Professional Documents
Culture Documents
Screening test-CE(anurag)
Screening test-CE(anurag)
(a) wL3/6EI
(b) wL3/3EI
(c) wL4/8EI
(d) wL3/2EI
4. A two span beam with an internal hinge is shown below. The conjugate beam
corresponding to this beam is________
(a)
(b)
(c)
(d)
5. For determining the force in the member AB of the truss shown in the given figure by
method of sections, the section is made to pass through AB, AD and ED and the
moments are taken about ______________________
(a) Joint C
(b) Joint B
(c) Joint D
(d) Joint A
(a)0.85 bd/fy
(b)0.87 fy/bd
(c)0.04 bd
(d)0.4 bd/y
7. The performance of a specific task in CPM, is known_______________
(a) Dummy
(b) Event
(c) Activity
(d) Contract.
8. Pick up the correct proportions of chemical ingredients of cement____________
9. Consolidation in soils_____
(a)35%
(b)50%
(c)65%
(d)none of these.
11. The group efficiency of a pile group__________
(a)Circular
(b)Elliptical
(c)Parabolic
(d)A straight line
13. Pick up the correct statement from the following:
(a)Wind
(b)water
(c)Glacier
(d)Gravitational force.
15. A pitot tube is used to measure___________
(a)Pressure
(b)Difference in pressure
(c)Velocity of flow
(d)None of these.
16. For the flow of liquid from an open ended tube (or nozzle) leading to the formation of
spray of liquid drops, the number generally applied, is________
17. The flow in open channel is said to be subcritical if the Froude number is_______
(a) 2 cm
(b) 3 cm
(c) 4 cm
(d) 5 cm.
20. The peak discharge of the instantaneous unit hydrograph of a basin, when compared
to the peak discharge of a 4-hour unit hydrograph of that basin, would
be_____________
(a)Greater
(b)Equal
(c)Equal or lesser
(d)Lesser
21. The rate of accumulation of sludge in septic tanks is recommended as__________
(a) 30 litres/person/year
(b) 25 litres/person/year
(c) 30 litres/person/month
(d) 25 litres/person/month
22. If 2% solution of a sewage sample is incubated for 5 days at 20°C and depletion of
oxygen was found to be 5 ppm, B.O.D. of the sewage is_______
(a) 200 ppm
(b) 225 ppm
(c) 250 ppm
(d) None of these.
23. Assertion (A) : Discharging the effluents from the oxidation ponds just up stream of
lakes or reservoirs is undesirable.
Reason (R) : The discharged algae get settled in the reservoirs and cause anaerobic
decomposition and other water qualities.
24. For the survival of fish in a river stream, the minimum dissolved oxygen is
prescribed______________
(a) 3 PPm
(b) 4 PPm
(c) 5 PPm
(d) 10 ppm
25. Generally, first portion of a logistic curve for the population growth of a developing
city, represents the growth of___________________________
(a)Increasing
(b)Decreasing
(c)Constant
(d)all the above.
26. Biochemical Oxygen Demand (B.O.D.) of safe drinking water must be_____
(a)nil
(b)5
(c)10
(d)15
(e)20
27. A district road with a bituminous pavement has a horizontal curve of 1000 m for a
design speed of 75 km ph. The super-elevation is________
(a)1 in 40
(b)1 in 50
(c)1 in 60
(d)1 in 70
28. The total length of a valley formed by two gradients - 3% and + 2% curve between
the two tangent points to provide a rate of change of centrifugal acceleration 0.6
m/sec2, for a design speed 100 km ph, is_________
(a) 16.0 m
(b) 42.3 m
(c) 84.6 m
(d) None of these.
29. In an ideal transition curve, the radius of curvature___________
(a) is constant
(b) at any point is directly proportional to its distance from the point of commencement
(c) is inversely proportional to the radius of main curve
(d) is directly proportional to the radius of main curve
30. The reaction time for calculation of stopping distance may be assumed as_____
(a) 5 secs
(b) 2.5 secs
(c) 0.5 secs
(d) 10.0 secs
31. Speed regulations on roads is decided on the basis of__________
(a) Foresight (b) intermediate sight (c) back-sight (d) any sight.
34. The combined effect of curvature and refraction over a distance L kilometres
is___________
36. The distance between the point of intersection of an up grade + g1% and
downgrade g2% and the highest point of the vertical curve of length L, is______
37. What is the name of the conceptual framework in which the research is carried out?
38. Who was the author of the book named "Methods in Social Research"?
(a) Kerlinger
(b) CR Kothari
(c) Goode and Hatt
(d) Wilkinson
39. The conceptual framework and background of research which will become the source
for formulation of the hypothesis is known as___________
(a) Methodology
(b) Review of literature
(c) Data analysis
(d) None of the above
40. The act of presenting someone else’s work or idea as own is considered as
(a) Plagiarism
(b) Academic dishonesty
(c) Wrongful appropriation
(d) All of these