ARG Use BIA emo:
$ ‘er outay Gn: (1) 2685208
Ton SE a Geek 8 com NES Te ay ef 315 Se
7S Rel ~ 1100229). Spins nome eens
‘Se ano 1) 618 68
INDIAN ROADS CONGRESS
a at Mae, Soc K.P
‘New Deb 11083 nis).
NOTIFICATION NO. 71 dated the 28% June, 2011,
‘Subject: Amendments 0 IRC:6-2010 “Standard Specifeations and Code of Practice for Road
Bridges” Setion: It Loads and Stresses (Fifth Revision)
Filth Revision of IRC6-2010 “Standard Specifications and Code of Practice for Road Bridges” Section: 1
‘Loads and Stresses was published in November 2010 incorporating up-o-dte amendment il ht tine.
‘The Indian Roads Congress has decided 1 Furher amend the sbove document. Accordingly, the Amendment
No.2 is hereby atid,
These amendments sll be effective fom the 1*
2011
0
pte
‘GF nor)
Seretary Generel
AMENDMENTS TO IRC:6.2019
CaN] Ter Ta
“ale Title 1 be Ton Connan Vi, TE TT Cand Coma, Vie alas
tier ne: Cun 10 (eve od ekg Come 10 (Gace snd reign ep xe)
Set ei! rc) ae save 03a all be 02nd oF.
{Load Combinatorial of
Fue Tele othe end combination VI, ve
ewe der Caan 17 (reson ef). "|EF wm ue slum 1 eon ee) sate
Aisa, in Table 1, fr load Combination 1X, Sete.
andr alan 17 (een 00 ANE ie in Take for lad canbinton X dr clan 17
see erenion eee} naod tobe ced
The leven exact of Tal sepa
te herent ext of Tbe | sede below
“eerie te} Tanai a
Fre bate oni Sac | on Tae] Baas | bates | Cc | Besar
r Finca sir | ea | Tea | Bias | pote | ce
Oe Pe Pee | eo |" a
batt
7S [Use af atonal ine land 03 shown i
(Note) fiove Table is applicable only when the Allen the dexg ve lon given in Table? icone. Te
‘low ”Jésia le loa gent ble? is cansicered fratare mt nn be checked with 0 ive lan
‘Die [These mart lobe checked wth ao ve]
i"
Ey Nees [New noe Cy below TabieT
esate, (hase No 21932 maybe eter t,o eon of
elow Iesdin Load Combination Vi.
Tile
—4xxTRN_-’NV’N’N’V’rTro’'-'-—"_ ora
i‘AMENDMENTS TO 1RC:6-2010 “STANDARD SPECIFICATIONS AND CODE OF PRACTICE
FOR ROAD BRIDGES” SECTION : II LOADS AND STRESSES (FIFTH REVISION)
Casa] Fe
Taal
Ni Nevesising
‘New Chas afer Clause 2043
2044 Congestion Factor
For bros, Ryowelrade separ dose
pens, vy doses and es and sy oer
Frequent congestion of heny veces may cer,
check foe congestion ef vehicular live lsd 6a he earsagens|
‘hal be cansderee Bethe abence of any stgulied value,
‘Ye congestion fsa, se meniored ate Tale 2) sal be
ensieed Ts itor sal be wed = ming itr oo
‘Ho ploba enero veiclrlvelaedonty Undethiscondion,
orion fore due obrakingceleraon,cevfgal aco
td temperate grade effet aed ot be nla tthe
litt oflive load inact shal be nid.
‘tnte2(@)
Se ‘Span Range ‘Congestion
Per
1 [Abe tomanduprosom | us
2 300m wm Tis 130
3 Home 00m 130% 145
= Ome oom 1450 160
5 Bomw 0m Tove 170
® Beyond 700 70
Note: Fortes edge pans be value of culling
‘cor maybe inept
2132 [To alow fr fal taoyany, reduc |
ade in the goes weight of the member
sce, nk allowing mana:
5) wher he member nde consideration]
ispnes water ony, eg. 2 slow
pie or abut pier found ana
{be bed lee the rection in well
Salle eq to ht of te volume of
the diplend water
‘hea the member unde consideration
‘places water aod ao sl ost
egy = dec piet or abutment pit
‘ting tueagh sta of sa ad i
{nd founded on sir mae, te
b
Fo iow fee fal toojaney, «retacon sll be made fo te
srs weg ofthe menber feted by seeing cent 83
Be doit of te cplced water,
soe: The densty of water ay be kena 1.0?
pwede
INDIAN HIGHWAYS, OLY 2011
SAMENDMENTS TO IRC:62010 “STANDARD SPECIFICATIONS AND CODE OF PRAGTICR
‘FOR ROAD BRIDGES" SECTION : Il LOADS AND STRESSES (FIFTH REVISION) |
Chae Fer
Read
‘slg te econ weigh lle
Seasiered ss made of facts
(Pall bytes pes de
"oe dep of water emi ta the
‘ieee in levee Bewoan |
Tee surice of water aod th|
Toundatos ofthe eter ud
coxsideica, the oe suic|
beng tkea fre wont ont
a
(0) Upward presse due be
submerged weight ofthe it oF
Sand eeusted in acordce wi
Rakin thar fr spropi
(Pu) |stove ned pot be sooner on te
Jomponents, sch at wing walls on]
Je wal snce here lent ay
pubes ow co.
ge final cso,
Nae bio Nererning [New noe below Gane 2
232, For artesian cnn HFL.o acl witer bed, whichever
sigh, shal be consis fr calulting te uli
2I9SA | aol earth prose Feros desta] Themed earth pose forces deseribd dx =e
srgraph ee not be comidered onthe prion of ts sata
low sou level and on ther earponent sch a wing wal
ander wal
3189 [Where castomerie barge we wind, |
(ip uner | seprme system of erexer cone ie bi
Recomet- | dectons shall be inode to cst
ea | ses forces on ts besring
Provisions
Fee some beaiags are Wed, a mpuais asin a
sexe convo in both esto may be rrodoe oat
Semis Fores on he bei
wat [The sow load of 900 Kp? we]
srelicabie on be ide deck shall be ke
inte feowng, "ee condone be
checked independent:
0) Aseowsccunslaon 025s overt
(ick thal be taken into onder
While designing the ster
‘held veces.
1) Ascow accumulation f0 move
‘ck shal taken it eonsderton|
‘while desing be sevcure fr
‘hehe veils
Jo) Incateofsow sceunultonerestng
030 m maximum sow secumltn
tase onal ste observation sal
Fie sow ead of 500 ia wher pliable Sal be ad
joactonhe beige dec wil combining wit lveloodas ve
bsiow. Both ibe condons bal te chested independ
0) A sow acumuation upto 025 m over the deck sal
‘be taken into coniderton, while designing the suc]
‘be wheeled vile
>) A soow sccumulaon wp to 030 m over the deck sal
be ten ito coniéeatin, whe designing be smote
racked vices,
Jo) te case of snow scunulaion exceeding 050 m, Sie
shale based ate ima ecoreed no arcuate
(ase onthe actual ste obseration, inching te fet ol
‘ston ia sow dens) Nove ned shal be considered
{Wa along wih his now on
I consdered witht ive lon
—o»hl TTT Y—_-e-N-N—---— nr
s
se
Fe
1onda BAG wm
Ws "Tg (Sey Genel 411) 26185303
‘ern iA er Goee 8 EN TOL Say OSHA Se 1ST,
7 Rh ~ 110022 re) doin saan i
en ay 1 2163659
INDIAN ROADS CONGRESS
aa Kot Mag Sec 6 RK Pas,
| "New Dei 000 dai)
NOTIFICATION NO. 72 dated the 28 June, 2011
|) Sebjoct: Amendment to 1RC:78-2000 “Standard Specifications and Code of Practice for Road
| Bridges” Section :VII Foundations and Substructure (Second Revision)
| Second Revision of IRC-78-2000 “Standard Specifications and Code of Practice for Rosd Bridget” Setion °VIL
|| Foundations and Substncture was published in December 2000 and reprinted in August 2007 incorporating
up-to-date amendmen il hat time.
‘The Indian Roads Congress has decided to fuher amend the above document, Accordingly, the Amendment
[No.8 ishereby notified,
‘isdn sl beet fom ey 2 “
ee
‘2 itr)
sere Ge
AMENDMENT TO IRC: 78-2000
Cae For Read
Ne.
7631.2 | The allowable Waring rere on Fock my | For open foundations and wel oandatos rsing oo To |
be deeded upon aot oly an the seen ofthe allowable earng presse on rock may be deed
aret rock tu abo on oven charctraties | upon nt oaly on the steal of para ek but sso on
Parca deienies, ihe, join, being | overl characterise parila daieces, Ue, jit,
Planes, fault, weuered ones,” et. la bedding pans, faults, weathered zones, ela absense
abseace of such deals or anal of overall of such detail or anys of veal shat, he
states, tbe value of fate of safety vale of factor of sy sed on unconine compeessve
‘ese on uncoated compressive sueagth a srengh ofthe parent rock maybe ken a 6 to ules
he pent rock maybe kee a 6 6 8 ules oherwie indict onthe Sai of lea exerinte. The
ferwse indicated on the esis of cell slowable bearing preset, tind ie to be itr
experince. The allowable beating press, exticed tno over3 MPa for ad combi () ve ia
tus, ebaicd isto te fer ested to not | Cla 706.1,
exer 3 MPa fr oad combination () 808 ror oe of safety in cate of lle funda, late
ee eames
Fe einepeciet ory ated
al atroctany tetrad
S
INDIAN