Professional Documents
Culture Documents
Silde - Cswip - 3.1 079 156 18
Silde - Cswip - 3.1 079 156 18
Silde - Cswip - 3.1 079 156 18
Good cut - sharp top edge, fine and even drag lines, little oxide Good cut - sharp top edge, fine and even drag lines, little oxide
and a sharp bottom edge. and a sharp bottom edge.
Preheat flame too high - top edge Nozzle is too high above the works Irregular travel speed - uneven
Preheat flame too low -
is melted, irregular cut, excess of - excessive melting of the top space between drag lines, irregular
deep groves in the lower
adherent dross. edge, much oxide. bottom with adherent oxide.
part of the cut face.
OFW/C Advantages/Disadvantages
Advantages: Disadvantages:
No need for power High skill factor.
supply portable. Wide HAZ.
Versatile: preheat, Safety issues.
brazing, surfacing, Slow process.
repair, straightening
Limited range of
Low equipment cost. consumables.
Can cut carbon and Oxy Fuel Film
Not suitable for
low alloy steels. reactive and
Good on thin refractory metals.
materials.
15-2