard the fuel.
(2) Remove the SAFETY BARRIER(S).
(3) Remove the access platform(s).
(4) Remove the WARNING NOTICE(S).
(5) Remove the ground support and maintenance equipment, the special and standard tools and all other
items.
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 20 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
FIG. EFFECTIVITY: On A/C 001-009 011-050 101-150 154-200 246-300 351-352 Fig Issue Date: 14 May 2024
356-356 358-360 501-501 503-504 506-506 508-508 510-512 517-525 527-527
529-529 531-536 540-550 561-567 571-571 582-600 605-608 610-611 615-709
712-712 717-718 725-725 729-750
B A
PANEL 115VU
OFF
ENG MODE ENG OFF
1 2
AUTO IGN
C FIRE CRANK IG N
FIRE
FAULT FAULT
A 1 2
B PANEL 40VU
XFEED
ENG1 APU ENG2
F OPEN F
U ON U
E L TK PUMPS CTRTK CTRTK R TK PUMPS E
1 2 PUMP1 MODESEL PUMP2 1 2
L FAULT A FAULT FAULT
L
FAULT FAULT FAULT U FAULT
T
OFF OFF OFF MAN O OFF OFF OFF
FUEL KG
F .U S E D 1 F .U S E D 2
3100 FOB 3100
LP VALVE 12860 LP VALVE
CLOSED APU OPEN
LE FT RIGHT
N_MM_282400_5_AEM0_01_00
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 21 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 22 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
FIG. EFFECTIVITY: On A/C 361-372 381-425 427-428 430-433 435-450 801-908 Fig Issue Date: 14 May 2024
911-999
B A
PANEL 115VU
OFF
ENG MODE ENG OFF
1 2
AUTO IGN
C FIRE CRANK IG N
FIRE
FAULT FAULT
A 1 2
B PANEL 40VU
XFEED
ENG1 APU ENG2
F OPEN F
U ON U
E L TK PUMPS CTRTK CTRTK R TK PUMPS E
1 2 LXFR MODESEL RXFR 1 2
L FAULT FAULT A FAULT FAULT
L
FAULT FAULT U FAULT
T
OFF OFF OFF MAN O OFF OFF OFF
FUEL KG
F .U S E D 1 F .U S E D 2
3100 FOB 3100
LP VALVE 12860 LP VALVE
CLOSED APU OPEN
LE FT CTR RIGHT
N_MM_282400_5_SAM0_01_00
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 23 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
FIG. EFFECTIVITY: On A/C 378-379 : EMB SB 28-1206 FOR A/C 378-379 Fig Issue Date: 14 May 2024
B ENGINE CONTROL
C PANEL
115VU
ON PUSH ON
ENG MODE
ENG
OFF 1 AUTO IGN 2 OFF
CRANK IGN
FIRE FIRE
FAULT FAULT
1 2
A A
PANEL
40VU
X FEED
F ENG 1 APU
OPEN
ENG2 F
U ACT ON U
E L TK PUMPS FAULT
A
U
CTRTK CTRTK
R TK PUMPS
E
L 1 2
FWD T
O
PUMP1 MODE SEL
A
PUMP2 1 2 L
FAULT FAULT FAULT FAULT U FAULT FAULT FAULT
T
OFF OFF OFF MAN OFF OFF OFF
O
FUEL KG
F.USED 1 F.USED 2
3100 FOB 3100
16860
APU
LP VALVE
LP VALVE OPEN
CLOSED LEFT CTR RIGHT
2000
ECAM
LOWER DU
C
N_MM_282400_5_GEM1_01_00
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 24 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
FIG. EFFECTIVITY: On A/C 154-200 246-300 351-352 356-356 358-372 378-379 Fig Issue Date: 14 May 2024
381-425 427-428 430-433 435-450 501-501 503-504 506-506 508-508 510-512
517-525 527-527 529-529 531-536 540-550 561-567 571-571 582-600 851-908
911-999
ACCESS PANEL
5 2 2 A T (6 2 2 A T )
FRONT
SPAR
LP FUEL
VALVE
12QM
13QM
ACTUATOR
9QG
10QG
VALVE
B VALVE
CLOSED OPEN
SEE / FEEL
INDICATO R
N_MM_282400_5_AAM0_01_00
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 25 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 26 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
FIG. EFFECTIVITY: On A/C 001-009 011-050 101-150 605-608 610-611 615-709 Fig Issue Date: 14 May 2024
712-712 717-718 725-725 729-750 801-850
ACCESS PANEL
5 2 2 A T (6 2 2 A T )
(UNDER SLAT)
FRONT
SPAR
LP FUEL
VALVE
12QM
13QM
ACTUATOR
9QG
10QG
VALVE
B VALVE
CLOSED OPEN
SEE / FEEL
INDICATO R
N_MM_282400_5_BAM0_01_00
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 27 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
FIG. EFFECTIVITY: On A/C 001-009 011-050 101-150 605-608 610-611 615-709 Fig Issue Date: 14 May 2024
712-712 717-718 725-725 729-750 801-850
B
FUEL COOLED
B
OIL COOLER
FUEL PLUG
N_MM_282400_5_AAA0_01_00
Fuel Drain Plug - Location and Detail : Fuel Drain Plug - Location and Detail - Sheet 1
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 28 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
FIG. EFFECTIVITY: On A/C 154-200 246-300 351-352 356-356 358-372 378-379 Fig Issue Date: 14 May 2024
381-425 427-428 430-433 435-450 501-501 503-504 506-506 508-508 510-512
517-525 527-527 529-529 531-536 540-550 561-567 571-571 582-600
A
FLANGE
STA199 (A2)
FLANGE
STA191 (B6)
FUEL
FILTER
FUEL PLUG
2
1
N_MM_282400_5_BAA0_01_01
Fuel Drain Plug - Location and Detail : Fuel Drain Plug - Location and Detail - Sheet 1
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 29 of 30
A318/A319/A320/A321 – AMM LTM D1-LTM-
A320
Airbus Printed by Toolbox: 24 Jun 2024 15:01:42 CLT
UNCONTROLLED COPY 24 Jun 2024
Rev 45 - 01 May 2024
TASK 28-24-00-720-001-A Functional Test of the LP Fuel Shut Off Valves Issue Date: 15 Mar 2024
EFFECTIVITY: On A/C ALL
FIG. EFFECTIVITY: On A/C 851-908 911-999 Fig Issue Date: 14 May 2024
A FUEL
MANIFOLD
1
2
A
N_MM_282400_5_DAA0_01_00
Fuel Drain Plug - Location and Detail : Fuel Drain Plug - Location and Detail - Sheet 1
Selected 170 Airbus PROPRIETARY - Copyright © - Unpublished Work - See title page for details Page 30 of 30