fuses first. Lamp type Gasoline Diesel models (12V – Always replace fuses with fuses of the Meter panel lamp 3W (14V) 3W correct amperage. – If fuse burns out immediately and you Tail/Stop lamp 8W/23W 10W/2 cannot locate the cause, have your Cat Headlamp 45W 60W lift truck dealer make a circuit check. Check the fuses one by one by Turn signal lamp 27W 25W – Use a replacement light bulb of the operating the light switch and seeing if same wattage. each light comes on. Back-up lamp 10W 12W Working lamp (opt) 45W 60W Lights are suspected Gasoline models Diesel models A to have burned out. Code Capa Capa B Circuit Circuit city city C 10 15 A 10A Direction lever 10A Direction lever D 15
B 15A Instrument panel 10A Instrument panel E
15
(for monitor and (for monitor and 15
gauge), backup, gauge), turn F
10
stop and turn signal lights (opt)
10 G 15 signal (opt) lights, One light of the circuit fai H 10 ECU (for T/M controller, J
C frequency 102535A All lights of the circuit fai
transducer) D 15A Spare power 10A Spare power source source Puller 15A Instrument panel 15A Instrument panel (for panel light), (for panel light), Check to see if fuse has been tail and working head, tail and (opt) lights working (opt) lights E 15A Head lights 10A Horn F 10A ECM for engine 10A Spare fuse G 10A Horn 10A Stop lights, ECU (for T/M controller) 101442 H 15A Fuel pump 10A Backup lights To remove the fuse or insert a replacement J 10A Starter 15A Spare fuse fuse, use the puller found in the fuse panel lid.