Download as pdf or txt
Download as pdf or txt
You are on page 1of 126

Spirit

series
ST 400-900S
Manufacturing No. 400-

Y
X Z

Instructions
902594-en
12.01.2011
ver. 1.0
Original instructions
2 12.01.2011
ver. 1.0
Gödning
Fertilizer
Dünger
Engrais

1,12 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 704 <   < 470 <   < 939 <   < 704 <   < 626 < 
9 km/h  < 463 <   < 309 <   < 618 <   < 463 <   < 412 < 
12 km/h  < 349 <   < 232 <   < 465 <   < 349 <   < 310 < 
15 km/h  < 279 <   < 186 <   < 372 <   < 279 <   < 248 < 
18 km/h  < 229 <   < 152 <   < 305 <   < 229 <   < 203 < 

Vete
Wheat
Weizen
Blé

0,79 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 510 <   < 340 <   < 679 <   < 510 <   < 453 < 
9 km/h  < 338 <   < 225 <   < 451 <   < 338 <   < 300 < 
12 km/h  < 254 <   < 169 <   < 339 <   < 254 <   < 226 < 
15 km/h  < 195 <   < 130 <   < 260 <   < 195 <   < 174 < 
18 km/h  < 166 <   < 111 <   < 221 <   < 166 <   < 147 < 

Korn
Barley
Gerste
Orge

0,74 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 400 <   < 266 <   < 533 <   < 400 <   < 355 < 
9 km/h  < 308 <   < 205 <   < 410 <   < 308 <   < 273 < 
12 km/h  < 208 <   < 138 <   < 277 <   < 208 <   < 185 < 
15 km/h  < 197 <   < 131 <   < 262 <   < 197 <   < 175 < 
18 km/h  < 162 <   < 108 <   < 216 <   < 162 <   < 144 < 

Havre
Oats
Hafer
Avoine

0,63 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 421 <   < 281 <   < 561 <   < 421 <   < 374 < 
9 km/h  < 257 <   < 172 <   < 343 <   < 257 <   < 229 < 
12 km/h  < 197 <   < 131 <   < 262 <   < 197 <   < 175 < 
15 km/h  < 147 <   < 98 <   < 196 <   < 147 <   < 131 < 
18 km/h  < 139 <   < 92 <   < 185 <   < 139 <   < 123 < 
Bönor
Beans
Bohnen
Féves

0,85 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 569 <   < 379 <   < 758 <   < 569 <   < 506 < 
9 km/h  < 377 <   < 251 <   < 503 <   < 377 <   < 335 < 
12 km/h  < 281 <   < 187 <   < 375 <   < 281 <   < 250 < 
15 km/h  < 223 <   < 149 <   < 298 <   < 223 <   < 198 < 
18 km/h  < 184 <   < 123 <   < 245 <   < 184 <   < 163 < 

Ärtor
Peas
Erbsen
Pois

0,84 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 536 <   < 357 <   < 714 <   < 536 <   < 476 < 
9 km/h  < 383 <   < 255 <   < 511 <   < 383 <   < 341 < 
12 km/h  < 282 <   < 188 <   < 376 <   < 282 <   < 251 < 
15 km/h  < 223 <   < 149 <   < 297 <   < 223 <   < 198 < 
18 km/h  < 191 <   < 127 <   < 255 <   < 191 <   < 170 < 

Raps
Rape
Raps
Colza

0,65 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 18 <   < 12 <   < 24 <   < 18 <   < 16 < 
9 km/h  < 11 <   < 7,3 <   < 15 <   < 11 <   < 9,8 < 
12 km/h  < 8,5 <   < 5,6 <   < 11 <   < 8,5 <   < 7,5 < 
15 km/h  < 6,9 <   < 4,6 <   < 9,2 <   < 6,9 <   < 6,2 < 
18 km/h  < 5,5 <   < 3,7 <   < 7,4 <   < 5,5 <   < 4,9 < 

Lin
Flax
Flachs
Lin

0,74 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 146 <   < 97 <   < 195 <   < 146 <   < 130 < 
9 km/h  < 98 <   < 65 <   < 131 <   < 98 <   < 87 < 
12 km/h  < 74 <   < 49 <   < 98 <   < 74 <   < 66 < 
15 km/h  < 59 <   < 39 <   < 79 <   < 59 <   < 52 < 
18 km/h  < 39 <   < 26 <   < 53 <   < 39 <   < 35 < 

Gräs
Grass
Gras
Ray-grass

0,31 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 46 <   < 31 <   < 61 <   < 46 <   < 41 < 
9 km/h  < 31 <   < 21 <   < 42 <   < 31 <   < 28 < 
12 km/h  < 24 <   < 16 <   < 31 <   < 24 <   < 21 < 
15 km/h  < 19 <   < 13 <   < 26 <   < 19 <   < 17 < 
18 km/h  < 16 <   < 11 <   < 22 <   < 16 <   < 14 < 
ST 400-900S

1 Safety rules
1.1 Before using the drill ............................................................................ 9
1.2 Warning decals ................................................................................. 10
1.3 Location of warning decals on the machine ........................................... 11
1.4 Machine plate ................................................................................... 12
1.5 Other safety regulations ..................................................................... 13
1.6 Moving the machine when not hitched to a tractor ................................. 14

2 Installation instructions
2.1 Tractor ............................................................................................. 15
2.2 Installation of the Control Station on the tractor .................................... 16
2.3 Installation of the feed's electrical system on the tractor ......................... 17

3 Instructions and settings


3.1 Hitching and unhitching the seed drill ................................................... 18
3.2 Hose length adjustment ..................................................................... 20
3.3 Hydraulic brakes (option) ................................................................... 21
3.4 Pneumatic brakes (option) .................................................................. 23
3.5 Control Station .................................................................................. 24
3.6 Extending and retracting the wing sections ........................................... 35
3.7 Horizontal alignment .......................................................................... 39
3.8 Setting the radar ............................................................................... 40
3.9 Setting tramline markers .................................................................... 41
3.10 Setting up the pre-implement ............................................................. 43
3.11 Scrapers, supporting wheels (accessory) .............................................. 45
3.12 Scrapers, seed coulter compaction (packer) wheels ................................ 46
3.13 Adjusting the bout markers, ST 400-800 .............................................. 47
3.14 Preparations before filling the seed hopper ............................................ 48
3.15 Filling the seed hopper ....................................................................... 49
3.16 Setting the amount of air ................................................................... 50
3.17 Opening the emptying hatch/Emptying the seed box .............................. 51
3.18 Rotor replacement ............................................................................. 52
3.19 Gearing up and down ......................................................................... 53
3.20 Seed guide ....................................................................................... 54
3.21 Calibration ........................................................................................ 55
3.22 Test drive ......................................................................................... 60
3.23 Emptying the seed hopper .................................................................. 61
3.24 Setting the sowing depth .................................................................... 62
3.25 Setting the weight transfer ................................................................. 68
3.26 Setting the seed coulter pressure ........................................................ 69
3.27 Adjusting the following harrow ............................................................ 71
3.28 Levelling units ................................................................................... 72
3.29 Setting the pre-emergence bout markers .............................................. 73
3.30 Tramlining ........................................................................................ 74

4 Driving
4.1 Setting and raising the drill in furrows .................................................. 76
4.2 Half machine shut off ......................................................................... 76
4.3 Drilling depth and seed coulter pressure ............................................... 77
4.4 Checking the seed feed rate ................................................................ 78

5 Maintenance and service


5.1 Securing the seed drill machine for service ........................................... 79
5.2 General ............................................................................................ 80
5.3 Lubrication points .............................................................................. 81

12.01.2011
ver.1.0 5
5.4 Cleaning .......................................................................................... 83
5.5 Storage of the machine ...................................................................... 85
5.6 Replacing the disc hub, System Disc .................................................... 86
5.7 Changing discs, System Disc ............................................................... 86
5.8 Changing the hydraulic cylinder seals ................................................... 87
5.9 Bleeding the hydraulic system ............................................................. 87
5.10 Changing the fan speed sensor ............................................................ 88
5.11 Replacement of the feed output system rotation guard ........................... 89
5.12 Repair and exchange of the seed hoses ................................................ 90
5.13 Inspecting the seed drill's towing hitch ................................................. 91
5.14 Wing section locking devices ............................................................... 92
5.15 Inspect the wheel bearing play ............................................................ 92
5.16 Changing wheels ............................................................................... 93
5.17 Hydraulic brakes (option) ................................................................... 95
5.18 Pneumatic brakes (option) .................................................................. 96

6 Troubleshooting
6.1 General information on troubleshooting ................................................ 98
6.2 Troubleshooting list ......................................................................... 100
6.3 Alarm list ....................................................................................... 104

7 Appendices
7.1 Seeding table .................................................................................. 107
7.2 Hydraulic system schematic diagram .................................................. 109
7.3 Electrical system ............................................................................. 115
7.4 Technical data ................................................................................. 123

6 12.01.2011
ver. 1.0
ST 400-900S

INTRODUCTION

The Väderstad Spirit 400-900S is a high capacity pneumatic cultivator drill. The machine
is intended for drilling in light to medium soils.
The machine can be used in all cultivation systems, from following ploughs to direct drill-
ing when conditions are right.
The seed placement ability of the machine is excellent, even at high speeds.

IMPORTANT!

This instruction manual is based on experience and results obtained during development of
the Spirit project. The hints and advice it contains are to be regarded as guidance only and
entail no responsibility whatsoever on the part of Väderstad-Verken AB and/or its repre-
sentatives. All responsibility for usage, road transport, maintenance and repair, etc. of the
seed drill rests with the owner/driver.
Local conditions affecting crop rotation, soil type, climate, etc. may require procedures
different to those mentioned in this manual.

The owner/operator shall bear full responsibility for correct use of the seed drill in every
respect.
Väderstad seed drills have passed quality assurance inspection and operational tests prior
to delivery. The user/purchaser shall retain sole liability for ensuring that the equipment
functions correctly when in use. In case of complaints, please refer to the “General deliv-
ery conditions of the Väderstad group”.

12.01.2011
ver.1.0 7
EC DECLARATION OF CONFORMITY FOR THE MACHINE
according to EU Machine Directive 2006/42/EC

Väderstad-Verken AB, P. O. Box 85, SE-590 21 Väderstad, SWEDEN


hereby confirms that the drilling machines hereunder have been manufactured in
accordance
with the Council Directives 2006/42/EC and 2004/108/EC.

The above declaration covers the following machines:


ST 400S, ST 600S, ST 800S and ST 900S with manufacturing no. 400-1000.

Väderstad 2010-06-18

Lars-Erik Axelsson
Legal requirements coordinator
Väderstad-Verken AB
Box 85, SE-590 21 Väderstad

The undersigned is also authorised to compile technical documentation for the above
machines.

8 12.01.2011
ver. 1.0
ST 400-900S

1 Safety rules

1.1 Before using the drill

Figure 1.1

! Carefully read the instructions and make sure you understand their meaning.
! Always pay special attention to the text or illustration indicated by this symbol!
! Learn how to operate the seed drill correctly and carefully! In the wrong hands or during care-
less operation, the drill can become a dangerous implement.

12.01.2011
ver.1.0 9
Safety rules

1.2 Warning decals

D E F G H
B

I J K L

Figure 1.2

A Carefully read the instructions and make sure you understand their meaning.
B Make sure the whole of the working area and area for folding out the sections are clear! Never
walk under a suspended wing section. Always check that the automatic stoppers have been
locked during transport and parking.
C Do not stand between the tractor and the machine when the tractor is reversed to hitch the seed
drill.
D Make sure nobody is on the seed drill when it is moving.
E Make sure nobody is on the seed drill when loading seed.
F The ladder and platform on the machine are not intended to be used for manual loading from
small sacks.
G Watch your feet. Risk of pinching.
H Always make sure that the working area of the bout markers is free from obstructions! Keep
in mind that there is a risk of injury when the bout markers are extended and there is a risk of
crushing between the seed drill and the bout markers when they are retracted. NOTE!The bout
markers are always retracted when the machine is lifted, regardless of the indications on the
Control Station. Switch off the Control Station when the machine is not operating in the field.
The Control Station stores all settings and values in memory when it is switched off.
I Warning tape, watch out for the risk of crushing or impact. Also used on safety-related parts.
J Do not climb onto the packer wheels of the drill when the units have been raised.
Do not stand on the supporting wheels when the machine has been lowered to the work posi-
tion.
K Re-tighten the nuts on the two outer wheels on each side of the centre section after 10 - 15 km
of road transport. Re-tighten the nuts similarly after changing wheels. Wheel nuts must be
tightened and checked for tightness using a torque wrench. See ”5 Maintenance and service”
on page 79.
L Use ear defenders when adjacent to the running fan.

10 12.01.2011
ver. 1.0
ST 400-900S

1.3 Location of warning decals on the machine

H, I
K, J
D, E

A, B, C, F, G, L

Figure 1.3

12.01.2011
ver.1.0 11
Safety rules

1.4 Machine plate

A C

D F

E
I
G

Figure 1.4

A Machine type
B Manufacturing number
(Always state the serial number of your machine when ordering spare parts and in case of serv-
icing or warranty claims.)
C Year of manufacture
D Working width
E Transport width
F Tare weight of the basic machine*
G Maximum total weight
H Maximum permitted payload
I Maximum permitted axle loading
J Maximum coupling load (at the tractor hitch)

* including System Disc, following harrow and bout marker


! See also ”7.4 Technical data” on page 123.

12 12.01.2011
ver. 1.0
ST 400-900S

1.5 Other safety regulations


! When transporting the seed drill on public roads, show good judgement and drive carefully.
We recommend the use of a tractor with a gross weight that is at least equal to the gross weight
of the seed drill, if the seed drill is not equipped with brakes. Please note that in most cases road
transport of a drill not equipped with brakes and with its seed hopper filled is inappropriate.
National legislation concerning brake equipment must always be complied with!
! This machine and its tyres are designed for a maximum speed of 50 km/h for transportation on
the public highway. National legislation concerning speed limits must always be complied
with!
! The view to the rear is very limited. Check the positioning of the rear view mirrors on the trac-
tor.
! Use the lights on the machine in accordance with local traffic regulations.
! In order to avoid any risk arising by accidental operation of the tractor's hydraulic controls dur-
ing road transport, the hydraulic hoses to the raising/lowering of pre-implements and seed drill
unit (yellow marking) must be disconnected from the tractor before transport driving begins.
! The platform and ladder on the machine must be kept clean so that there is no risk of slipping.
! For all servicing and repair work on the hydraulic system, the side sections of the drill must
always be in the lowered position and should rest on level and stable ground.
! Always park the seed drill on a level and solid surface.
! Prior to connecting the hydraulic hoses, make sure the seed drill male couplings and the female
connectors on the tractor are clean and free from dirt.
! To maintain the high level of quality and operational safety, use only Väderstad genuine spare
parts. The warranty and any claim commitments will become void if other than genuine parts
are used.
! Any welding work on the machine must be carried out to a professional standard.
Note that incorrect welding could result in serious or even fatal injuries.
If in doubt, please consult a certified welder for correct welding instructions.
! The installation of electrical systems or brakes must be carried out to a professional standard.
Incorrectly completed installations could result in major risks. If in doubt, contact a
professional service engineer.

12.01.2011
ver.1.0 13
Safety rules

1.6 Moving the machine when not hitched to a tractor


NOTE!If the machine must be moved in any way other than hitched to a tractor, it must be
transported on a low loader trailer or flatbed lorry. The machine must be rolled onto and off the
transport vehicle with the aid of a tractor.
1 Fold up the machine into its transport position, see ”3.6 Extending and retracting the wing
sections” on page 35.
2 Reverse the machine lengthwise onto the low loader trailer or flatbed lorry. A ramp, loading
pier or similar is required when using a flatbed lorry. Take great care. Check that no machine
components are damaged during loading.
3 Adjust the parking support so that the machine rests on its wheels and the parking support.
Lower the front tools and seed drill unit so that they rest on the ground.
4 Secure the wheels of the machine to prevent rolling using chocks or similar.
5 Secure the tarpaulin ready for transport using ratchet straps or similar.
6 Unhitch the tractor from the machine.
7 Secure the machine using suitable lashing equipment in accordance with applicable rules.
Attach the lashing equipment to the machine at the specified points indicated by labels, see
“Figure 1.5”.
! For information on the machine's dimensions and weight, see ”7.4 Technical data” on page
123.
! Always follow national regulations concerning transport dimensions, requirements for escort
vehicles, etc.!

Figure 1.5

14 12.01.2011
ver. 1.0
ST 400-900S

2 Installation instructions

2.1 Tractor

Figure 2.1 Figure 2.2

To minimise damaging soil compaction, the tractor used to tow the seed drill should be equipped
with extra wide tyres, e.g. double installation of Twin wheels or similar. Try to have as low tyre
pressure as possible. Any front weights on the tractor should be removed.

2.1.1 Tractor hydraulic system requirements


4 double-acting hydraulic couplings and 1 non-pressurised return input, 3/4" required.
A For fan operation and feed 1 x double-acting hydraulic coupling is required, with a capacity of
40 l/min. at 200 bar. This coupling requires an individually adjustable flow.
B For the raising/lowering of pre-implements and seed drill units, one double-acting hydraulic
coupling is required, with a capacity of 40 l/min. at 200 bar.
NOTE!It must be possible to use the hydraulic couplings mentioned in A and B above simultane-
ously.
C For the fine adjustment of working depth for pre-implements, one double-acting hydraulic cou-
pling is required, with a capacity of 20 l/min. at 200 bar.
D For the wing lowering function and adjustment of working angle on Crossboard, one double-
acting hydraulic coupling is required, with a capacity of 20 l/min. at 200 bar.
E For return oil from the fan operating system, 1 x pressureless return entry. Contact your tractor
distributor for instructions on how this is to be installed.

2.1.2 Tractor electrical system requirements


2 x electrical sockets with the following requirements:
For operation of the Control Station, refer to ”2.2 Installation of the Control Station on the
tractor” on page 16. The Control Station must be connected to an electrical socket that is fused
for a power output of 20A, which prevents the use of a cigarette lighter socket..
For operation of the feed, refer to ”2.3 Installation of the feed's electrical system on the tractor”
on page 17. During normal operation, the power consumption of the feed system is between 10-
20A. For short periods of time, the system's power consumption can be higher and the system must
therefore be fused up to 60A.

12.01.2011
ver.1.0 15
Installation instructions

2.2 Installation of the Control Station on the tractor

Figure 2.3 Figure 2.4

Attach the control box securely in the tractor cab. The control box should be installed within the
field of vision when driving forwards. Install the bracket as shown in the illustration.
NOTE!Prior to any drilling in the tractor cabin, be sure to check for any concealed wiring that may
be present.
Connect the cables: brown to plus (+) and blue to ground (-).
NOTE!Do not reverse the polarity! If the tractor is fitted with a power outlet in the cabin, use this
outlet. If a power outlet is not available, an extra cable must be prepared. Preferably use 6 mm²
cable. Do not use a cigarette lighter outlet, as the current consumption is up to 20 A. It is impor-
tant that this connection is made correctly, since any looseness could cause a malfunction.
Make sure the connection cable to the seed drill is not pinched under the rear window of the trac-
tor, since this cable can be easily damaged. Use the designated connector port or cable lead-
through. Securely clamp the cable in the tractor cab. This protects the Control Station from dam-
age in case the connection cable has inadvertently not been disconnected prior to unhitching the
drill.

16 12.01.2011
ver. 1.0
ST 400-900S

2.3 Installation of the feed's electrical system on the


tractor
1 Make sure that the main switch on the tractor is switched off.
2 Fit the electrical socket in a suitable place with the cable pointing downwards in order to
prevent water from getting into the connector. We recommend that the socket be located close
to the hydraulic connector at the rear of the tractor.
3 Route the cable in a suitable way through to the main switch/main relay switch. The cable must
be fitted so that it cannot become trapped or rest against hot components on the tractor or work
loose.
NOTE!The cables in the kit must not be cut off, as the connectors and fuses were pre-installed and
tested in the factory.
4 Connect the red cable to the 12V AFTER the main switch/main relay.
5 Connect the black cable to the negative.
NOTE!The installation must be capable of a current output of 60A
NOTE!Incorrectly completed installations could result in major risks. If in doubt, contact a
professional service engineer.
The person who carries out the installation is responsible for the effect that the installation may
have on the tractor and its guarantee.

12.01.2011
ver.1.0 17
Instructions and settings

3 Instructions and settings

3.1 Hitching and unhitching the seed drill


3.1.1 Hitching

Figure 3.1

1 Connect the drill to the tractor's hitch.


2 Raise and secure the parking stay.
Regularly inspect the tractor hitch device for any looseness and wear. Considerable looseness or
wear will cause the working depth of the seed drill to become uneven. Excessive wear on the trac-
tor hitch point also poses a risk that the seed drill hitch will detach from the tractor hitch!

3.1.2 Connecting cables to the Control Station, feed and lighting

Figure 3.2

1 Remove the protective cover (A) from the intermediate cable on the seed drill and connect the
cable to the Control Station. Be very careful when making this connection. Make sure that the
pins of both connectors are aligned. Then lightly press the connectors together while screwing
the nut to secure the connectors. Screw on the protective cover for the intermediate cable when
the machine is unhitched.
2 The male connector for seed drill lighting is connected to the standard external lighting
connector on the tractor.
3 Undo the protective cover on the seed drill's power cable to the feed and connect the electrical
socket fitted on the tractor

18 12.01.2011
ver. 1.0
ST 400-900S

3.1.3 Connecting the hydraulic hoses


2

Figure 3.3 Figure 3.4

Also see ”2.1.1 Tractor hydraulic system requirements” on page 15. Carefully check that all hoses
are connected in pairs to the correct hydraulic couplings on the tractor.
1 1 x 1/2" hose + 1 x 3/8" hose (marked with red plastic rings) for driving the fan, seed rate con-
nect to double-acting hydraulic couplings.
2 1 x 3/4" hose connects to a pressure-free return entry. Lock the return input coupling female
connection. See “Figure 3.4”.
3 2 x 1/4” hoses (marked with blue plastic rings) for folding wing sections and adjusting working
angle on Crossboard are connected to a double-acting hydraulic coupling.
4 2 x 3/8" hoses (marked with yellow plastic rings) for raising/lowering the seed drill unit and
the Disc pre-implement as well as operating the bout markers are connected to a double-acting
hydraulic coupling.
5 2 x 1/4" hoses (marked with white plastic rings) for setting the working depth for the pre-im-
plement are connected to a double-acting hydraulic coupling.
NOTE!Carefully wipe the couplings and outlets dry! This is a good way to avoid unnecessary
problems and wear in the hydraulic system.
NOTE!Read section ”3.16 Setting the amount of air” on page 50 before starting the fan.

3.1.4 Unhitching
! Unhitching and parking must always take place on a level and solid surface.
1 Make sure that the hydraulic system is depressurised. Disconnect the hydraulic hoses and elec-
trical cables.
2 Lower the drawbar and secure the parking stay.
3 Disconnect from the tractor hitch device.

12.01.2011
ver.1.0 19
Instructions and settings

3.2 Hose length adjustment

Figure 3.5

Connect the hydraulic hoses carefully and adjust their lengths, see “Figure 3.5”. This will ensure
that the hoses are always connected correctly and that the seed drill is operated using practised
lever manipulations. Once work is completed, hook the quick-release couplings securely onto the
hose holder.
NOTE!The hoses must not hang down towards the drawbar because of the risk of them becoming
crushed or worn

20 12.01.2011
ver. 1.0
ST 400-900S

3.3 Hydraulic brakes (option)


3.3.1 General
The ST 400-900 S can be fitted with hydraulic brakes. The machine is braked with the aid of four
brake cylinders located on the outer wheels in the middle section. The system also has an emer-
gency brake that is applied if the machine becomes unhitched from the tractor. The emergency
system consists of an accumulator, a valve and a wire that is connected to the tractor.

3.3.2 Connection and driving

1 2
A

Figure 3.6

1 Connect the hydraulic hose of the brake system to the brake coupling on the tractor. Please note
that the hose must only be connected to a brake coupling that is controlled by the tractor’s brake
pedal and provides a maximum pressure of 150 bar. Attach the wire to a convenient point on
the tractor. Make sure the wire cannot get entangled.
2 Ensure that the emergency brake valve is set to position A.
3 Press down the brake pedal and keep it in this position until the pressure gauge on the ma-
chine’s draw-bar shows 120 - 140 bar.
4 The machine is now ready to drive.

12.01.2011
ver.1.0 21
Instructions and settings

3.3.3 Parking

Figure 3.7

Always park the implement on a stable and level surface. In order to activate the parking brake,
proceed as follows:
1 Connect the brake couplings to the tractor.
2 Activate the tractor’s parking brake.
3 Close the needle valve (A) on the valve. This closes the hydraulic circuit between the valve and
the brake cylinders.
! Open the needle valve (A) when you want to disengage the parking brake.

22 12.01.2011
ver. 1.0
ST 400-900S

3.4 Pneumatic brakes (option)


3.4.1 General
ST 400-900 can be supplied with pneumatic brakes. The pneumatic brake system comprises pres-
sure lines up to an oil cylinder, where the pressure is transferred via the brake fluid to the brake
drum. The oil type in the hydraulic section should be a mineral oil for type GL-4 hydraulic sys-
tems. When supplied from the factory, the system is filled with Ate oil, LHM PLUS.

3.4.2 Connecting the brake system’s hoses


! The compressed air line has a red mounting and must be connected to the tractor’s red cou-
pling.
! The control line has a yellow mounting and must be connected to the tractor’s yellow coupling.

3.4.3 Activation of parking brake

Figure 3.8

In order to activate the parking brake, proceed as follows:


1 Connect the compressed air lines to the tractor’s couplings as described above.
2 Activate the tractor’s parking brake.
3 Close the needle valve (A) on the main ram. This closes the hydraulic circuit between the main
ram and the wheel cylinders.
! Open the needle valve (A) when you want to disengage the parking brake.

12.01.2011
ver.1.0 23
Instructions and settings

3.5 Control Station


3 4

2 21

22

5
23

30 24

6 9
25

10
7
26

11
8
27
12
15
13
16

28
1

29
14

18 20 19 17

32

31

Figure 3.9

24 12.01.2011
ver. 1.0
ST 400-900S

3.5.1 Functional description


1 Main switch

2 - Activation of the Control Station when starting.


- Wing sections lowering, see ”3.5.2 Functions” on page 27.

3 Calibration, refer to ” The pre-emergence bout marker should be adjusted to the tramlin-
ing width. Move the tines (A) laterally on the frame. The angle of the bout marker discs can be
adjusted by turning the shafts (B) in their holders.” on page 73.

4 Manual starting. When the button is held pressed in, feed will take place without the ma-
chine moving forward. Used when starting at a corner, for example, or during feed checks. Pre-
selection of which driving speed the feed is set for takes place in the programming menu.
5 LCD display.
6 Lamps to indicate tramline marking.
Not lit = no tramlining.
Green light = Tramlining in operation.
7 - Auto advance block. The indicator lamp next to the button lights when the block is engaged.
- Selection of tramlining programme (Keep the push-button pressed for 5 seconds).
8 Manual advance of tramlining.
9 Indicator lamps for active bout markers.
10 Manual selection of bout markers. Both in/left out/right out/both out.
11 - Automatic bout marker change left/right. The indicator lamp next to the button lights when
automatic operation is engaged.
- Manual change of bout marker.
12 Information. Used to explain alarm conditions, check the trip meter, average speed, etc.
13 Enter.
14 Escape.
15 Selection of low-lift or full lift. The indicator lamps next to the button show which function has
been engaged. The left indicator lamp blinks when the low-lift switch has been engaged.
16 Lift stop. Used to operate bout markers without raising the machine from the furrow.
17 Selection dial. Use the dial to scroll through the menus. Selections are shown against a dark

background, and when a selection has been confirmed with it is framed and the alterna-
tive can be selected or a value can be changed by turning the selector dial. Confirm the selec-

tion or value with .


When entering digits, the speed of change upwards/downwards can be increased by keeping

pressed in while the selector dial is turned.


18 Limited operation left side, (ST 600S XL, ST 800S, ST 900S.
19 Limited operation right side, (ST 600S XL, ST 800S, ST 900S.
20 Not used.

12.01.2011
ver.1.0 25
Instructions and settings

3 4

2 21

22

5
23

30 24

6 9
25

10
7
26

11
8
27
12
15
13
16

28
1

29
14

18 20 19 17

32

31

Figure 3.10

26 12.01.2011
ver. 1.0
ST 400-900S

21 Manual starting. When the button is held pressed in, feed will take place without the machine
moving forward. Used when starting at a corner, for example, or during feed checks. Pre-se-
lection of which driving speed the feed is set for takes place in the programming menu.
22 - Adjustment of sown seed amount, increase (in max. 5 steps and to max. increase of 99 %).
- Filling the output system prior to calibrating.
23 - Adjustment of sown seed amount, default value.
- Seed rate when calibrating.
24 Adjustment of sown seed amount, decrease (in max. 5 steps and to max. decrease of 99%).
25 Not used.
26 Not used.
27 Not used.
28 Not used.
29 Not used.
30 Alarm indicator.
31 Circuit breaker. Reset the circuit breaker by depressing it with a thin object, e.g., a pen.
32 Control Station part number.
Display
The first line in the display shows the seed rate in kg/hectare, the second one shows the fan rotation

speed , the third row shows the area meter or speedometer .


The fourth row shows the selected tramlining programme and the current position in the sequence.
Alarms are also indicated by the symbol (!). The number of (!) symbols indicates the number of

alarms. Alarm explanations are obtained by pressing . Alarms are acknowledged by press-

ing

3.5.2 Functions

Lowering the wing sections


Also see ”3.6 Extending and retracting the wing sections” on page 35.
When the seed drilling unit wing sections are to be extended or retracted, both the System Disc

and the drilling units must be at the correct height. Press button (the symbol is
shown on the display below the button).
Lower the seed drill and the System Disc to the ground. Raise them until they automatically stop

in the correct position. will now be shown beneath the symbols for the System Disc

and the seed drill .

! If the symbol is not shown, the System Disc or the drilling units must be adjusted up or

down in accordance with the arrow that is displayed, or . Adjust until is shown.
The wing sections can now be extended or retracted. When the movement is completed, press but-

ton or button to return to the main menu.

12.01.2011
ver.1.0 27
Instructions and settings

Auto advance
The Control Station usually operates with so-called auto advance. This means that the bouts in the
tramlining cycle are advanced and the bout makers are switched at the completion of each bout.

The auto advance feature can be blocked by depressing push-button . When auto advance
is blocked, the indicator lamp in the push-button lights.
Bout markers

During normal driving, automatic bout marker switching is used. Press until the green in-
dicator lamp lights. To advance a bout marker, depress the button once again.

Use for manual selection of bout markers. Selection is possible between both bout markers
folded in, left marker out, right marker out and both markers folded out.
Low-lift/Full lift
To set the low-lift height, refer to ”3.5.3 Programming” on page 31.

Use push-button to switch between low-lift and full lift. The indicator lamps next to the
button show which function has been engaged. Use low-lift when drilling. This prevents the ma-
chine from being raised too much, while allowing proper operation of the following harrow in the
headland.
NOTE!The machine must not be reversed in the low-lift position.
If it becomes necessary to raise the machine, e.g., when encountering an obstruction in the furrow

or to turn back and fill the seed hopper, be sure to first press to disengage the auto advance

feature. Then press to switch to full lift. The machine can now be raised to its maximum
height.

When the drill later is returned to the same position as before the interruption, press to re-

engage auto advance of tramlining and bout marker switching, and press to return to low-
lift operation.
The indicator lamp on the left of the button blinks when the low-lift switch has been engaged.
Lift stop
Use the lift stop when the bout markers should be retracted without lifting the machine from the

furrow, e.g., to pass a post or well. Press the button and lift the bout marker using the hy-

draulic lever. One press of button or switches between low-lift and full lift. The
Control Station remembers the function that was engaged prior to activating the lift stop.

28 12.01.2011
ver. 1.0
ST 400-900S

Tramlining
The selected tramlining programme is shown at the lower left of the display, while the current bout
in the sequence is shown at the lower right.

Keep the button depressed until the tramlining programme digit is selected. Select the de-

sired tramlining interval with the selection dial and confirm with . Advance to the desired

start value using .


Tramlining programme 31 permits a user-defined tramlining programme to be created.

Keep the button depressed until the tramlining programme digit is selected. Select pro-

gramme 31 using the dial and confirm with . In the left part of the menu, first select the de-
sired number of sequences in the tramlining cycle. Then use the right part of the menu to select in
which sequences tracks should be made, and whether they should be on the left and/or right. Ad-

vance to the desired start value using .


Adjustment of the sown amount (option)
The nominal value and the percentage change are recorded in the calibration menu.

Adjustment of the sown amount is done using the buttons - - .

results in an increase in the sown amount according to the calibration selection, while

reduces the sown amount according to the calibration selection, and results in the default
value. (Max. 5 steps and max. up/down 99%.)
Half machine shut off (ST 600S XL, ST 800S, ST 900S)
Shut off the supply of cereals to half the machine left or right hand side by pressing the button

left or right. Indicator lamps will show that half machine shut off is activated.

12.01.2011
ver.1.0 29
Instructions and settings

Calibration

Press to enter the calibration menu. See “Figure 3.11”. Proceed in accordance with ” The
pre-emergence bout marker should be adjusted to the tramlining width. Move the tines (A) later-
ally on the frame. The angle of the bout marker discs can be adjusted by turning the shafts (B) in
their holders.” on page 73.

Figure 3.11

Alarms
In the case of an alarm the red indicator lamp in the alarm symbol (30) lights and a buzzer sounds.
(The buzzer signal can be deselected in the programming menu. See ”3.5.3 Programming” on
page 31.)
(!) is displayed. Several (!) symbols indicate that there is more than one alarm condition. Press

for an explanation of the alarm in the display. Alarms are acknowledged by pressing
When the main switch is switched on, a number of alarm indications appear in the display and the

buzzer sounds. Press to acknowledge the alarms. The alarms disappear when drilling starts
providing that all functions are OK.

It is possible to acknowledge several alarm conditions at the same time. Press and then

press .
Information

Press to enter the information menu. Advance through the pages by turning the selection
dial. If an alarm simultaneously appears on the Control Station, the alarm texts are shown first.

The information menu shows: seed drilling trip meter (kg), , area trip meter (ha), , sea-

sonal area trip meter (ha), , total area trip meter (ha), , speedometer (average speed in

km/h), , and the total timer (h), .


It is not possible to reset the trip total area meter, speedometer and the total timer to zero.

The other meters can be reset to zero by first selecting the row where is displayed, and then

pressing .
The information texts are shown as the last items in the menu. The following texts may be valid
for this machine:
- Low-lift switch engaged.

30 12.01.2011
ver. 1.0
ST 400-900S

3.5.3 Programming
The Control Station is always preset at the Väderstad factory depending on the type and size of
the machine it accompanies. If the Control Station is changed or reset, the settings need to be re-
entered.
It is also possible to adjust certain settings in this case, e.g., alarm delays, area metering, etc.

To enter the programming menu, keep pressed while simultaneously switching on the pow-
er switch (1).
If the Control Station already has been switched on, switch to the programming menu by keeping

the button depressed for 5 seconds. To complete programming and return to the drive

mode, select the last menu in the scroll list: . Confirm with .
Use the selection dial to select the desired menu. Selections are shown against a dark background.

Use to confirm a selection and then select or change the value of the selected item. Confirm

the value/selection with .


Menus:

1 Language. Select the desired language for the alarm texts, etc.

2 Type of machine. Select “ST 4-600”, “ST 600XL”, “ST 8-900”.

3 Front tools. Select SystemDisc, SD+CB or Crossboard. To change the front tool, press
button A whilst rotating the selection dial.

4 GPS, Yes/No. See ”3.5.5 GPS (Global Positioning System)” on page 34.

5 Serial number. Record the serial number of the machine here. Select digits with the se-

lection dial and advance using .

6 Machine width. Select 4.0m, 6.0m, 8.0m or 9.0m

7 Manual starting. Select here the driving speed that is intended while the button
is held pressed in (Starting feed when drilling begins at a corner of the field, etc., only with
hydraulic feeding.)

8 Setting the lift delay time. Default setting 0.0 seconds.

9 Number of radar pulses per metre driven. Default setting 99 per metre.

12.01.2011
ver.1.0 31
Instructions and settings

10 AUTO. Automatic calibration. Measure a specific distance (at least 100 m). Press

at the starting point to reset the pulse counter. Drive the selected distance with the ma-
chine lowered to the drilling position. The pulses are counted in the display. Enter the driven
distance in metres. The Control station now calculates the number of pulses per metre of driven
distance, and automatically adjusts this value for the wheel circumference in menu 8. Select

OK by pressing .

11 LOW-LIFT. Setting the low-lift levels.

A Use the selector dial to select the value you want to change. Seed drilling units, or

System Disc, .

B Press .
C Use the hydraulics to drive the seed drilling units or the System Disc to the desired low-
lift level.

D Press to save the setting.


E Repeat from step A to set up units or System Disc that have not previously been set up.
F If a setting value that lies outside the factory preset limit values is chosen, the Control Sta-
tion generates an alarm and the setting will not be saved. Repeat the setting procedure
from step A.

G Scroll down to the OK/ESC menu row. Press to confirm the settings. Press
to reject the settings.

12 Alarm delay. Select the delay in seconds between receipt of the alarm signal from the
drilling system's rotation guard and the visual/audible alarm of the Control Station. The alarm
should be slightly delayed to avoid alarms at low speeds. Nevertheless, the delay should be as
short as possible to allow even sudden, brief interruptions to be detected. Default setting: 2.0
seconds.

13 Fan rotation speed, seed fan, upper alarm level. Default setting: 4500 rpm.

14 Fan rotation speed, seed fan, lower alarm level. Default setting: 2900 rpm.

15 Buzzer, Off/On

32 12.01.2011
ver. 1.0
ST 400-900S

16 Pre-emergence bout marker, Yes/No

17 Side bout marker as pre-emergence bout marker, Yes/No. When "Yes" is selected, the
side bout marker will make a track in the centre of the previous bout if this bout was tramlined.

18 Tramlining system on the distributor head for seed, Accord/Linak. Only “Accord” ap-
plies to the ST 400-900S.

19 BioDrill seed hopper, Yes/No

20 Reducing the amount sown during tramlining. Default setting dependent on machine
type and machine width calculated on 2+2 closed seed coulters and 125mm separation.
125mm 167mm
ST 400 12.5% 16.7%
ST 600 8% 11.2%
ST 800 6.2% 8.4%
ST 900 5.5% 7.4%

21 It is possible to enter user-specific information, e.g., a name. Use the selection dial to en-

ter characters and digits, and advance using .

22 Setting the display contrast. Use the selection dial to set the contrast between 0% (light-
er) and 100% (darker). (This adjustment is only available on Control Stations with order no.
428030 and program version 1.01 or later.)

23 OK. Press to complete programming and return to the drive mode.

12.01.2011
ver.1.0 33
Instructions and settings

3.5.4 Mini Remote


1 2

Figure 3.12

A remote control unit is mounted on the left side of the seed hopper. This is an aid during calibra-
tion, see ” The pre-emergence bout marker should be adjusted to the tramlining width. Move the
tines (A) laterally on the frame. The angle of the bout marker discs can be adjusted by turning the
shafts (B) in their holders.” on page 73. Note that the remote control unit can only be used when
the Control Station is in calibration mode.
Functional description

1 Filling the metering system before calibration.

2 Seed feed during calibration.

3.5.5 GPS (Global Positioning System)


Väderstad's Control Stations can be connected to the “Fieldstar” and “Agrocom” GPS systems.
For more information about this, contact Väderstad-Verken AB.

3.5.6 Loading new software


New software can be downloaded to the Control Station via a computer with an Internet
connection. For this purpose, a special connection cable (order no. 428017) is required. This can
be ordered from Väderstad-Verken AB.
Proceed as follows:
1 Log on to the Väderstad home page at http://www.vaderstad.com.
2 Click on “Aftermarket” and “Downloads” to download the installation programme for a VCS
update on your computer.
3 Make sure that the computer is connected to the internet. Run the new program and follow the
on-screen instructions. New files are created and/or updated. A short-cut to the program "VCS
update" will also be created on the PC desktop.
4 Double-click on the "VCS update" icon and follow the instructions.

34 12.01.2011
ver. 1.0
ST 400-900S

3.6 Extending and retracting the wing sections


3.6.1 Extending
A Ensure that the Control Station is connected and switched on!

B Before the machine is unfolded for the first time, make sure that the correct front tool is
set. See ” Menus:” on page 31.

C Press button on the Control Station (the symbol is shown on the display below
the button). Now a menu is shown, as in the illustration below.

Figure 3.13

D In order for the wing sections to be able to extend, the System Disc, symbolised by and

the drilling units, symbolised by must be in the correct height position. At the correct

height position, is shown beneath the respective symbols.


! To easily get them into the correct position, first lower the System Disc and the drilling units
to the ground. Then raise them until they automatically stop at the correct height for extension.

The symbol will now be shown for both the System Disc and the drilling units.

If symbol is not shown, the System Disc or the drilling units must be adjusted up or down

in accordance with the arrow that is displayed, or . Adjust until is shown.

12.01.2011
ver.1.0 35
Instructions and settings

E Use the fold-down cylinder to retract the wing sections. Unlock the wing sections using the
operating line from the tractor cab. Fold down the seed drill wing sections. Keep the line taut
until both wing sections start to fold down.
F Start driving forwards at a slow speed once the wing sections touch down on the ground. Keep
applying pressure on the folding hydraulic system until the folding ram has been completely
extended and until the piston rod of the weight transfer ram has retracted to about half its
length.

Figure 3.14

G Press button or button on the Control Station to return to the main menu.
H Turn the tap on the double-acting hydraulic coupling from the wing folding position to the
working depth for the front tool. This applies to machines equipped with System Disc Cross-
board (SD+CB).

36 12.01.2011
ver. 1.0
ST 400-900S

3.6.2 Retracting
A Ensure that the Control Station is connected and switched on!
B Check that the front tool (Crossboard) has an operating position of approx. 2.5 on the working
depth indicator. Turn the tap on the double-acting hydraulic coupling from the working depth
for the front tool to the wing folding position. This applies to machines equipped with System
Disc Crossboard (SD+CB).

C Press button on the Control Station (the symbol is shown on the display below
the button). Now a menu is shown, as in the illustration below.

Figure 3.15

D In order for the wing sections to be able to retract, the System Disc, symbolised by and

the drilling units, symbolised by must be in the correct height position. At the correct

height position, is shown beneath the respective symbols.


! To easily get them into the correct position, first lower the System Disc and the drilling units
to the ground. Then raise them until they automatically stop at the correct height for retraction.

The symbol will now be shown for both the System Disc and the drilling units.

If symbol is not shown, the System Disc or the drilling units must be adjusted up or down

in accordance with the arrow that is displayed, or .

12.01.2011
ver.1.0 37
Instructions and settings

E Fold up the seed drill wing sections.

Figure 3.16

F Check that the automatic locking devices have engaged.

G Press button or button on the Control Station to return to the main menu.

38 12.01.2011
ver. 1.0
ST 400-900S

3.7 Horizontal alignment

Figure 3.17

Match the drawbar on the drill to the hitch height of the tractor.
Use the push rod (A) for this adjustment. When making this adjustment, the machine must remain
hitched to the tractor and the entire machine must remain parked on level, solid ground. When cor-
rectly adjusted, the machine frame should be perfectly parallel with the ground.
Raise the locking tab (B), adjust to the required level, and then lower the locking tab.
! Adjustment is made easier if the draw-bar is lifted from the tractor's hitch by carefully pressing
down the System Disc pre-implement against the ground.

12.01.2011
ver.1.0 39
Instructions and settings

3.8 Setting the radar


A

35°

Figure 3.18

The angle of the radar unit must be adjusted. The angle must be 35° +/- 1° in relation to the soil
surface. The angle of the radar is optimal when the surface (A) is parallel with the soil surface.
Loosen the screws and adjust the bracket along the oblong hole.
! Before operation the radar must be calibrated, refer to the menu item “10” "Automatic calibra-
tion" in section ”3.5.3 Programming” on page 31.
! Clean the optics of the radar at regular intervals!
! Ensure that the working area of the radar is free from intruding objects such as hoses or cables!
NOTE!Never look into the radar optics while it is operating! Risk of eye injury!

40 12.01.2011
ver. 1.0
ST 400-900S

3.9 Setting tramline markers


3.9.1 Adjusting track width, machines with 125 mm seed coulter separation

43 21 1 234

150 cm

175 cm

200 cm
Figure 3.19

The drill is normally supplied with two row shut-off, track width 200 cm.
However, the track width can be changed as necessary. Switch the hoses on the drilling units as
follows:
! Shutting drilling units 1 and 2 results in two-furrow shut-off with a track width of 150 cm.
! Shutting drilling units 2 and 3 results in two-furrow shut-off with a track width of 175 cm.
! Shutting drilling units 3 and 4 results in two-furrow shut-off with a track width of 200 cm.

12.01.2011
ver.1.0 41
Instructions and settings

3.9.2 Adjusting track width, machines with 167 mm seed coulter separation

3 2 1 1 2 3

167 cm
184 cm
200 cm

Figure 3.20

The drill is normally supplied with two row shut-off, track width 200 cm.
However, it is possible to change the track width if necessary: Shift the feed hoses on the seed drill
unit as follows:
! Shutting off seed drill units 1 and 2 produces two row shut-off with a track width of 167 cm.
! Shutting off seed drill units 2 and 3 produces two row shut-off with a track width of 200 cm.
! Shutting off seed drill unit 2 produces one row shut-off with a track width of 184 cm.

42 12.01.2011
ver. 1.0
ST 400-900S

3.10 Setting up the pre-implement


3.10.1 Bleeding and zero setting
The hydraulic system that regulates the pre-implement and seed drill unit must be bled and reset
at least once a day.

1 Set the Control Station for maximum lifting, .


2 Raise the pre-implement and seed drill unit fully. Hold the hydraulic lever in the raising posi-
tion for approximately 30 seconds in order to evacuate any air

3.10.2 Adjusting the working depth of the front tool


The working depth of the System Disc and Single Crossboard front tools is adjusted using three
hydraulic rams connected in series (C). See ”3.10.3 Parallel alignment” on page 44.
Prior to use of the machine, bleed the hydraulic rams and adjust them in relation to each other in
order to achieve uniform work depths along the entire work width of the machine.
! Bleed the hydraulic system as explained in ”3.10.1 Bleeding and zero setting” on page 43.
! Check the height of the front tool sections in relation to each other. If adjustment becomes nec-
essary, lower the front tool to the ground and adjust the hydraulic ram stroke lengths by loos-
ening the counter nuts and screwing the piston rods in or out

Max 20 mm

Figure 3.21

! Do not unscrew the piston rod end more than 20 mm.

12.01.2011
ver.1.0 43
Instructions and settings

3.10.3 Parallel alignment

C
A

Figure 3.22
B

C
A

Figure 3.23

Perform this adjustment when the implement has been folded out onto level and firm ground.
1 Lower the pre-implement so that it is approx. 1 cm above the ground.
2 Adjust cylinder C so that the wing sections are at the same height as the centre section. See
adjustment of the pre-implement sections height in relation to each other in ”3.10.2 Adjusting
the working depth of the front tool” on page 43
3 SystemDisc: Adjust the stretching screws (A) so that the front disc row is parallel with the rear
disk row in the pre-implement.
Singel crossboard: Adjust the stretching screws (A) so that all crossboard pins have the same
working angle as required.
4 After the adjustment, lock the stretching screws using the lock nuts (B).
5 Crossboard + System Disc: Then check that the crossboard tines are aligned in relation to each
other. If adjustment is necessary, adjust the lengths of the hydraulic rams by loosening the
counter nuts and screwing the piston rod ends in or out.

Max 20 mm
Figure 3.24

! Do not unscrew the piston rod end more than 20 mm.


! Never work underneath the pre-implement unless it has been secured with trestles or similar
supports.

44 12.01.2011
ver. 1.0
ST 400-900S

3.11 Scrapers, supporting wheels (accessory)

Min 10 mm

Figure 3.25

The scrapers on the supporting wheels should be adjusted until the distance to the tyres is at least
10 mm. They can be moved as desired along the oblong holes.
Also make sure the brackets are correctly adjusted to be straight so the scrapers are parallel with
the tyre surface.
When the scrapers wear down, they can be fitted with new wear plates. Please refer to the spare
parts manual.

12.01.2011
ver.1.0 45
Instructions and settings

3.12 Scrapers, seed coulter compaction (packer) wheels

Figure 3.26

When necessary the seed coulter packer wheels can be adjusted. The scraper edges (A) can be
moved along the oblong holes.
The distance between the scraper edge and the packer wheel should be approx. 5 mm.

46 12.01.2011
ver. 1.0
ST 400-900S

3.13 Adjusting the bout markers, ST 400-800

Figure 3.27

Adjust the bout markers as shown in “Figure 3.27”. The measurement (A) from the outer edge of
the frame to the marking scraper must be as shown in the table below..

Table 3.1
A
ST 400 195 cm
ST 600 295 cm
ST 800 395 cm

NOTE!This adjustment is approximate. To avoid double-seeding or non-seeding, which may oc-


cur for example if the driver sits at an angle in certain tractors, a follow-up check should be done
in the field. Depending on the type of tractor and the driver position, the mark may be observed
differently.
The marker disc should be adjusted after about an hour’s time of operation.

12.01.2011
ver.1.0 47
Instructions and settings

3.14 Preparations before filling the seed hopper


Check before filling:
! that the machine is empty, clean and dry.
! that the level guards are adjusted correctly; refer to ”3.14.1 Setting the level guards” on page
48.
! which rotor and gear are best suited, see ”7.1 Seeding table” on page 107 and then make the
settings in accordance with ”3.18 Rotor replacement” on page 52 and ”3.19 Gearing up and
down” on page 53.
! that the emptying hatches are closed, see ”3.17 Opening the emptying hatch/Emptying the seed
box” on page 51.

3.14.1 Setting the level guards

Figure 3.28

The heights of the level guards can be adjusted. The sensors (A) can be moved to different cutouts
in their brackets.
! The 6 upper positions are used for cereal seed.
! The lower position is used for oilseed and other small size seeds.

48 12.01.2011
ver. 1.0
ST 400-900S

3.15 Filling the seed hopper


3.15.1 Filling from a bulk bag

Figure 3.29

NOTE!Think safety, never stand under a suspended load! Make sure nobody is present on the drill
when the seed is brought up to it. It is best to use an extension handle on the knife. Do not go up
to the seed hopper unless absolutely necessary. Avoid contact with and inhalation of seed dress-
ing.
Start by filling the rear of the seed hopper, and preferably empty the last seed bag in the front part
of the seed hopper.

3.15.2 Filling from small bags


NOTE!Pay attention to safety. Never walk under a suspended load! Make sure nobody is present
on the drill when the seed is brought up to it. Do not go up to the seed hopper unless absolutely
necessary. Avoid contact with and inhalation of seed dressing.
The ladder on the drill is not designed for manual filling of the hopper when using small sacks.
Filling should preferably be done using a loader and the bags placed on a pallet.

12.01.2011
ver.1.0 49
Instructions and settings

3.16 Setting the amount of air


The seed drill fan is located on the front wall of the seed hopper and is driven by the tractor hy-
draulic system.
The amount of air can be adjusted by altering the fan rotation speed, controlled from the Control
Station.
The fan rotation speed is regulated by the tractor's flow valve. If the tractor has a priority hydraulic
coupling, use that one.
Set the fan rotation speed in accordance with the following table. Check the fan rpm in the Control
Station display.
The alarm in the Control Station warning of too low a rotation speed is best set for 300 rpm below
the preset rotation speed, and the alarm warning of too high a rotation speed to 300 rpm above the
preset rotation speed, see ”3.5.3 Programming” on page 31.
To prevent the fan rotation speed from decreasing when raising or lowering the machine, the
hydraulic flow can be adjusted on most tractors. Rev up the tractor and check the rotation speed
of the fan on the Control Station display when the machine is raised and lowered. Set an
appropriate hydraulic distribution.
.

Table 3.2 Recommended fan rotation speed


ST 400S ST 600S/S XL ST 800S ST 900S
Small size seeds 3000 rpm 3400 rpm 3500 rpm 3600 rpm
Cereals 3600 rpm 4000 rpm 4200 rpm 4300 rpm

50 12.01.2011
ver. 1.0
ST 400-900S

3.17 Opening the emptying hatch/Emptying the seed box


1 Shut off the supply of seed from the seed hopper to the seed box by undoing latch clamp (B)
and pulling out the shut-off hatch (A) as far as it will go.
2 Open the latch clamp (C).

B C

A
Figure 3.30 Figure 3.31
3 Press together the spring-loaded lock on the emptying hatch (D) and open the hatch. If
necessary (e.g. rotor replacement), the hatch can be locked in the open position, see “Figure
3.33”.

Figure 3.32 Figure 3.33

12.01.2011
ver.1.0 51
Instructions and settings

3.18 Rotor replacement


The Seed Hawk comes equipped with an electric feed where the feed quantity is influenced by a
rotor and the gear setting; see also ”7.1 Seeding table” on page 107.
The rotor for the required seed output attachment must be fitted prior to drilling. There are three
different rotors to choose from: a rapeseed rotor, a grass rotor and a grain rotor.
1 Switch off the supply of seed to the seed box with the shut-off hatch and open the emptying
hatch, see ”3.17 Opening the emptying hatch/Emptying the seed box” on page 51.
2 Pull out the gearbox locking pin (A).
3 Remove the bearing (B) by twisting it out of its snap mountings.
A

Figure 3.34 Figure 3.35


4 Switch to the required rotor. Make sure that the rotor engages correctly in the driveshaft, see
“Figure 3.37”.

Figure 3.36 Figure 3.37


5 Reinstall the bearing and locking pin and select a suitable gear setting.
! Close the emptying hatch. If the latch clamp cannot be closed, open and clean so that the
emptying hatch lock can catch correctly.
6 Push in the shut-off hatch and fold down the latch clamp.
NOTE!The grooves on the rapeseed rotor have to be guided into the grooves on the seed box.

Figure 3.38

52 12.01.2011
ver. 1.0
ST 400-900S

3.19 Gearing up and down


The Seed Hawk comes equipped with an electric feed where the feed quantity is influenced by a
rotor and the gear setting; see also ”7.1 Seeding table” on page 107.
NOTE!An appropriate gear must be selected prior to drilling.
If the gear is changed with seed in the seed hopper, it is easiest to first close the shut-off hatch and
empty out the seed that is in the seed box, see ”3.17 Opening the emptying hatch/Emptying the
seed box” on page 51.
1 Pull out the locking pin (A).
2 Fit the locking pin in the inner shaft's hole (B), near the end.
! To switch from high to low gear, rotate and press the shaft using the locking pin.
! To switch from low to high gear, rotate and pull the shaft using the locking pin.

Figure 3.39 Figure 3.40

3 Fit the locking pin in position A for low gear and position B for high gear.

A B

Figure 3.41

12.01.2011
ver.1.0 53
Instructions and settings

3.20 Seed guide


Seed guide can be used in extreme conditions if certain seed types are pressing too hard against
the rotor, causing uneven operation.
NOTE!When sowing slow-moving seeds such as grass seed or clover and grass mixes, seed guide
must never be installed, as the seed can otherwise become compacted against the seed guide plate
and, in the worst case scenario, stop the flow.

3.20.1 Installation/removal of the seed guide plate


1 Remove the rotor, see ”3.18 Rotor replacement” on page 52.
2 Remove the cover (A) by first undoing the knob (B).

B
A
Figure 3.42

3 Remove the spring (E) from the latch clamp (D)


4 Grip the seed guide plate (C).
5 Pull out the latch clamp (D) and install or remove the seed guide plate (C).
! When installing, the seed guide plate (C) is inserted with the straight, thin side at the top and
the locking hooks towards the bottom/rear as shown in “Figure 3.43”. Insert the plate upwards
and towards the rear until it comes into contact with the edge and the mounting holes are in the
correct position for installing the latch clamp (D).
6 Fit the latch clamp (D) and spring (E).
NOTE!The latch clamp must be fitted on the correct side so that the seed box (A) can be fitted.
D

Figure 3.43

7 Install the cover (A).


8 Remove the desired rotor, see ”3.18 Rotor replacement” on page 52.

54 12.01.2011
ver. 1.0
ST 400-900S

3.21 Calibration
NOTE!The Spirit 400S and Spirit 600S have one metering unit. The Spirit 600S XL, Spirit 800S
and Spirit 900S have two metering units. In the case of double metering units, calibration of the
amount of seed delivered is carried out using two calibration bags.
NOTE!Lower the seed drill to the ground before starting calibration. The seed drill unit must not
be pushed down!

OBS! Make sure that the Control Station is programmed correctly, menu 2 and menu 6

must be set to the correct machine width, see ”3.5.3 Programming” on page 31.

Figure 3.44

1 Prior to sampling, reset the scale with the empty calibration bag supplied. Then fit the bag to
the seed box.
NOTE!The fan must be switched off.
2 Start the Control Station. See ”3.5 Control Station” on page 24

12.01.2011
ver.1.0 55
Instructions and settings

3 Press button on the Control Station to enter the calibration menu.

(Alternatively, the calibration menu can be activated by pressing the buttons and
on the Control Station simultaneously.))

Figure 3.45

! Select the row on the menus with the selection dial and confirm with .

4 Mark the menu row with . Enter the desired seed rate in kg/ha. Confirm with .
Note that the value shows the total feed from the machine, from both the front and rear meter-
ing units.

5 Mark the menu row with . Enter the desired increase/decrease of the output volume

as a percentage for the electrically adjustable sown amount. Confirm with .

6 Scroll down to the “Calibrate” menu row and press ...

Figure 3.46

7 Fill the feed system by pressing the button on the remote control. Undo the calibration
bag(s) by pulling out the locking spring. Empty the calibration bag(s).

56 12.01.2011
ver. 1.0
ST 400-900S

8 Fit the calibration bag(s) under the seed box(es) again..

Figure 3.47

9 Press on the remote control and keep the button pressed in until a reasonable amount of
seed has been fed out into the bag(s). The number of pulses from the seed boxes are counted
up in menu row 3.
ST 400S, ST 600S ST 600S XL, ST 800S, ST 900S

4,98 4,98 4,98

Figure 3.48

10 Weigh the contents of the bag(s).

12.01.2011
ver.1.0 57
Instructions and settings

11 Scroll down to menu row 4, mark it with and enter the weight in kg. Confirm with .

The number of pulses per kg will be calculated automatically in menu row 5, and menu row 6
will be marked.

To enter the number of pulses per kg manually, scroll back to row 5 and use to mark it.

Then enter the value manually and confirm with .


NOTE!If the weights of the content of both bags differ from each other (applies to ST 600S XL,
ST 800 and ST 900S), the seed boxes and drill rollers should be checked that the rotor and gear
are the same in both metering units.

12 Confirm the calibration at menu row 6 “Accept” by pressing .


To cancel the calibration and make a fresh calibration, scroll down to menu row 7 “Reject” and

press .

13 Select EXIT and press .

58 12.01.2011
ver. 1.0
ST 400-900S

3.21.1 Scale

Hold

2.24 KG

Figure 3.49 Figure 3.50

Weigh the calibration amounts as follows:


1 Press Start/Reset.
2 Hang the empty calibration bag on the scale hook.
3 The tare weight of the bag is shown. Wait until Hold is displayed.
4 Press Start/Reset.
5 Remove the bag and fill it with the calibrated amount.
6 Weigh the filled bag. The scale now shows the net weight of the calibrated amount.
! The scale is switched off automatically after approximately 5 minutes. (1 min. for certain
scales)
! Keep the scale in the calibration box while driving.
! Regularly check the scale with a known weight, and always do this before the beginning of the
season.

12.01.2011
ver.1.0 59
Instructions and settings

3.22 Test drive


To check the actual feed volume, a ‘test drive’ can be performed.
NOTE!Calibrate the radar to make sure the area meter show correct result, see drill instruction “
Programming”.
Test drive

1 Reset the area trip meter. Go into the information menu by pressing . Select the row

(trip meter area) by pressing the button. The row now flashes. Reset the trip meter

by pressing .
2 Ensure that the fan is switched off.
3 Install the calibration bag.

Figure 3.51

NOTE!It is vital for the operating test to be carried out with the machine in the work position, the
same as when work is imminent. The results will otherwise be misleading.
4 Drive a short distance, ideally around 100 m, with the calibration bag fitted, the feed enabled
and the fan switched off.
5 Weigh the contents of the bag.
6 Divide the weight by the area read on the Control Station.
Example: The contents of the calibration bag weigh 0.95kg. The area meter shows 0.12 ha.
0.95/0.12=7.91 kg/ha
! Due to variations in driving conditions small differences are possible compared to calibrated
seed output.
7 Reset the machine.
Should there be significant difference between test drive result and calibrated seed output make a
new calibration, see ”3.21 Calibration” on page 55.
! Make sure the feed system is filled prior to seed delivery calibration.
! Make sure the calibration bag is empty before weighing.
! Calibrate scale with empty calibration bag before weighing, see ”3.21.1 Scale” on page 59.
Repeat test drive procedure.
NOTE!Overlapping can cause the actual driven area to differ from the measured field area.
NOTE!Incorrect radar adjustment can cause false area meter indication.

60 12.01.2011
ver. 1.0
ST 400-900S

3.23 Emptying the seed hopper


The seed drill unit must be in its lowered position on the chassis before the seed hoppers are
emptied. .

A
C
Figure 3.52 Figure 3.53

When the seed hopper is to be emptied, open the latch clamp (A), allow the emptying hatch (B) to
hang down and push in the shut-off hatch (C).
If the seed is running slowly from the seed hopper, start the rotor manually by pressing the button

on Control Station, see also ”3.5.1 Functional description” on page 25.


! Do not forget to close the emptying hatch (B) after emptying. The latch clamp can be closed if
the hatch is closed correctly. If the latch clamp cannot be closed, open and clean so that the
emptying hatch lock can catch correctly.
! Check and clean the rotors after emptying of the seed hoppers. This is particularly important
when the seed box is used for fertiliser feed.

12.01.2011
ver.1.0 61
Instructions and settings

3.24 Setting the sowing depth


3.24.1 Bleeding and zero setting the hydraulic system
It is necessary to bleed and reset the hydraulic system used to adjust the System Disc and drilling
units at least once a day.

1 Set the Control Station for maximum lifting, .


2 Raise the System Disc and seed drilling units as far as they will go. Hold the hydraulic lever in
the lift position for approx. 30 seconds to bleed any remaining air in the system.

3.24.2 Sowing depth setting


C

60 mm
A

Figure 3.54

The drilling depth of the machine can be adjusted by placing clips (A) on the four limiter struts
(B). The more clips installed on the struts, the more shallow the drilling depth. Be sure to place
the same number of clips and same combination of clip widths on all 4 limiter struts.
There are four 20 mm clips, one 30 mm clip and one 5 mm clip available for each limiter strut.
NOTE!Be careful to avoid pinching your fingers when handling the clips for setting the drilling
depth. Do not under any circumstances operate the hydraulic circuit for raising/lowering the drill
while clips are being inserted or removed.
NOTE!The actual drilling depth should always be set and verified while driving in the field. The
following example serves as an aid to set the drilling depth:
For a machine with new drill discs and packer wheels, 60mm clips are mounted on each
limiter strut, which gives a theoretical drilling depth of approximately 30mm.
Theoretically, the drilling depth can vary from 0-9cm.
Check the drilling depth regularly, preferably once every hour. Check the drilling depth midway
between the tractor tracks, in the actual tractor track, and behind the left and the right wing sec-
tions. If the drilling depths under the side sections deviate from that of the centre section, then
check the hydraulic system function and setting, see ”3.26 Setting the seed coulter pressure” on
page 69 and ”3.25 Setting the weight transfer” on page 68.
If the drilling depths under the side sections deviate from that of the centre section despite the hy-
draulics being checked as above, the depth can be adjusted by screwing the nuts (C) on the limiter
struts in or out.

62 12.01.2011
ver. 1.0
ST 400-900S

3.24.3 Lowering the machine to the work position


When lowering the machine to the work position, keep the hydraulic lever in the lowering position
for an extra second or two until the preset coulter pressure has been obtained. On tractors featuring
hydraulic levers with adjustable flow duration, use that feature with advantage.

3.24.4 Adjusting the low lift height


When drilling, the low-lift function must be used to prevent the pre-implement and seed drill unit
being raised more than necessary on the headland. Using the low-lift function also results in side
bout markers and pre-emergence bout marker reacting more quickly. For instructions regarding
the use of the low-lift function and the setting of low-lift heights, see ”3.5.3 Programming” on
page 31.
NOTE!The machine must not be reversed in the low-lift position.

3.24.5 Setting the height of the packer wheels

Figure 3.55

The packer wheels of the drilling units can be set at three different heights. Upon delivery, the
wheels have been set to the centre positions (A).
The upper holes (B) can be used when the drill discs have worn down or if an extreme drilling
depth is desired.
Use the lower holes (C) for very shallow drilling.

12.01.2011
ver.1.0 63
Instructions and settings

3.24.6 Adjusting the distance between the seed drill unit’s discs

Figure 3.56

There should be a distance of at least 2 mm between the seed drill unit’s discs. Turn the discs and
check the distance for the entire rotation. The discs must remain apart in all positions.
When the discs are worn such that the distance between them is 10 mm, the seed drill unit must
be adjusted. Undo the screw(s) (A) and remove the disc(s). Remove one or more washers (B). The
washers are 0.5 mm thick. Reinstall the discs.
After installation, check that the scraper is just in contact with the discs.

64 12.01.2011
ver. 1.0
ST 400-900S

3.24.7 Setting the work depth for the front tool


When the machine is lowered to the operating position, the pre-implement and the seed drill unit
go down to the set working depth.
The working depth for the front tool is set with the aid of a separate hydraulic circuit. This circuit
includes a ‘memory cylinder’, which entails that the front tool returns to the set working depth
when the machine is lowered, for example after turning.
Adjustment of the work depth should always be done in the field and as follows:
1 Lower the front tool and seed drill unit with the hydraulic circuit for machine raising/lowering
(hoses marked yellow). The front tool stops at the depth at which the memory cylinder is set.
2 Adjust the working depth for the front tool by altering the position of the memory cylinder with
its hydraulic circuit during operation (hosed marked white).
3 In the centre of the front row of discs is a V-shaped centre disc. The centre disc can be adjusted
using a crank (A) to prevent a bank or dyke forming in the centre of the drawbar.

Figure 3.57

Memory ram function


A Piston rod for lifting and lowering the front tool. The piston rod is regulated by the hydraulic
circuit with hoses that are marked yellow.
B Ram puck for adjusting the ram stroke and thereby the work depth of the front tool. The puck
position is adjusted by the hydraulic circuit with hoses marked in white.

B A

Figure 3.58

12.01.2011
ver.1.0 65
Instructions and settings

3.24.8 Adjusting the working angle on Crossboard

Figure 3.59

If the machine is equipped with System Disc and Crossboard, the Crossboard’s angle can be ad-
justed hydraulically. The hydraulic circuit is connected to the circuit for folding the wing sections.
A valve (C) on the left side of the frame determines whether the circuit is regulating folding of the
wing sections or adjustment of the Crossboard’s angle of attack.
Position 1: Adjusting angle of attack for Crossboard
Position 2: Folding wing sections

3.24.9 Adjustable track eradicator pins for System Disc Aggressive with Crossboard
(accessory)

Figure 3.60

The machine can be fitted with adjustable track eradicator pins. The pins loosen the soil after the
tractor's wheel tracks.
Loosen the cotter pins (C) and select a new placement in the hole series to change the pin height.

66 12.01.2011
ver. 1.0
ST 400-900S

3.24.10 Adjusting the low lift height


When drilling, the low-lift function must be used to prevent the pre-implement and seed drill unit
being raised more than necessary on the headland. Using the low-lift function also results in side
bout markers and pre-emergence bout marker reacting more quickly. For instructions regarding
the use of the low-lift function and the setting of low-lift heights, see ”3.5.3 Programming” on
page 31.
NOTE!The machine must not be reversed in the low-lift position.

3.24.11 Setting the spill prevention plates

Figure 3.61

The spill prevention plates that are fixed to the System Disc pre-implement should travel just
above ground level. Note that the height of the spill prevention plates should be adjusted in case
of a considerable change of the System Disc work depth.
To adjust the plate height, remove the screws (A) and turn the plate arm to the required position.
On the ST 900S, the spill prevention plate must be removed from the frame during transport in
order to clear the transport height of 4m. Undo four nuts (B) and the clamp. The frame can be
marked to indicate whether it should be fitted back on again.

12.01.2011
ver.1.0 67
Instructions and settings

3.25 Setting the weight transfer

E
Figure 3.62

To adjust weight transfer to the wing sections, adjust the upper knob (C) inside the cover on the
front face of the seed hopper. The manometer (D) displays the set pressure. Note that the knob has
a locking nut that must be slackened before making an adjustment and then tightened again.
The weight transfer is normally preset to 30-60 bar. This pressure works well in most conditions
and does not normally need to be adjusted.
The weight transfer hydraulic pressure is altered as follows:
A Fold out the machine to the work position.
B Raise the seed drill unit and pre-implement fully.
C Open with the knob (C).
D Apply pressure to the wing section hydraulics so that the wings begin to lift.
E Check that the manometer (D) shows 0 bar.
F Operate the folding down hydraulics until the folding ram is completely extended and so that
the weight transfer ram (E) is slightly compressed, until the manometer displays the desired
pressure.
G Close with the knob (C) and lock with the locking nut.
H Check that the weight transfer ram (E) is stilly slightly compressed. Check the manometer
pressure (D).
! Increased manometer pressure provides more weight on the wing sections.

68 12.01.2011
ver. 1.0
ST 400-900S

3.26 Setting the seed coulter pressure

Figure 3.63

The seed coulter pressure can be adjusted using the cock (A) on the front face of the seed hopper.
The manometer (B) displays the set pressure. Note that the cock has a locking nut that must be
slackened before making an adjustment and then tightened again.
The default setting is 30 bar. This pressure works well under most light soil conditions and does
not normally require adjustment.
If the seed coulter pressure needs to be changed, proceed as follows:
If the hydraulic coupling used for raising the machine can be locked:
1 Raise the seed drilling units and System Disc as far as they will go.
2 Fully open the cock (A).
3 Lower the machine and set the hydraulic control for a constant flow.
4 Step down from the tractor. Turn the cock (A) clockwise until the desired seed coulter pressure
is obtained. Check the manometer (B). Tighten the lock nut for the cock.
5 If the pressure becomes too high, repeat the procedure from step 1.
6 Raise the seed drilling units and System Disc as far as they will go.
7 Lower the machine and keep the hydraulic lever in the applied position for a few seconds.
Check whether the desired seed coulter pressure has been obtained. If further adjustment of the
pressure is required, then repeat from step 1.
If the hydraulic coupling used for raising the machine cannot be locked:
1 Raise the seed drilling units and System Disc as far as they will go.
2 Fully open the cock (A).
3 Turn the cock (A) clockwise about one full turn.
4 Lower the machine and keep the hydraulic lever in the applied position for a few seconds.
5 Check the actual seed coulter pressure on the manometer (B). If the desired pressure has been
achieved, close the cock (A). If further adjustment of the pressure is required, then repeat from
step 1.

12.01.2011
ver.1.0 69
Instructions and settings

3.26.1 Drill coulter pressure


The pressure in the hydraulic system will vary between different machines depending on the
number of seed coulter units on the machine, i.e. machine width and seed coulter separation The
actual pressure of the seed coulters will however be adjustable between approx. 40-80kg.
A lower drill coulter pressure is recommended on light sandy soils whilst a heavier soil type may
need a higher drill coulter pressure. To prevent the machine from being overloaded, there is an in-
built maximum limit in the system.

Tabell 3.3 Drill coulter pressure


ST 400S ST 600S ST 800S ST 900S
125 167 125 167 125 167 125 167

25 bar 37 42 33 37 37 42 35 39
30 bar 40 47 36 41 40 47 38 44
35 bar 43 51 38 43 43 51 41 47
40 bar 46 54 40 46 46 54 43 51
45 bar 48 57 42 48 48 57 45 53
50 bar 51 62 44 52 51 62 48 57
55 bar 54 64 46 54 54 64 50 60
60 bar 57 69 48 57 57 69 53 64
70 bar 63 77 53 63 63 77 58 71
80 bar 68 84 57 69 68 84 63 77
90 bar 74 61 75 74 68
100 bar 79 65 80 79 73
110 bar 70 78
120 bar 73 82
130 bar 78 87

70 12.01.2011
ver. 1.0
ST 400-900S

3.27 Adjusting the following harrow


E

Figure 3.64

The following harrow’s working pressure and angle of attack can be adjusted by turning the
screws (E) clockwise or counterclockwise.
! Clockwise increases the working pressure.
! Counterclockwise reduces the working pressure.

12.01.2011
ver.1.0 71
Instructions and settings

3.28 Levelling units

Figure 3.65

Between the wheels, and beyond the outer wheel, there are levelling units in the form of rubber
bars. The purpose of the levelling units is to level the small soil banks that may form in certain
circumstances.
If necessary, the levelling units can be vertically adjusted. To adjust, loosen the screw clamp (A)
and move the bar up or down.

72 12.01.2011
ver. 1.0
ST 400-900S

3.29 Setting the pre-emergence bout markers

Figure 3.66

The pre-emergence bout marker should be adjusted to the tramlining width. Move the tines (A)
laterally on the frame. The angle of the bout marker discs can be adjusted by turning the shafts (B)
in their holders.

12.01.2011
ver.1.0 73
Instructions and settings

3.30 Tramlining
3.30.1 Setting tramlines
With the ST 400, tramlines can be laid at 8, 12, 16, 20, 24 m and so on.
With the ST 600, tramlines can be laid at 12, 18, 24, 30 m and so on.
With the ST 800, tramlines can be laid at 16, 24, 32, 40 m and so on.
With the ST 900, tramlines can be laid at 18, 27, 36, 45 m and so on.
The tracks are always laid symmetrically on either side of the machine centreline. The drill is sup-
plied having two or three row shut-off. Before verifying or changing the wheel track width, refer
to ”3.9.1 Adjusting track width, machines with 125 mm seed coulter separation” on page 41.

Keep the button depressed until the digit for the chosen tramlining programme is marked.

Select the desired tramlining interval with the selection dial and confirm with . Advance to

the first bout start value using . Also see ”3.5.2 Functions” on page 27.
Tramlines will be laid when indication lamp 6 lights. For successful tramlining, it is important to
plan tramlining before starting the work.
Example: The ST 600 is to lay 24 m tramlines. Set the multiples selector to 4 (24/6 = 4). Advance
to start value 2.

ST 400/4 m
ST 600/6 m
ST 800/8 m
ST 900/9 m

ST 400/8 m
ST 600/12 m
ST 800/16 m
ST 900/18 m

ST 400/12 m
ST 600/18 m
ST 800/24 m
ST 900/27 m

ST 400/16 m
ST 600/24 m
ST 800/32 m
ST 900/36 m

ST 400/20 m
ST 600/30 m
ST 800/40 m
ST 900/45 m

Figure 3.67

74 12.01.2011
ver. 1.0
ST 400-900S

Table 3.4 Examples of tramlining systems for the ST 600S


Width, Tramline marker Start Notes
tramline programme, value
marking
12m 2 1 First bout overlapped by half by the next bout.*
18m 3 2
20m 31 NOTE! Requires some modification of the machine.
Contact Väderstad-verken AB for more information.
24m 4 2 First bout overlapped by half by the next bout.*
30 m 5 3
36 m 6 3 First bout overlapped by half by the next bout.*
* The ST 400-600S is equipped with mechanical half machine shut off, while the ST 600S XL and
ST 800-900S are equipped with automatic half machine shut off, see ”4.2 Half machine shut off”
on page 76 which should preferably be used for the first row. Do not forget to reset the feed
amount before the third bout.

12.01.2011
ver.1.0 75
Driving

4 Driving

4.1 Setting and raising the drill in furrows


A When the machine is lowered to the working position, the System Disc will be lowered to the
set working depth and the seed drill unit will be lowered to the set drilling depth. The bout
markers will also unfold.
! Keep the hydraulic lever in the lowering position for a few seconds until the desired seed
coulter pressure has been achieved. On tractors that are equipped with hydraulic control with
adjustable flow duration, this function can be used to advantage.
B When the machine is raised, the System Disc and seed drill unit will be raised to the set low-
lift heights. The bout markers are also folded in.

4.2 Half machine shut off


4.2.1 0.1.1Automatic shutting off half the machine
ST 600S XL, ST 800S, ST 900S feature shutting off half the machine as a function in Control sta-
tion also refer to ” Half machine shut off (ST 600S XL, ST 800S, ST 900S)” on page 29.

4.2.2 0.1.2Mechanical shutting off half the machine


ST 400S and ST 600S are equipped with mechanical shutting off half the machine. You can shut
off the supply of cereals to half of the seed hoses by turning the cover to the distributor housing
and moving it to the right position. It is important to make sure which hoses have been closed, e.g.
by checking the seed feed, see ”3.5.1 Functional description” on page 25.
NOTE!As half of the seed hoses have been shut off, the feed amount needs to be reduced by 50 %
in Control Station so that the amount of delivered seed is the same across the entire field, see ”
The pre-emergence bout marker should be adjusted to the tramlining width. Move the tines (A)
laterally on the frame. The angle of the bout marker discs can be adjusted by turning the shafts (B)
in their holders.” on page 73. Do not forget to reset the feed amount when the cover is turned back
again to full width.

76 12.01.2011
ver. 1.0
ST 400-900S

4.3 Drilling depth and seed coulter pressure

Figure 4.1

See ”3.24 Setting the sowing depth” on page 62 and ”3.26 Setting the seed coulter pressure” on
page 69.
Probably the most important task the seed drill operator needs to attend to is to carefully and con-
tinually monitor the drilling depth.
The drilling depth used must be adjusted to suit the crop in question, the soil type and the state of
the tilth at the time of sowing. Shallow sowing calls for very good conditions for germination in
terms of moisture and fine tilth, for example in silty soils. Drilling too deep can give rise to weaker
plants.
In fields with varying soil types the depth setting should be checked and adjusted to ensure the
correct drilling depth across the entire field.
Drilling depth must be adjusted so that the seed is placed in moist soil, but not too deep. The cor-
rect preparation of the tilth prior to sowing is essential for producing the right conditions for ger-
mination.
The drilling depth should be checked regularly throughout the day. Preferably this should be done
once every hour. Check the drilling depth midway between the tractor tracks, in the actual tractor
track, and behind the left and the right wing sections. If the drilling depths under the wing sections
deviate from that of the centre section, then check the hydraulic system function and setting, see
”3.25 Setting the weight transfer” on page 68 and ”3.26 Setting the seed coulter pressure” on
page 69. This applies, among other things, to the weight transfer to the wing sections. When work-
ing on hard soil, the pre-implement may require a larger amount of weight transfer. When sowing
small-size seed on loose soil, it may be necessary to reduce the amount of weight transfer.

12.01.2011
ver.1.0 77
Driving

4.4 Checking the seed feed rate

Figure 4.2

The seed feed should be checked at the same time as the sowing depth is checked, i.e. preferably
once per hour.
Raise the seed drilling units and System Disc to the low-lift height. Then switch to full lift.

Start the fan. Press or on the Control Station for a few seconds. Leave the tractor and
check that seed feed has taken place. Repeat this procedure if it is not clear that seed is being fed
out.
Start with the machine switched to tramlining, when all coulters except those which are closed for
tramlining should be delivering seed. Then advance the control for the tramlining function and
check to see if these coulters now deliver seed.
This sowing system has been developed to deliver seed evenly and in reliable quantities.
Väderstad-Verken AB shall however not be liable for damage that has not occurred in the seed
drilling machine itself. This includes the fact that we accept no liability for damages due to errors
in seed feed or fertiliser dosage.
It is the responsibility of the user to use seed which has been treated correctly with an additive of
a type which does not impair the functioning of the seed feed mechanism or prevent proper seed
feeding.

78 12.01.2011
ver. 1.0
ST 400-900S

5 Maintenance and service

5.1 Securing the seed drill machine for service

Figure 5.1

Figure 5.2

NOTE!Due to the danger of crush injuries, the machine must be supported safely on stands when-
ever any work is carried out on it.
When service of the drilling units is required, first secure them on trestles. Completely raise the
drilling units and place trestles under the frame tubes used to lift the units, in accordance with
“Figure 5.1”. Note that at least one trestle is required for each section (centre section and the two
wing sections).
When service of the System Disc is required, first secure the pre-implement sections on trestles.
Completely raise the pre-implement and put trestles under it as shown in “Figure 5.2”. Note that
at least one trestle is required for each section (centre section and the two wing sections).
! Ensure also that the surface supporting the trestles is firm enough to support them.
Be sure to always extend the wings and lower the drilling units and System Disc to the ground
before performing any servicing on the hydraulic system!

12.01.2011
ver.1.0 79
Maintenance and service

5.2 General

Figure 5.3

! A machine is only as good as the service it receives.


! Before driving off, make sure that all screws and nuts are tight. During the season, check peri-
odically that the nuts and bolts have not worked loose and inspect joints and hydraulic ram
mountings for wear.
! Re-tighten the nuts on the two outer wheels on each side of the centre section after 10 - 15 km
of road transport. Re-tighten the nuts similarly after changing wheels. Wheel nuts must be
tightened and checked for tightness using a torque wrench.
Tightening torque: 330 Nm (33 kpm).

Figure 5.4

! Bolts and nuts forming part of a joint must not be tightened so much that the jointed parts are
clamped to each other.
! The hydraulic system will not normally require any maintenance but check that hoses and cou-
plings have not been damaged.
! Be sure to keep dirt away whenever work needs to be performed on the hydraulic system!
Clean off with clean paper or rags. Place parts on a clean surface (not straight on to the work
bench). Rinse before assembling, for example with degreasing agent.
! Smear grease or oil on to the piston rods if the seed drill is not going to be used for longer pe-
riods of time, and always after cleaning it.
! Lubricate galvanised and chrome-plated surfaces with grease before long periods of storage.
! To preserve the high quality of the drill, always use genuine Väderstad spare parts.

80 12.01.2011
ver. 1.0
ST 400-900S

5.3 Lubrication points


Pay attention to safety! Don’t crawl under the machine. Lubricate from above or support the ma-
chine securely on trestles. See ”1 Safety rules” on page 9.
Lubricate according to ”Figure 5.5 ” on page 81 and ”Table 5.1 Lubrication points and lubrica-
tion intervals” on page 82 using 2-3 piston strokes per nipple..

A B

D E F C G
Figure 5.5

12.01.2011
ver.1.0 81
Maintenance and service

A B C

D
E F

Figure 5.6

Table 5.1 Lubrication points and lubrication intervals


Lubrication points Lubrication interval Number
500 ha/season 400 600 800 900
A Bout markers X 6 6 6
B Hinges, wing section pivots X 4 4 4 4
C Hydraulic ram X 14 14 18 18
D System Disc parallel linkage X 6 6 6 6
E Turnbuckles X 8 12 12 12
F Rocker shaft, front X 12 12 12 12
G Wheel hubs, supporting wheels X 8 12 16 18

NOTE!On braked machines the four braked hubs on the load bearing wheels cannot be lubricated.
Lubricate all the greasing points in accordance with the stated lubrication intervals, and always
after high pressure washing.
Never flush water directly on bearings! Seals can easily be damaged when using a high-pressure
water jet, which results in rusty ball bearings!
Lubricate at the end of each season.

82 12.01.2011
ver. 1.0
ST 400-900S

5.4 Cleaning

Figure 5.7 Figure 5.8

Check at regular intervals, and at the end of each season, that no seed or packaging remains have
got into the seed hoses or the seed head outlets. At the same time check the cleanliness and oper-
ation of the tramline units.
Clean the seed hoppers, rape seed brushes and metering unit along with other parts at the end of
the season. Check that there is no seed left in the ejector tubes and associated air hoses.
Remember that any remaining seed that sprouts can block the air and seed hoses. Seed can also
attract small rodents, which can damage the machine.
Clean the clear plastic covers in the seed heads before the season starts.
Keep the fan running for a while, so that the whole system is blown dry.

12.01.2011
ver.1.0 83
Maintenance and service

5.4.1 Cleaning the rapeseed rotor


Dismantle the rapeseed rotor and clean it if required. This should always be cleaned at the end of
the season. Remove the rotor (see ”3.18 Rotor replacement” on page 52). Undo the two screws
holding the rotor together. Dismantle the rotor and clean each part separately. The pulse washer
on the end of the rotor should not be removed.

OK

Figure 5.9

Assemble the rotor in reverse order. NOTE! Make sure that the rotor rings are fitted correctly.

5.4.2 Cleaning the grass rotor


Dismantle the grass rotor and clean it if required. This should always be cleaned at the end of the
season. Remove the rotor (see ”3.18 Rotor replacement” on page 52). Undo the two screws
holding the rotor together. Dismantle the rotor and clean each part separately. The pulse washer
on the end of the rotor should not be removed.

x 22

OK

Figure 5.10

Assemble the rotor in reverse order. NOTE! Make sure that the rotor rings are fitted correctly.

84 12.01.2011
ver. 1.0
ST 400-900S

5.5 Storage of the machine


When not in use the machine should be stored indoors. This is particularly important since the ma-
chine contains electronic equipment. The electronic components are of a very high standard and
are normally unaffected by damp, but we recommend nevertheless that the machine is stored in-
doors. The Control Station should be stored at room temperature during the winter and in between
seasons.
Shiny machine parts, such as piston rods and wearing parts, should be coated in grease or oil for
the winter.
Make sure that the drill is thoroughly cleaned. Allow the emptying hatches to remain open and
remove the air hose from the ejector tube, to facilitate ventilation.
Prior to folding down the drill in temperatures below 0°, it must be parked for a while in a heated
building to allow the drill hoses to regain their softness.

12.01.2011
ver.1.0 85
Maintenance and service

5.6 Replacing the disc hub, System Disc

Figure 5.11

NOTE!Make sure the pre-implements rest properly on solid supports. Be sure to keep dirt away
whenever work needs to be performed on the bearing!
Dismantling
Remove the nut (A). The bearing can now be removed from the shaft pivot.
Fitting a new hub
Install the hub and the O-ring on the shaft pivot as shown in “Figure 5.11”. Fit a new nut and tight-
en it to a torque of 285 Nm.

5.7 Changing discs, System Disc


Make sure the pre-implements rest properly on solid supports. When replacing discs, use a counter
wrench or better still a nutrunner. Block the disc using a wood block or similar to prevent it from
turning. The discs have sharp edges - use gloves! Tighten the pinned head screws crosswise to a
torque of 105 Nm.

86 12.01.2011
ver. 1.0
ST 400-900S

5.8 Changing the hydraulic cylinder seals

Figure 5.12

NOTE!During service work on the hydraulic system, the wing sections and the drill must be fully
lowered, with no pressure in their hydraulic systems. Completely remove the cylinders from the
machine before changing their seals.

5.8.1 Replacing the ram seals on the master and slave rams
This applies to the lifting and pre-implement systems.
A Unscrew and remove the piston rod guide (A) using the hook wrench (B).
B Pull out the piston rod and change the seals. NOTE! Take great care to ensure that the seals
face in the correct direction.
C Check carefully that there are no scratches on the jacket lining (C).
D Refit the cylinder.
When replacing the seals, the overspill channel or holes should be polished with an abrasive cloth
in the longitudinal direction of the ram. Carefully flush the ram cylinder before reassembling.
NOTE!Check that the seals are fitted facing the correct direction. Also change the piston rod guide
(A) seals if necessary.
Fit the cylinder to the machine and bleed the hydraulic system, see ”3.24 Setting the sowing
depth” on page 62.

5.8.2 Replacing the seals on other rams


Proceed in accordance with ”5.8.1 Replacing the ram seals on the master and slave rams” on
page 87. Note however that these rams do not have any cuff seals nor overspill channels.

5.9 Bleeding the hydraulic system


See ”3.24 Setting the sowing depth” on page 62 and ”3.10 Setting up the pre-implement” on page
43.

12.01.2011
ver.1.0 87
Maintenance and service

5.10 Changing the fan speed sensor


B

C 1,5 mm

Figure 5.13

Disconnect the hydraulic hoses to the fan drive from the tractor’s hydraulic coupling before
commencing work.
1.Disconnect the electrical connector from the sensor.
2.Slacken the locking nut and unscrew the old sensor.
3.Loosen the screws A and lift out the fan cover B
4.Turn the fan wheel by hand so that the indicator plate C moves into position as shown in figure
1.0.
5.Screw in the new sensor. First, tighten the sensor until it comes into contact with the indicator
plate. Then unscrew it by 1.5 turns. The distance between the sensor and the indicator plate is then
1.5 mm. Tighten the locking nut.
6.Refit the fan cover B.
7.Connect the electrical connector to the sensor.
8.Connect the hydraulic hoses.

88 12.01.2011
ver. 1.0
ST 400-900S

5.11 Replacement of the feed output system rotation guard


1 Remove the rotor, see ”3.18 Rotor replacement” on page 52.
2 Undo the bearing (A) by gripping it from inside the seed box and twisting it out of its snap
mountings. Remove the gearbox and bearing.
A

Figure 5.14

Figure 5.15

3 Remove the cable for the rotation guard.


4 Undo the screws (A) that hold the cable in place.
5 Undo the counter-nut and remove the old sensor.
6 Screw in the new sensor and fit and connect the cable.
7 Fit the bearing.
8 Fit the rotor.
9 Position the sensor so that it is approx. 1.5-2.5 mm from the rotor pulse washer.
The sensor LED will flash when the rotor is rotating.

Figure 5.16

10 Fit the gearbox.

12.01.2011
ver.1.0 89
Maintenance and service

5.12 Repair and exchange of the seed hoses

Figure 5.17

Repair
If a seed hose is damaged due to abrasion or folding, it can be jointed with a sleeve, part no.
415397 for a 32 mm diameter seed hose. This measurement is the outer diameter of the sleeve and
the inner diameter of the hose. Cut the hose at the centre of the fold or damage. If necessary the
smallest possible part of the hose can be cut away. If the hose becomes too stiff at the joint and
cannot be bent enough when the machine is lowered, it may be necessary to change the entire seed
hose, or to change part of the hose and joint it at two places.
Changing a seed hose
Use soapy water on the hoses when removing or fitting them to drill coulters. Twist the hose coun-
terclockwise when removing or fitting, which will help the spiral reinforcement to "open" a little.
Cut the spare hose to the same length as the old hose.

90 12.01.2011
ver. 1.0
ST 400-900S

5.13 Inspecting the seed drill's towing hitch


A B C D

Max. +2.5 mm

Figure 5.18

5.13.1 Alternative towing hitches


A 50 mm diameter towing eye (standard).
B 40 mm diameter towing eye.
C 80 mm diameter ball hitch.
D 57 mm diameter swivel hitch.

5.13.2 Re-tightening the hitch securing bolts


The hitch securing bolts (E) must be re-tightened at regular intervals. Tightening torque 277 Nm.

5.13.3 Wear limit


When the diameter of the hole in the towing eye has increased by 2.5 mm, it has reached its wear
limit and it is time to change the eye.
When fitting a new towing eye, new bolts must be used. Tighten the hitch securing bolts (E) to
277 Nm. Use a torque wrench.
NOTE!Never weld a towing eye, since this can drastically reduce its strength!

12.01.2011
ver.1.0 91
Maintenance and service

5.14 Wing section locking devices

Figure 5.19

Regularly verify proper operation of the locking devices. Clean as required.


NOTE!Never walk under a suspended wing section!

5.15 Inspect the wheel bearing play


B
A C

Figure 5.20

It is extremely important that the wheel bearing play is adjusted after the end of the first season.
Check the wheels and if any play is felt, tighten the bearings.
1 Remove the hub cap (A) and undo the locking pin (B)
2 Retighten the castle nut (C) with a hand tool.
3 Now loosen the castle nut so that the wheel rolls easily with no play.
4 Lock using the locking pin (B).
5 Fit the hub cap.

92 12.01.2011
ver. 1.0
ST 400-900S

5.16 Changing wheels


5.16.1 Outer wheels of the centre section

X X X X

5 6

X X X X

Figure 5.21

NOTE!Never walk under a suspended wing section. Always check that the automatic catches have
engaged before entering the wing section folding area.
NOTE!The wheels are heavy! Be very careful when handling them.
1 Fold up the machine into its transport mode.
2 Use a jack to lift the frame until the wheels are about 1 cm from the ground. Place an axle stand
under the frame, in front of the wheels. Note that the ground must be stable.
3 Detach the outer wheel from the hub.
4 Detach the stub axle for the inner wheel.
5 Fold out the machine to the work position.
6 Lift up the wheel, together with the stub axle and hub, with the aid of an overhead crane, fork
lift truck or similar lifting device.
7 During reassembly, tighten the stub axle to 900 Nm. Use a torque wrench.
NOTE!The brakes on braked machines must be dismantled to change the inner wheel. The hub
cap and castle nut are removed after which the washer, ball-bearing and brake drum are lifted off.
In the event of uncertainty contact professional service personnel as the brakes are a safety com-
ponent. It is extremely important that all components are kept clean and bearings are greased dur-
ing assembly. The hub is filled to 50-70% with grease and the hub cap can be filled completely
with grease to ensure the bearings are sufficiently lubricated without risking grease being forced
into the brake system. The system must be bled after assembling the brakes.

12.01.2011
ver.1.0 93
Maintenance and service

5.16.2 The two centre wheels

X X

Figure 5.22

NOTE!The wheels are heavy! Be very careful when handling them.


1 Fold out the machine to the work position.
2 Drive the undamaged centre wheel up onto a plank or similar support, to give the damaged
wheel a few centimetres of clearance.

Figure 5.23

3 Remove the seed feed system riser pipes.


4 Detach the wheel from the wheel carriage.
5 Raise the wheel. Take care not to damage the distributor head and seed hoses.

5.16.3 Wing section wheels

X X X X X X

Figure 5.24

NOTE!Never walk under a suspended wing section. Always check that the automatic catches have
engaged before entering the wing section folding area.
1 Fold out the machine to the work position.
2 Detach the wheel.
3 Carefully fold up the machine into its transport mode. Check that the wheel does not catch on
any part of the machine.

94 12.01.2011
ver. 1.0
ST 400-900S

5.17 Hydraulic brakes (option)


5.17.1 Bleeding the brake system

Figure 5.25

Following maintenance or other work on the hydraulic system, the brake system must be bled be-
fore use.
1 The oil that is topped up in the system comes from the tractor.
2 Connect the hydraulic hose of the brake system to the tractor and apply the brakes.
3 Bleed the system using the nipple (B), which is located adjacent to the brake line connections
at each braked wheel. Be careful! First bleed the wheel that is furthest away from the main cyl-
inder (i.e. the wheel furthest away on the right-hand side) and continue to bleed left wheel/right
wheel until all the air has been forced out of the lines. Connect the transparent hose to the nip-
ple and allow surplus oil to run into a suitable container. Close the nipple when no more air
bubbles can be seen in the hose.

5.17.2 Replacing brake components


NOTE!Incorrect handling can result in a risk of the brakes not working as they should. If in doubt,
contact a professional service engineer.
The brake system’s brake cylinders, brake shoes and brake drums are wearing parts. When replac-
ing a component, the entire component must be replaced.
NOTE!The brake shoes must not be replaced individually. All the brake shoes must be replaced
simultaneously. The same applies when replacing the brake cylinders, which must also all be re-
placed at the same time.

12.01.2011
ver.1.0 95
Maintenance and service

5.18 Pneumatic brakes (option)


5.18.1 Daily maintenance

B
Figure 5.26 Figure 5.27

1 Drain off the condensation water from the compressed air container. Open the discharge valve
(B) on the underside of the container.
2 Check the oil level in the container (C) on the main ram. The level should be between the Max
and Min markings on the container. Top up with mineral oil type GL-4 or equivalent for hy-
draulic systems if the level is too low.
NOTE!The mineral oil should be type GL-4 or equivalent. Other types of brake fluid will damage
the system’s seals.

5.18.2 Maintenance
1 Check the oil level. Top up with new oil if necessary. Use mineral oil type GL-4 or equivalent.
2 Check that all lines, hoses and brake cylinders are undamaged and that they are not leaking.
3 If the brake action is slow, disassemble the line filters for cleaning, wash and dry the filters as
required.

Figure 5.28

96 12.01.2011
ver. 1.0
ST 400-900S

5.18.3 Bleeding the brake system

B
A
Figure 5.29

Following maintenance or other work on the hydraulic system, the brake system must be bled be-
fore use.
1 Top up the container (A) with oil to the Max marking.
2 Connect a brake bleeding tool (max. 1 bar) to the main ram
or
connect the compressed air line and the control line to the tractor and apply the brakes
or
connect the compressed air line and the control line to an external compressed air source (max.
6 bar).
3 Bleed the system using the nipple (B), which is located adjacent to the brake line connections
at each wheel. Be careful! First bleed the wheel that is furthest away from the main cylinder
(i.e. the wheel furthest away on the right-hand side) and continue to bleed left wheel/right
wheel until all the air has been forced out of the lines. Connect the transparent hose to the nip-
ple and allow surplus oil to run into a suitable container. Close the nipple when no more air
bubbles can be seen in the hose.
NOTE!If the oil is not topped up when the level is below the Min marking, there is a risk that air
can penetrate the system.

5.18.4 Replacing brake components


NOTE!Incorrect handling can result in a risk of the brakes not working as they should. If in doubt,
contact a professional service engineer.
The brake system’s main ram, wheel cylinders, brake pads and brake drums are wearing parts.
When replacing a component, the entire component must be replaced.
NOTE!The brake pads must not be replaced individually. All the brake pads must be replaced si-
multaneously. The same applies when replacing the wheel cylinders, which must also all be re-
placed at the same time.

12.01.2011
ver.1.0 97
Troubleshooting

6 Troubleshooting

6.1 General information on troubleshooting


Many of the functions of the seed drill are controlled by a series of electrical, hydraulic and me-
chanical components. A good way to immediately exclude many of the sources of faults is to first
determine whether or not the fault is electrical. Because of this, first check whether the electrical
circuit is intact right up to the last electrical component in the chain.
Then continue troubleshooting by first performing the easiest inspections, in order to quickly ex-
clude other sources of faults.
Study the appendices”7.2 Hydraulic system schematic diagram” on page 109 and ”7.3 Electrical
system” on page 115, which can be useful during troubleshooting, and also the descriptions in
”3.5 Control Station” on page 24.

6.1.1 Electric faults


General checks in the case of electrical faults:
! Is the Control Station correctly connected to the tractor?
! Is at least 12 V being supplied to the Control Station from the tractor?
! Have the + (brown) and ground (blue) wires been connected properly?
! Check whether the automatic circuit breaker in the Control Station has tripped.
! Check the Control Station settings.
! Check whether both connectors of the intermediate cable are correctly connected to the Control
Station and the Work Station.
! Check that all the connectors, pins and sockets are clean, free from damage and are not pushed
inwards. Spray the switches with contact spray that is intended for use with electronic
equipment.
! Check that all cables are correctly connected and that no cable is crushed or otherwise
damaged.
! Check that the power cable fuse is whole.

6.1.2 Hydraulic faults


General checks in the case of hydraulic faults:
! Check that all hydraulic hoses are connected.
! Check that the hydraulic hoses have been connected to the correct hydraulic couplings on the
tractor. Hoses with the same colour coding constitute a pair.
! Make sure the hydraulic hoses' quick-release couplings are dimensioned for and fit the cou-
plings on the tractor. There are many types of coupling available on the market, and although
they are standardised problems can still exist. Problems that may appear could be that female
and male couplings operate as non-return valves, i.e. that the machine can be raised but not
lowered or vice versa. The problem may be aggravated by a high flow rate or worn couplings.
! If the hydraulic valve on the oil cooler is leaking large quantities of oil, this may be because
the return line is not depressurised.

98 12.01.2011
ver. 1.0
ST 400-900S

6.1.3 Hydraulic solenoid valves


An electrically operated solenoid valve contains a coil that acts as an electromagnet when current
is fed to the valve. The following prove that current is present in the valve:
The diode in the connector lights and the coil becomes warm after a few minutes. Also, the nut on
the top of the valve becomes magnetised.
Use a small screwdriver or the edge of a knife blade to check whether the nut on top of the valve
is magnetised. Since weak residual magnetism may be present in the nut, perform this check with
the power switched both on and off.

6.1.4 Magnetic switch

Figure 6.1

A reed switch is a switch (or a sensor) that reacts to a magnetic field. Inside the reed switch is a
glass tube containing two metal reeds that attract to each other when subjected to a magnetic field
from a magnet. See the illustration. Reed switch operation can easily be tested using a multimeter
and a magnet.

6.1.5 Inductive sensor

Figure 6.2

Reacts to metal objects.


A functional test can be easily made since an LED at the rear of the sensor lights each time it sens-
es a ferrous metal object.

6.1.6 Capacitive sensor

Figure 6.3

Reacts to matter containing humidity, such as cereals, a hand, etc.


A functional test can be easily made since an LED at the rear of the sensor lights each time it sens-
es a moist object.

12.01.2011
ver.1.0 99
Troubleshooting

6.2 Troubleshooting list

The Control Station does not op-


erate when the main switch is
switched on. - See ”6.1.1 Electric faults” on page 98.

The bout marker(s) fail to go


down. - Check in accordance with ”6.1.1 Electric faults” on
page 98.
- Check in accordance with ”6.1.2 Hydraulic faults” on
page 98.
- Check that one of the marker lamps on the Control
Station is lit.
- Check whether the machine is at or above the low-lift
height. (For safety reasons the bout markers cannot be
unfolded in the low-lift mode or at a higher height.)

The marker or markers fail to re-


tract. - Probably due to dirt in the solenoid valve. Note that
dirt causing faults is often invisible. It is recommend-
ed that solenoid valves are changed.
- It should always be possible to retract both markers,
regardless of the settings and indications on the Con-
trol Station, and even if the Control Station is
switched off.

100 12.01.2011
ver. 1.0
ST 400-900S

The folded up marker or markers


slowly extend, inadvertently. - Check that the appropriate marker indicator lamp on
the Control Station is not lit.
- Check that there is no current supply to the marker
electrical solenoid valves, see ”6.1.3 Hydraulic sole-
noid valves” on page 99.
- Swap the right and left marker solenoid valves.
If the fault moves to the other side, the solenoid valve
must be faulty.
If the fault remains, the marker hydraulic cylinder is
probably defective.
- Remove the solenoid valve and check that it is free
from dirt, and that the outer seals of the valve are in-
tact and undamaged.
NOTE! First lower the seed drilling units to the
ground and release the hydraulic pressure.
- Check that the marker cylinder is not leaking external-
ly or internally. In the case that the seals need to be
changed refer to ”5.8 Changing the hydraulic cylin-
der seals” on page 87.

Automatic shifting of the bout or


tramline markers does not take
place. - Is the Control Station set to auto advancing?
- Has the bout marker function selector been set to the
alternating position? The indicator lamp in the button
should light.
- Has the correct tramlining programme been selected?
- Check for a possible break in the wiring or a short-
circuit.
- Check the operation of the pressure sensor. The left

hand indicator lamp at the button on the


Control Station must flash when the seed drill unit is
raised.

The seed drilling units can be


raised even though the lift stop is
engaged. - Check that the solenoid valve on the valve block is re-
ceiving current. See ”6.1.3 Hydraulic solenoid
valves” on page 99.

If the lift stop valve has no current: - See ”6.1.1 Electric faults” on page 98.

If the lift stop valve has voltage: - See ”6.1.2 Hydraulic faults” on page 98.

12.01.2011
ver.1.0 101
Troubleshooting

The seed drilling units cannot be


raised or lowered. - Check whether the lift stop or low-lift mode has been
set.
- See ”6.1.2 Hydraulic faults” on page 98.

If the seed drilling units cannot be


raised: - Check whether the lift stop or low-lift mode has been
set.
- See ”6.1.2 Hydraulic faults” on page 98.
- Check whether the lift stop solenoid valve is receiving
current, either via a short-circuit or because of another
fault, see ”6.1.3 Hydraulic solenoid valves” on page
99.
- Switch off the Control Station and check whether the
seed drilling units can be raised. If the unit still cannot
be raised, the fault must be hydraulic.
- See ”6.1.1 Electric faults” on page 98.

The drilling depths of the centre


and wing sections are different. - Check whether the long ram rod of the folding ram is
completely extended and that the rod does not slowly
retract during driving.
- Check the weight transfer setting. See ”3.25 Setting
the weight transfer” on page 68.
- Check the settings of the master and slave systems.
See ”3.24 Setting the sowing depth” on page 62.

102 12.01.2011
ver. 1.0
ST 400-900S

The shaft seal in the fan hydrau-


lic motor is leaking. - Leakage from the hydraulic motor shaft seal may
be due to:
- Damage during assembly.
- Wear because of dirt.
- Wear because of high pressure in the drain line
- A damaged seal caused by very high pressure in the
drain line.
The pressure in the drain line can be measured at the
connection block if the plug (the connection marked
M) is replaced by an adapter for pressure measure-
ment. Use a 0-10 bar pressure gauge. During opera-
tion the pressure must not be greater than 2 bar.
- High pressure may be due to:
- A large oil flow in the drain line
- Counter-pressure in the hydraulic valve on the tractor.
Detach the drain line from the tractor and remove the
quick-release coupling. Start the fan. Collect the
drained oil in a container.
Measure the pressure. Measure the amount of oil that
comes out during one full minute.
A considerable pressure drop would indicate a prob-
lem with the tractor's hydraulic valve.
A small pressure drop would indicate an excessive
flow of oil. The drain flow should normally be less
than 3 litres per minute.
- A large oil flow may be due to:
- A worn motor
- A leaking one-way valve in the connection block. Oil
from the return line will then leak into the drain line.
Clean the outside of the connection block and remove
the hose between the motor and the block at port P3.
Carefully start the fan. fan. If oil comes out of the
block, the non-return valve is leaking.
Try cleaning the valve (it is preferable to let the valve
remain on the block). It is located between P3 and the
return channel (between the motor port and P1).

The area measurement and/or


speedometer show incorrect val-
ues. - Has the Control Station been programmed with the
correct number of pulses per metre? See ”3.5.3 Pro-
gramming” on page 31.
If the value in the area/speed field is too low, then re-
duce the number of pulses per metre.
If the value in the area/speed field is too high, then in-
crease the number of pulses per metre.

The display shows an incorrect


or variable feed amount sown. - Check that you have the correct rotor and gear in
accordance with the seed tables. Switch to a smaller
rotor and/or lower gear and perform a new calibration
test

12.01.2011
ver.1.0 103
Troubleshooting

6.3 Alarm list

1, 3 Low level seed. - Check the seed level in the hopper.

If there is seed in the hopper: - The sensitivity of the sensor has been incorrectly set.

2 Low level seed (concerns the


rear seed housing). - Check the fertiliser level in the hopper.

If there is fertiliser in the hopper: - The sensitivity of the sensor has been incorrectly set.

5, 7 Seed feed LH rotation.

If the seed housing does not move: - Check the gear setting and cabling
- Check the power supply to the feed

If the alarm appears despite the seed


housing rotating: - Check what alarm time has been programmed.
- Check the cabling, connectors and connections of the
sensor.
- Check the operation of the sensor. The sensor LED
should light when the toothed washer passes. The
distance between the sensor and the pulse disc must
be 1.5 - 2.5 mm. Adjust if necessary.
A lit LED, however, is not necessarily any guarantee
that the sensor is operating.
- Check the condition and installation of the toothed
wheel.

6 Seed feed RH Rotation


(concerns the rear seed
housing). - See alarm no. 5.

9 Low temp. - The machine will not start because the temperature is
below the lower limit for working temperature for
seed feeding.

10 High temp. - The machine will not start or stops because the system
has been overloaded.
- Check and clean the seed feeding if it has stopped.
- Wait until the machine has cooled.

11 Grass feed Rotation (BDA). - See alarm no. 5.

12 Tramline RH Failure. - This alarm occurs if tramlining does not take place
when the Control Station sends the signal for
tramlining, or if tramlining takes place when the
Control Station is not sending the signal for
tramlining.

104 12.01.2011
ver. 1.0
ST 400-900S

- Check the function of the tramlining units in the


distributor head, motor, turntable, springs and
hatches. Clean as required.
- Check the wiring, connectors and connections of the
sensor.
- Check the sensor.

13 Tramline LH Failure. - See alarm no. 12.

18 Fan seed Low rev. - Check whether the hydraulic hoses are connected
correctly to the tractor.
- Check that the flow of hydraulic oil from the tractor is
correctly adjusted.
- Check the alarm limit settings that are programmed
into the Control Station.
- Check that the fan shut-off cock is in the correct
position.
- Check the rotation speed sensor wiring, connectors
and connections.
- Check the sensor function by spinning the fan wheel
manually and checking the sensor LED. The LED
should light when the pin on the fan shaft passes by.
The distance between the sensor and the indicator
plate must be 1 - 2 mm. Adjust if necessary. A lit
LED, however, is not necessarily any guarantee that
the sensor is operating.
If the sensor needs to be changed, refer to”5.10
Changing the fan speed sensor” on page 88.
- If the alarm is only occasionally given, this is
probably because the sensor is either incorrectly
adjusted or defective.

19 Fan seed High rev. - Check that the flow of hydraulic oil from the tractor is
correctly adjusted.
- Check the alarm limit settings that are programmed
into the Control Station.

23 High voltage Workstation. - The tractor supplies a voltage of more than 17 V. The
Control Station remains on, but certain functions,
such as electric motors and hydraulic valves, are
switched off.

28 Work Station not connected. - Check whether the intermediate cable between the
Control Station and Work Station is connected.
Inspect the condition of the cable and connectors. The
green indicator lamp on the Work Station shows that
voltage is present, however, the lamp could light even
though the intermediate cable is partially damaged.

12.01.2011
ver.1.0 105
Troubleshooting

29 Voltage fault Workstation. - Work Station is receiving a voltage lower than 11 V.


Inspect the connections and connectors of the
intermediate cable. The functions of the hydraulic
system solenoid valves, etc. may cease to work.

31, 32 Level sensor LH seed. - Check the wiring, connectors and connections of the
sensor.
- Check that the sensor is not dirty or damp. Dry the
sensor with a dry cloth.
- The sensor may be defective.

34 Level sensor fertilizer


(concerns the rear seed
housing). - See alarm no. 31.

40 No speed. - This alarm occurs if the machine is lowered below low


lift height and stands still.

If the alarm is generated while the


machine is being driven forward: - Check the radar's wiring, connectors and connections.

43 Level sensor grass (BDA). - See alarm no. 31.

59 No GPS. - The system is programmed to be connected to GPS.


Check that the GPS unit is connected.

60 Max speed. - Check that you have the correct rotor and gear in
accordance with the seed tables. Switch to a larger
rotor and/or higher gear and perform a new
calibration test.

61 Overload protection . - The machine will not start or stops because the system
has been overloaded.
- Check and clean the seed feeding if it has stopped.

106 12.01.2011
ver. 1.0
ST 400-900S

7 Appendices
7.1 Seeding table
Gödning
Fertilizer
Dünger
Engrais

1,12 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 704 <   < 470 <   < 939 <   < 704 <   < 626 < 
9 km/h  < 463 <   < 309 <   < 618 <   < 463 <   < 412 < 
12 km/h  < 349 <   < 232 <   < 465 <   < 349 <   < 310 < 
15 km/h  < 279 <   < 186 <   < 372 <   < 279 <   < 248 < 
18 km/h  < 229 <   < 152 <   < 305 <   < 229 <   < 203 < 

Vete
Wheat
Weizen
Blé

0,79 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 510 <   < 340 <   < 679 <   < 510 <   < 453 < 
9 km/h  < 338 <   < 225 <   < 451 <   < 338 <   < 300 < 
12 km/h  < 254 <   < 169 <   < 339 <   < 254 <   < 226 < 
15 km/h  < 195 <   < 130 <   < 260 <   < 195 <   < 174 < 
18 km/h  < 166 <   < 111 <   < 221 <   < 166 <   < 147 < 

Korn
Barley
Gerste
Orge

0,74 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 400 <   < 266 <   < 533 <   < 400 <   < 355 < 
9 km/h  < 308 <   < 205 <   < 410 <   < 308 <   < 273 < 
12 km/h  < 208 <   < 138 <   < 277 <   < 208 <   < 185 < 
15 km/h  < 197 <   < 131 <   < 262 <   < 197 <   < 175 < 
18 km/h  < 162 <   < 108 <   < 216 <   < 162 <   < 144 < 

Havre
Oats
Hafer
Avoine

0,63 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 421 <   < 281 <   < 561 <   < 421 <   < 374 < 
9 km/h  < 257 <   < 172 <   < 343 <   < 257 <   < 229 < 
12 km/h  < 197 <   < 131 <   < 262 <   < 197 <   < 175 < 
15 km/h  < 147 <   < 98 <   < 196 <   < 147 <   < 131 < 
18 km/h  < 139 <   < 92 <   < 185 <   < 139 <   < 123 < 

12.01.2011
ver.1.0 107
Appendices

Bönor
Beans
Bohnen
Féves

0,85 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 569 <   < 379 <   < 758 <   < 569 <   < 506 < 
9 km/h  < 377 <   < 251 <   < 503 <   < 377 <   < 335 < 
12 km/h  < 281 <   < 187 <   < 375 <   < 281 <   < 250 < 
15 km/h  < 223 <   < 149 <   < 298 <   < 223 <   < 198 < 
18 km/h  < 184 <   < 123 <   < 245 <   < 184 <   < 163 < 

Ärtor
Peas
Erbsen
Pois

0,84 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 536 <   < 357 <   < 714 <   < 536 <   < 476 < 
9 km/h  < 383 <   < 255 <   < 511 <   < 383 <   < 341 < 
12 km/h  < 282 <   < 188 <   < 376 <   < 282 <   < 251 < 
15 km/h  < 223 <   < 149 <   < 297 <   < 223 <   < 198 < 
18 km/h  < 191 <   < 127 <   < 255 <   < 191 <   < 170 < 

Raps
Rape
Raps
Colza

0,65 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 18 <   < 12 <   < 24 <   < 18 <   < 16 < 
9 km/h  < 11 <   < 7,3 <   < 15 <   < 11 <   < 9,8 < 
12 km/h  < 8,5 <   < 5,6 <   < 11 <   < 8,5 <   < 7,5 < 
15 km/h  < 6,9 <   < 4,6 <   < 9,2 <   < 6,9 <   < 6,2 < 
18 km/h  < 5,5 <   < 3,7 <   < 7,4 <   < 5,5 <   < 4,9 < 

Lin
Flax
Flachs
Lin

0,74 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 146 <   < 97 <   < 195 <   < 146 <   < 130 < 
9 km/h  < 98 <   < 65 <   < 131 <   < 98 <   < 87 < 
12 km/h  < 74 <   < 49 <   < 98 <   < 74 <   < 66 < 
15 km/h  < 59 <   < 39 <   < 79 <   < 59 <   < 52 < 
18 km/h  < 39 <   < 26 <   < 53 <   < 39 <   < 35 < 

Gräs
Grass
Gras
Ray-grass

0,31 kg/l

ST 400 ST 600 ST 600 XL ST 800 ST 900


Kg / ha Kg / ha Kg / ha Kg / ha Kg / ha

6 km/h  < 46 <   < 31 <   < 61 <   < 46 <   < 41 < 
9 km/h  < 31 <   < 21 <   < 42 <   < 31 <   < 28 < 
12 km/h  < 24 <   < 16 <   < 31 <   < 24 <   < 21 < 
15 km/h  < 19 <   < 13 <   < 26 <   < 19 <   < 17 < 
18 km/h  < 16 <   < 11 <   < 22 <   < 16 <   < 14 < 

108 12.01.2011
ver. 1.0
ST 400-900S

7.2 Hydraulic system schematic diagram


7.2.1 Hydraulic system schematic diagram, ST 400

Q
S

Figure 7.1 492552, ST 400

12.01.2011
ver.1.0 109
Appendices

Hydraulic system schematic diagram, ST 400

Table 7.1
C1 Ram (Memory ram); Master and slave system for System Disc
C2 Ram; Master and slave system for System Disc
C3 Ram; Master and slave system for System Disc
C4 Ram, left-hand bout marker
C5 Ram, right-hand bout marker
C6 Ram; pre-emergence bout marker
C7 Ram; Master and slave system for drilling units, wing section
C8 Ram; Master and slave system for drilling units, centre section
C9 Ram; Master and slave system for drilling units, centre section
C10 Ram; Master and slave system for drilling units, wing section
C11 Ram; folding and weight transfer
C12 Ram; Crossboard
C13 Ram; Crossboard
C14 Ram; Crossboard
B1 Valve block; seed coulter pressure and wing folding
B3 Valve block; lift stop, bout markers, pre-emergence bout marker
B4 Valve block; System Disc
B5 Pilot controlled non-return valv; System Disc
A Solenoid valve, left-hand bout marker
A14 Accumulator
B Solenoid valve, right-hand bout marker
C Solenoid valve; System Disc lift stop
D Solenoid valve; pre-emergence bout marker
F Solenoid valve; drilling units lift stop
G Regulator valve; seed coulter pressure
G1 Manometer; seed coulter pressure
H Pilot controlled non-return valve; seed coulter pressure locking
L Solenoid valve; mechanical bypass of wing locking
M Non-return valve; wing folding bypass
N Cock; blocking seed drilling units in raised position
O Pilot controlled non-return valve; seed coulter transport lock
P Pilot controlled non-return valve; System Disc and bout markers transport lock
Q Fan
R Cock for weight transfer pressure adjustment
S Hydraulic motor; fan
V1 Changeover valve; System Disc, wing folding
V18 Changeover valve: wing folding/Crossboard

110 12.01.2011
ver. 1.0
ST 400-900S

7.2.2 Hydraulic system schematic diagram, ST 600

Q
S

Figure 7.2 492553, ST 600

12.01.2011
ver.1.0 111
Appendices

Hydraulic system schematic diagram, ST 600

Table 7.2
C1 Ram (Memory ram); Master and slave system for System Disc
C2 Ram; Master and slave system for System Disc
C3 Ram; Master and slave system for System Disc
C4 Ram, left-hand bout marker
C5 Ram, right-hand bout marker
C6 Ram; pre-emergence bout marker
C7 Ram; Master and slave system for drilling units, wing section
C8 Ram; Master and slave system for drilling units, centre section
C9 Ram; Master and slave system for drilling units, centre section
C10 Ram; Master and slave system for drilling units, wing section
C11 Ram; folding and weight transfer
C12 Ram; Crossboard
C13 Ram; Crossboard
C14 Ram; Crossboard
B1 Valve block; seed coulter pressure and wing folding
B3 Valve block; lift stop, bout markers, pre-emergence bout marker
B4 Valve block; System Disc
B5 Pilot controlled non-return valvek; System Disc
A Solenoid valve, left-hand bout marker
A14 Accumulator
B Solenoid valve, right-hand bout marker
C Solenoid valve; System Disc lift stop
D Solenoid valve; pre-emergence bout marker
F Solenoid valve; drilling units lift stop
G Regulator valve; seed coulter pressure
G1 Manometer; seed coulter pressure
G2 Manometer; weight transfer pressure
H Pilot controlled non-return valve; seed coulter pressure locking
L Solenoid valve; mechanical bypass of wing locking
M Non-return valve; wing folding bypass
N Cock; blocking seed drilling units in raised position
O Pilot controlled non-return valve; seed coulter transport lock
P Pilot controlled non-return valve; System Disc and bout markers transport lock
Q Fan
R Cock for weight transfer pressure adjustment
S Hydraulic motor; fan
V1 Changeover valve; System Disc, wing folding
V18 Changeover valve: wing folding/Crossboard

112 12.01.2011
ver. 1.0
ST 400-900S

7.2.3 Hydraulic system schematic diagram, ST 800-900

Q
S

Figure 7.3 492554, ST 800-900

12.01.2011
ver.1.0 113
Appendices

Hydraulic system schematic diagram, ST 800-900

Table 7.3
C1 Ram (Memory ram); Master and slave system for System Disc
C2 Ram; Master and slave system for System Disc
C3 Ram; Master and slave system for System Disc
C4 Ram, left-hand bout marker (ST 800)
C5 Ram, right-hand bout marker (ST 800)
C6 Ram; pre-emergence bout marker
C7 Ram; Master and slave system for drilling units, wing section
C8 Ram; Master and slave system for drilling units, centre section
C9 Ram; Master and slave system for drilling units, centre section
C10 Ram; Master and slave system for drilling units, wing section
C15 Ram; Master and slave system for drilling units, wing section
C16 Ram; Master and slave system for drilling units, wing section
C11 Ram; folding and weight transfer
C17 Ram; folding and weight transfer
C12 Ram; Crossboard
C13 Ram; Crossboard
C14 Ram; Crossboard
B1 Valve block; seed coulter pressure and wing folding
B3 Valve block; lift stop, bout markers, pre-emergence bout marker
B4 Valve block; System Disc
B5 Pilot controlled non-return valve; System Disc
A Solenoid valve, left-hand bout marker
A14 Accumulator
B Solenoid valve, right-hand bout marker
C Solenoid valve; System Disc lift stop
D Solenoid valve; pre-emergence bout marker
F Solenoid valve; drilling units lift stop
G Regulator valve; seed coulter pressure
G1 Manometer; seed coulter pressure
G2 Manometer; weight transfer pressure
H Pilot controlled non-return valve; seed coulter pressure locking
L Solenoid valve; mechanical bypass of wing locking
M Non-return valve; wing folding bypass
N Cock; blocking seed drilling units in raised position
O Pilot controlled non-return valve; seed coulter transport lock
P Pilot controlled non-return valve; System Disc and bout markers transport lock
Q Fan
R Cock for weight transfer pressure adjustment
S Hydraulic motor; fan
V1 Changeover valve; System Disc, wing folding
V18 Changeover valve: wing folding/Crossboard

114 12.01.2011
ver. 1.0
ST 400-900S

7.3 Electrical system


7.3.1 Work Station connections

Table 7.4
Work Station Function Hydraulic block
connection connection
WS6-1 Level guard, right (ST 600S XL, ST 800-900S)
WS6-2 Level guard (left ST 600S XL, ST 800-900S)
WS6-3 Rotation guard, right seed housing (ST 600S XL, ST 800-900S)
WS6-4 Rotation guard, seed housing (left ST 600S XL, ST 800-900S)
WS6-5 Rotation counter, seed rate fan
WS6-6 Radar
WS6-8 Rotation guard BioDrill
WS6-9 Mini-remote, plus button
WS6-10 Low-lift sensor, drilling units
WS6-11 Low-lift sensor, pre-implement
WS6-13 Lift stop, pre-implement C
WS6-14 Lift stop, seed drilling units F
WS6-15 Pre-emergence bout marker D
WS6-16 Tramlining, right
WS6-17 Tramlining, left
WS6-20 Bout marker, right-hand B
WS6-21 Bout marker, left-hand A
WS6-22 Wing locking valve L
WS6-23 Mini-remote, ax button
WS6-24 Level guard BioDrill
WS6-25 Wing folding sensor, left-hand side
WS6-M1 Electric motor seed feed (left ST 600S XL, ST 800-900S)
WS6-M2 Electric motor right seed feed (ST 600S XL, ST 800-900S)
WS6-M3 Electric motor seed feed BioDrill

12.01.2011
ver.1.0 115
Appendices

7.3.2 Level guards; capacitive sensors

A B

Figure 7.4

Table 7.5
Work Station Ter- Wire Ter- Function Material Material
connection mi- colour mi- detected not detect-
nal nal ed
(A) (B)
WS6-1 1 Black 1 Matter detected = Ground, LED Max 1 V Min. 8 V
WS6-2 lights
WS6-24 2 White 2 Matter not detected = Ground Min. 8 V Max 1 V
3 Brown 3 12 V
4 Blue 4 0V

7.3.3 Rotation guards; inductive sensors

A B
Figure 7.5

Table 7.6
Work Station Ter- Wire Ter- Function Metal de- Metal not
connection mi- col- mi- tected detected
nal our nal
(A) (B)
WS6-3 1 Black 1 Metal detected = Ground, LED Max 1 V Min. 8 V
WS6-4 lights
WS6-5 2
WS6-8
3 Brown 2 12 V
4 Blue 3 0V

116 12.01.2011
ver. 1.0
ST 400-900S

7.3.4 Wing folding; inductive sensors

A B
Figure 7.6

Tabell 7.7
Work Station Ter- Wire Ter- Function Metal de- Metal not
connection mi- col- mi- tected detected
nal our nal
(A) (B)
WS6-25 1 Black 1 Metal detected = Ground, LED lights Max 1 V Min. 8 V
2
3 Brown 2 12 V
4 Blue 3 0V

7.3.5 Tramline valves and intermediate wiring


2 4 1 3 2 4

3 1 4 2 3 1

A A B

Figure 7.7

Table 7.8
Work Station Terminal Wire Tramlining
connection (A) colour
WS6-16 1 Black 12 V to R1, R3
2 White 12 V to R2, R4
3 Brown
4 Blue 0V

Table 7.9
Work Station Terminal Wire Tramlining
connection (A) colour
WS6-17 1 Black 12 V to L1, L3
2 White 12 V to L2, L4
3 Brown
4 Blue 0V

Table 7.10
Work Station Terminal Wire Tramlining
connection (B) colour
WS6-16 1
WS6-17 2 Brown 12 V - Valve closed 0 V - Valve open
3
4 Blue 0V

12.01.2011
ver.1.0 117
Appendices

7.3.6 Low-lift sensor

2 4 5 3

3 1 4 1
A B C

Figure 7.8

Table 7.11
Work Station Ter- Wire Ter- Function Wire Ter- Function
connection minal colour minal (A, B) colour (B) minal (C)
(A) (A) (B) (C)
WS6-10 1 Black 5 Signal Black 2, 4 Signal
WS6-11 2
3 Brown 1 12 V Brown 3 Feed (not 12 V)
4 Blue 2 0V Blue 1 0V

7.3.7 Hydraulic solenoid valves

A B

Figure 7.9

Table 7.12
Work Station Terminal Wire Terminal Function
connection (A) colour (B)
WS6-13 1
WS6-14 2 Brown 1 Feed to valve, 12 V, red lamp lights
WS6-15
WS6-20 3
WS6-21 4 Blue 2 0V
WS6-22

118 12.01.2011
ver. 1.0
ST 400-900S

7.3.8 Intermediate cable.

Figure 7.10

Table 7.13
Pole Wire colour Function
1 Blue 0V
2 Yellow CAN LO (communication)
3 Brown 12 V
Green CAN HI (communication)

7.3.9 Radar

A B C

Figure 7.11

Table 7.14
Work Station Terminal Wire Terminal Function Wire colour
connection (A) col- (B) terminal
our (C)
WS6-6 1 Black 1 Pulses per metre, pulse = ground signal Green
2
3 Brown 2 12 V Red
4 Blue 3 0V Black

12.01.2011
ver.1.0 119
Appendices

7.3.10 Mini-remote

A B
WS6-23

WS6-9

Figure 7.12

Table 7.15
Work Station Ter- Wire Function
connection minal colour
WS6-9 1 Black Feed measurement when button B pressed
(connection between pin 1 and pin 4 in WS6-9)
4 Blue 0V

Table 7.16
Work Station Ter- Wire Function
connection minal colour
WS6-23 1 Brown Feed measurement for calibration when button A pressed
(connection between pin 1 in WS6-23 and pin 4 in WS6-9)

7.3.11 Power cable

A D

1 2
B B C
A

Figure 7.13

Table 7.17
Connector (1) Connector (2) Cable Function
colour
A A+D Red +12V
B B+C Black 0V

120 12.01.2011
ver. 1.0
ST 400-900S

7.3.12 Power cabling on tractor

B 1
A 2

Figure 7.14

Table 7.18
Connector (1) Connector (2) Cable Function
colour
A Circuit breaker Red +12V
B Black 0V

7.3.13 Motor cable


PE 6 PE 2
1 6
2 5 5 1

3 4 4 3
A B

A B

Figure 7.15

Table 7.19
Cable Function
1 Motor -
2 Motor +
3 Sensor 0V
4 Sensor 5V
5 Sensor A
6 Sensor B
PE Not connected

NOTE!The motor cable can be turned, and it is important to make sure that this cable is rotated
the right way round so as to ensure that the motor runs in the right direction. Connector A must be
connected to the WorkStation, and connector B must be mounted in the feed system motor. Al-
ways check the direction of rotation after replacing parts.

12.01.2011
ver.1.0 121
Appendices

7.3.14 Lighting connector

Figure 7.16

Table 7.20
Pos. DIN Cable colour Function
1 L Yellow Flashers, left
2 54G
3 31 White Earth
4 R Green Flashers, right
5 58R Brown Tail light, right
6 54 Red Brake light
7 58L Black Tail light, left

122 12.01.2011
ver. 1.0
ST 400-900S

7.4 Technical data

Table 7.21
Machine ST 400 ST 600 ST 600S XL ST 800 ST 900
Work width (m) 4,0 6,0 6,0 8,0 9,0
Transport width (m) 3,0 3,0 3,0 3,0 3,0
Transport height (m) 2,65 2,8 2,9 3,9 4,0**
Length (m) 7,85 7,85 7,85 7,85 7,85
Total volume, seed hopper, (litres) 3740 3150 3900 3900 3900
Tare weight of the basic machine (kg)* 5400 6700 6800 8550 9200
Maximum total weight (kg) 8400 9500 9600 11500 12200
Maximum permitted payload (kg) 2500 2500 2500 2500 2500
Maximum permitted axle loading (kg) 7000 8000 8000 9500 10500
Maximum coupling load (at the tractor 2000 2000 2000 2000 2000
hitch) (kg)
Power requirement CB Heavy, approx. 100-120 140-170 140-170 180-220 200-240
(hp)
Power requirement SD Aggressive + 140-170 200-250 200-250 250-320 270-350
CB, approx. (hp)

* including System Disc, following harrow and bout marker


** excluding bout markers and spill prevention plates
Fan
Noise level: 92 dB(A) (at a distance of 1 m)
Tyre inflation pressure

4,5 kg/cm2 (450 kPa) 2,5 kg/cm2 (250 kPa)

Figure 7.17

12.01.2011
ver.1.0 123
Appendices

124 12.01.2011
ver. 1.0
590 21 VÄDERSTAD S-590 21 VÄDERSTAD
SWEDEN

Telefon 0142-820 00 Telephone +46 142 820 00


Telefax 0142-820 10 Telefax +46 142 820 10
www.vaderstad.com

You might also like