Professional Documents
Culture Documents
Booster 38431300
Booster 38431300
Booster 38431300
S E RV I CE S P R OG RA M B OOK 1 2 .2 6
SYSTEM COMPONENTS
Additional Specifications
x 1.6 MPa max operating pressure
x 0.2-1.6 MPa set pressure range
x 0.1-1.0 supply pressure range
x 1600 cfm max flow rate
x 1/2” NPTF threaded IN, OUT & EXH ports
x 1/8” NPTF threaded gauge port
Note:
x Pressure Booster should be installed indoors with ambient conditions between 2o and
50oC with no possibility of freezing
x The In port of the booster regulator has metallic mesh to prevent dust from entering the
booster. However, it cannot remove dust continuously or separate drainage. Make sure
to install a mist separator on the inlet side of the booster regulator
x The booster regulator has a sliding part inside, and it generates dust. Also, install an in-
line air filter on the outlet side as necessary.
x If a lubricator is required for end use equipment, ensure it is installed on the outlet side
as accumulated oil in the booster regulator may result in a malfunction.
x Allow sufficient space for maintenance and inspection
x Provide a dedicated pipe to release the exhaust air from each booster regulator. If
exhaust air is converged into a pipe, the back pressure that is created could cause
improper operation.
S E RV I CE S P R OG RA M B OOK 1 2 .2 7