Professional Documents
Culture Documents
SBWA920_SM_PANASONIC_EN
SBWA920_SM_PANASONIC_EN
SBWA920_SM_PANASONIC_EN
MD0403057C1
A6
SPECIFICATIONS
Specification
1
Active subwoofer
Type 1 way, 1 speaker system (Bass
reflex)
Speaker unit Impedance 4
Woofer 20 cm (7-7/8”) Cone type
Output sound pressure 84 dB/W (1.0 m)
Frequency range 34 Hz-220 Hz (-16 dB)
38 Hz-190 Hz (-10 dB)
Dimensions (W x H x D) 285 x 418 x 475 mm
(11-7/32” x 16-15/32” x 18-11/16”)
Mass 15 kg (33 lb.)
General
Power consumption 390V
Power supply AC 120V, 60Hz
Note :
Specifications are subject to change without notice.
Mass and dimensions are approximate.
SB-HT920P-S consists of :
SB-PF920P-S x 2, SB-PS920P-S x 2 and SB-PC920P-S x 1
1. Safety Precautions
1.1. GENERAL GUIDELINES
1. When servicing, observe the original lead dress. If a short circuit
is found, replace all parts which have been overheated or
damaged by the short circuit.
2
2. After servicing, see to it that all the protective devices such as
insulation barriers, insulation papers shields are properly installed.
3. After servicing, make the following leakage current checks to
prevent the customer from being exposed to shock hazards.
(This “Safety Precaution” is applied only in U.S.A.)
reading must be .
Fig. 1
3
1.1.2. LEAKAGE CURRENT HOT CHECK (See Figure 1.)
1. Plug the AC cord directly into the AC outlet. Do not use an
isolation transformer for this check.
2. Connect a 1.5k , 10 watts resistor, in parallel with a 0.15 F
capacitors, between each exposed metallic part on the set and a
good earth ground such as a water pipe, as shown in Figure 1.
3. Use an AC voltmeter, with 1000 ohms/volt or more sensitivity, to
measure the potential across the resistor.
4. Check each exposed metallic part, and measure the voltage at
each point.
5. Reverse the AC plug in the AC outlet and repeat each of the above
measurements.
6. The potential at any point should not exceed 0.75 volts RMS. A
leakage current tester (Simpson Model 229 or equivalent) may be
used to make the hot checks, leakage current must not exceed 1/2
milliamp. In case a measurement is outside of the limits specified,
there is a possibility of a shock hazard, and the equipment should
be repaired and rechecked before it is returned to the customer.
4
, 1 W resistor to ground.
DO NOT SHORT-CIRCUIT DIRECTLY (with a screwdriver blade, for instance), as this may destroy
solid state devices.
After repairs are completed, restore power gradually using a variac, to avoid overcurrent.
Current consumption at AC 120V, 60Hz in NO SIGNAL mode should be ~1000 mA .
4. Protection Circuitry
The protection circuitry may have operated if either of the following conditions are noticed:
- No sound is heard when the power is turned on.
- Sound stops during a performance.
The function of this circuitry is to prevent circuitry damage if, for example, the positive and
negative speaker connection wires are
“shorted”, or if speaker systems with an impedance less than the indicated rated impedance of
the amplifier are used.
If this occurs, follow the procedure outlines below:
5
Notes :
- To prevent damage to circuitry, never short-circuit positive (+) and
negative (-) speaker wires.
- Be sure to connect only positive (Copper) wires to positive (+)
terminals and negative (Silver) wires to negative (-) terminals.
6. Disassembly Procedure
“ATTENTION SERVICER”
Contents
6
- Disassembly of the Speaker Unit
- Main Component Replacement Procedures
6.1. Disassembly flow chart
The following chart is the procedure for disassembling the casing and inside parts for internal
inspection when carrying out the servicing.
To assemble the unit, reverse the steps shown in the chart below.
7
Step 1: Remove all the screws.
Step 2: Remove the stand base.
Steps 3 & 4: Remove all the screws from the bottom of the speaker unit.
Step 5: Use the Steel Ruler to slot into the hole of the bottom cabinet of speaker.
8
Step 6: Use the Wood Chip to slot between the Net Frame and the Steel Ruler as arrow shown.
Step 7: Use the Screwdriver slightly lift up the Net Frame as arrow shown.
Step 8: Take note of the bosses which glued to the unit .
- Assembly of Net Frame.
9
Clean up all the glue at the 4 Boss points and replace with the normal glue.
10
Step 10: Remove all the screws from the subwoofer.
Step 13: Pull out the Power Amp unit slightly as shown.
11
Step 14: Release the connector CN506 then pull out the entire Power Amp unit.
Step 16: Release the connector CN507 to remove the rear panel.
Step 17: Remove all the screws.
12
Step 19: Remove all the screws.
Step 20: Detach the connector CN503 and remove the transformer.
- Checking for the Transformer, Amplifier and AC Inlet P.C.B.
Step 21: Place the Transformer P.C.B., Amplifier P.C.B. and the AC Inlet P.C.B. as shown for
checking.
13
Steps 22: Release the AC Inlet P.C.B. as arrow shown.
- Checking for the Power and CD Open P.C.B.
Step 23: Place the Power P.C.B. and the CD Open P.C.B. as shown for checking.
14
Steps 2 & 3: Remove the screws.
Step 4: Replacement of the Power IC601 and Transistors (Q601 & Q602).
15
Step 8: Replacement of the Power IC501 and Transistors (Q511 & Q512).
8. Block Diagram
9. Schematic Diagram
(All schematic diagrams may be modified at any time with the development of the new
technology)
Note:
- The voltage value and waveforms are the reference voltage of this
unit measured by DC electronic voltmeter (high impedance) and
oscilloscope on the basis of chassis. Accordingly, there may arise
some error in voltage values and waveforms depending upon the
internal impedance of the tester or the measuring unit.
- Importance safety notice :
Components identified by mark have special characteristics
important for safety. Furthermore, special parts which have
purposes of fire-retardant (resistors), high-quality sound
(capacitors), low-noise (resistors), etc. are used. When replacing
any of components, be sure to use only manufacturer's specified
parts shown in the parts list.
Caution !
IC, LSI and VLSI are sensitive to static electricity.
Secondary trouble can be prevented by taking care during repair.
- Cover the parts boxes made of plastics with aluminium foil.
16
- Put a conductive mat on the work table.
- Ground the soldering iron.
- Do not touch the pins of IC, LSI or VLSI with fingers directly.
17
otherwise, P= Pico-farads (pF), F= Farads.
- Resistance values are in ohms, unless specified otherwise, 1K=
1,000 (OHM).
- The marking (RTL) indicates that the Retention Time is limited for
this items. After the discontinuation of this assembly in
production, the item will continue to be available for a specific
period of time. The retention period of a availability is dependent
on the type of assembly, and in accordance with the laws
governing part and product retention. After the end of this period,
the assembly will no longer be available.
- [M] Markings in the Remarks columns indicates parts supplied by
PAVCSG.
13.1. Cabinet
13.1.1. Cabinet Parts Location
18
13.1.2. Cabinet Parts List
19
Ref. No. Part No. Part Name & Description Remarks
CABINET AND CHASSIS
REPX0436A POWER P.C.B./ AC INLET P.C.B./ TRANSFORMER P.C.B./ LED P.C.B. [M] (RTL)
REPX0435A AMPLIFIER P.C.B./ SPEAKER INTERFACE P.C.B. [M] (RTL)
INTEGRATED CIRCUITS
TRANSISTORS
20
Ref. No. Part No. Part Name & Description Remarks
Q516 KRC102MTA TRANSISTOR [M]
Q517 B1BACG000009 TRANSISTOR [M]
Q519 KTC3199GRTA TRANSISTOR [M]
Q520 B1GCCFJJ0015 TRANSISTOR [M]
Q552 B1ACCF000063 TRANSISTOR [M]
Q553 2SD0592ARA TRANSISTOR [M]
Q554 B1ACCF000063 TRANSISTOR [M]
Q555 2SD0592ARA TRANSISTOR [M]
Q556 B1ACCF000063 TRANSISTOR [M]
Q557 2SD0592ARA TRANSISTOR [M]
Q601 B1BACG000009 TRANSISTOR [M]
Q602 B1BCCG000021 TRANSISTOR [M]
Q603 2SD1859QRTV2 TRANSISTOR [M]
DIODES
21
Ref. No. Part No. Part Name & Description Remarks
CONNECTORS
COMPONENT COMBINATION
SPEAKER
RELAY
FUSE
F1 K5D602AQ0002 FUSE
[M]
FUSE HOLDERS
FUSE PROTECTOR
HOLDERS
22
H601 K1YF10000006 10P WIRE HOLDER [M]
23
Ref. No. Part No. Part Name & Description Remarks
H602 RJS1A5508 WIRE HOLDER [M]
H603 K1YF04000001 CABLE HOLDER [M]
H604 K1YF04000001 CABLE HOLDER [M]
H605 RJS1A5503 CABLE HOLDER [M]
JACKS
EARTH TERMINALS
WIRES
RESISTORS
24
R529 ERDS2TJ223T 22K 1/4W [M]
25
Ref. No. Part No. Part Name & Description Remarks
R530 ERD25FVJ1R0T 1 1/4W [M]
R531 ERD25FVJ1R0T 1 1/4W [M]
R532 ERDS2TJ472T 4.7K 1/4W [M]
R533 ERDS1FVJ100T 10 1/2W [M]
R534 ERDS1FVJ100T 10 1/2W [M]
R537 ERDS1FVJ100T 10 1/2W [M]
R538 ERDS1FVJ100T 10 1/2W [M]
R539 ERDS2TJ101T 100 1/4W [M]
R540 ERDS2TJ101T 100 1/4W [M]
R541 ERDS2TJ101T 100 1/4W [M]
R542 ERDS2TJ101T 100 1/4W [M]
R543 ERDS2TJ101T 100 1/4W [M]
R544 ERDS2TJ101T 100 1/4W [M]
R545 ERDS2TJ224T 220K 1/4W [M]
R546 ERDS2TJ102T 1K 1/4W [M]
R547 ERDS2TJ394T 390K 1/4W [M]
R548 ERDS2TJ334T 330K 1/4W [M]
R549 ERDS2TJ392T 3.9K 1/4W [M]
R550 ERDS2TJ103T 10K 1/4W [M]
R551 ERDS2TJ103T 10K 1/4W [M]
R558 ERDS2TJ104T 100K 1/4W [M]
R559 ERDS2TJ103T 10K 1/4W [M]
R560 ERDS2TJ151T 150 1/4W [M]
R561 ERDS1FVJ392T 3.9K 1/2W [M]
R562 ERDS2TJ472T 4.7K 1/4W [M]
R563 ERDS1FVJ102T 1K 1/2W [M]
R564 ERDS2TJ224T 220K 1/4W [M]
R565 ERDS1FVJ392T 3.9K 1/2W [M]
R566 ERG2SJ220E 22 2W [M]
R567 ERDS1FVJ152T 1.5K 1/2W [M]
R568 ERDS2TJ151T 150 1/4W [M]
R569 ERDS1FVJ392T 3.9K 1/2W [M]
R570 ERDS2TJ103T 10K 1/4W [M]
R571 ERDS2TJ332T 3.3K 1/4W [M]
R572 ERDS2TJ223T 22K 1/4W [M]
R573 D0XGR10JA005 0.1 1/10W [M]
R575 ERDS2TJ682T 6.8K 1/4W [M]
R577 ERDS2TJ152T 1.5K 1/4W [M]
R578 ERDS2TJ103T 10K 1/4W [M]
R579 ERDS2TJ332T 3.3K 1/4W [M]
R580 ERDS2TJ220T 22 1/4W [M]
R581 ERDS2TJ682T 6.8K 1/4W [M]
R582 ERDS2TJ224T 220K 1/4W [M]
R583 ERDS2TJ101T 100 1/4W [M]
R584 ERDS2TJ473T 47K 1/4W [M]
R587 ERDS2TJ272T 2.7K 1/4W [M]
R588 ERDS2TJ151T 150 1/4W [M]
R589 ERDS2TJ103T 10K 1/4W [M]
R590 ERDS2TJ102T 1K 1/4W [M]
R591 ERDS2TJ682T 6.8K 1/4W [M]
R592 ERDS2TJ683T 68K 1/4W [M]
R593 ERDS2TJ474T 470K 1/4W [M]
R594 ERDS2TJ103T 10K 1/4W [M]
R595 ERDS2TJ101T 100 1/4W [M]
26
Ref. No. Part No. Part Name & Description Remarks
R596 ERDS2TJ473T 47K 1/4W [M]
R597 ERDS2TJ103T 10K 1/4W [M]
R598 ERDS1FVJ152T 1.5K 1/2W [M]
R599 ERDS2TJ223T 22K 1/4W [M]
R600 ERDS2TJ473T 47K 1/4W [M]
R601 ERDS2TJ473T 47K 1/4W [M]
R602 ERDS2TJ472T 4.7K 1/4W [M]
R603 ERDS2TJ103T 10K 1/4W [M]
R604 ERDS2TJ225T 2.2M 1/4W [M]
R605 ERG2SJ220E 22 2W [M]
R606 ERG2SJ220E 22 2W [M]
R607 ERG2SJ220E 22 2W [M]
R608 ERDS1FVJ152T 1.5K 1/2W [M]
R609 ERDS1FVJ152T 1.5K 1/2W [M]
R610 ERD2FCVJ4R7T 4.7 1/4W [M]
R611 ERD2FCVJ4R7T 4.7 1/4W [M]
R611 ERDS2TJ103T 10K 1/4W [M]
R612 ERD2FCVJ4R7T 4.7 1/4W [M]
R613 ERDS2TJ272T 2.7K 1/4W [M]
R614 ERDS2TJ272T 2.7K 1/4W [M]
R615 ERDS2TJ473T 47K 1/4W [M]
R616 ERDS2TJ472T 4.7K 1/4W [M]
R617 ERDS2TJ822T 8.2K 1/4W [M]
R618 ERDS2TJ473T 47K 1/4W [M]
R619 ERDS2TJ563T 56K 1/4W [M]
R620 ERDS2TJ563T 56K 1/4W [M]
R621 ERDS2TJ273T 27K 1/4W [M]
R622 ERDS2TJ103T 10K 1/4W [M]
R623 ERDS2TJ392T 3.9K 1/4W [M]
R624 ERDS2TJ392T 3.9K 1/4W [M]
R625 ERDS2TJ153T 15K 1/4W [M]
R626 ERDS2TJ153T 15K 1/4W [M]
R627 ERDS2TJ124T 120K 1/4W [M]
R628 ERDS2TJ154T 150K 1/4W [M]
R631 ERDS1FVJ100T 10 1/2W [M]
R632 ERDS1FVJ100T 10 1/2W [M]
R633 ERDS2TJ824T 820K 1/4W [M]
R634 ERDS2TJ473T 47K 1/4W [M]
R635 ERDS2TJ473T 47K 1/4W [M]
CAPACITORS
27
Ref. No. Part No. Part Name & Description Remarks
C516 ECKR2H103ZF5 0.01 500V [M]
C517 ECBT1C103NS5 0.01 16V [M]
C518 F1D1H473A012 0.047 50V [M]
C519 F1D1H473A012 0.047 50V [M]
C522 F1D1H473A012 0.047 50V [M]
C523 F1D1H473A012 0.047 50V [M]
C529 F1D1H1040002 0.1 50V [M]
C530 ECBT1H102KB5 1000P 50V [M]
C531 ECBT1H102KB5 1000P 50V [M]
C532 ECBT1H102KB5 1000P 50V [M]
C533 ECBT1H102KB5 1000P 50V [M]
C534 ECA1HM330B 33 50V [M]
C543 ECBT1H102KB5 1000P 50V [M]
C544 ECA1HM101B 100 50V [M]
C545 F1D1H1040002 0.1 50V [M]
C546 ECA1SM332B 3300 100V [M]
C547 ECA1SM472B 4700 100V [M]
C548 ECA1SM472B 4700 100V [M]
C549 ECA1SM332B 3300 100V [M]
C550 ECBT1C103NS5 0.01 16V [M]
C551 ECBT1H103KB5 0.01 50V [M]
C553 ECQE1104KF3 0.1 100V [M]
C554 ECQE1104KF3 0.1 100V [M]
C555 ECEA1VKA4R7B 4.7 35V [M]
C556 ECBT1H103KB5 0.01 50V [M]
C557 ECEA1AKA470B 47 10V [M]
C559 ECBT1H103KB5 0.01 50V [M]
C560 ECA1HM100B 10 50V [M]
C561 ECEA1HKA2R2B 2.2 50V [M]
C562 ECQB1H103JF3 0.01 50V [M]
C563 ECQV1H154JL3 0.15 50V [M]
C564 ECBT1C122KR5 1200P 16V [M]
C565 F1D1H1040002 0.1 50V [M]
C566 F1D1H1040002 0.1 50V [M]
C567 ECA1HM100B 10 50V [M]
C568 ECBT1C103NS5 0.01 16V [M]
C569 F1D1H473A012 0.047 50V [M]
C570 ECA1EM331B 330 25V [M]
C571 F2A1E1020065 1000P 25V [M]
C572 ECA1HM101B 100 50V [M]
C573 ECBT1H102KB5 1000P 50V [M]
C574 ECBT1H103KB5 0.01 50V [M]
C575 ECBT1H103KB5 0.01 50V [M]
C576 RCE1HKN100BG 10P 50V [M]
C577 ECEA1CKA100B 10 16V [M]
C578 ECBT1H103KB5 0.01 50V [M]
C579 ECBT1H103KB5 0.01 50V [M]
C580 ECEA1HKA2R2B 2.2 50V [M]
C601 ECA1SM332B 3300 100V [M]
C602 ECA1SM472B 4700 100V [M]
C603 ECA1SM472B 4700 100V [M]
C604 ECA1SM332B 3300 100V [M]
C605 ECQE1104KF3 0.1 100V [M]
C606 ECQE1104KF3 0.1 100V [M]
28
Ref. No. Part No. Part Name & Description Remarks
C607 ECBT1H180JC5 18P 50V [M]
C608 ECBT1H180JC5 18P 50V [M]
C609 ECKR2H103ZF5 0.01 500V [M]
C610 ECKR2H103ZF5 0.01 500V [M]
C611 ECBT1H102KB5 1000P 50V [M]
C612 ECBT1H102KB5 1000P 50V [M]
C613 ECKR1H103ZF5 0.01 50V [M]
C614 ECKR1H103ZF5 0.01 50V [M]
C615 F1D1H473A012 0.047 50V [M]
C616 F1D1H473A012 0.047 50V [M]
C619 F1D1H473A012 0.047 50V [M]
C647 ECA0JM471B 470 6.3V [M]
13.4. Packaging
29
FLE0403/P/A/S/E/N
30
A B C D E F G
1
POWER P.C.B. (REPX0436A)
2 CN501 J570
J607
J581 J539
J528
25
24
23
22
20
21
R543
CP502
19
TO MAIN UNIT E500
J507
J508
18
17 R544
J606
J591
16 J592
15 7 6 5 4 3 2 1
Q556
J571
R540
C550
14
C576
C647
13 D508 E C B
12
R539 R583
Q513
J572
11
10
9 R566 R605
3 B
J573
E C
8
7 R542 J504
R572
6 R541
5
4 J533 E C B
3 R607 R606 R5
C531
C530
2 Q514
R599
1
D56
C532 B B
C577
D559 D55
R522
R521
R545
D504
C529
R549
R547
D503
R548
C534
J517
J521
R537 J612 C533 C C
R581
J506
R571
J514
C568
E E
JK501 J60
Q505
Q506
6 C522 D558
J515
CENTRE J611 C549
SPEAKER 5
R534
J531
J538
C519
4
J565
J579
SURROUND RIGHT 3
SPEAKER J593
2
R533
J594
J552
C518 J595 C548
SURROUND LEFT
J577
1
R565
SPEAKER J574
J575 C547
J596
J608 CN507 J610
5 1
R593
J613
C561
J532
2 J537
D501
C563
J550 J511
R529
C566
J564
C545
1
R531
R573
J563
R611
J409
2 5 6 7 8
R530 J562
R519
C562
3
C513
IC502 J599
R597 J561
R538
R594
R596
R595
CN506 4 3 2 1
J576 C517
C515
C565 R592
D502
6 R403 C564 C569 J536
C505
C523 J597 J598
R591
IC501
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
9
G H I J K L M
PbF
FP1 5A
J582
J583
J584
C647
D562
J546
J545
J520
Q552 J548
J535
B
CN602
J547
R584
R603
C570
R562
R602
C B
R559
E C 1 2 3 4 5 6 7 8
R604
C578
C579
Q557
D556 R563
R582 E C580 15
E C B R558 J586
D560 B B
D555 Q502 14
C575
J605
CN503
B
Q553 Q520
C514
C C B 13
C574
R402
J549
E E C 12
E C B E
Q555 Q554 E 11
R520
R546
Q501
CN601
J609
J589
C560
J544 10 10
9 9
J588
D599 1 2 3 4 8 8
J542
J543 7 7
J553
C554
6 6
J578 J554 5 5
D598 J602 4 4
1 2 3 4
J555 3 3
C553
J569 2 2
C546 J556
1 1
D597 J557
1 2 3 4
J566
J603
J560
J558 D566
J580
H505B
J585
J417
J601
D565
R608
/W505
R570
J564
R598 C572
R502
R523
D509
R501
3
R513
Q503
C507
R567
J518
R532
E C B
D561 2
1
D533 R601
R609
R569
J509
J590
D510
R560 C551
R514
R526
R524
C508
7
R516
R515
C567
R575
R525
C515
C516
R568
C509
C510
R561 E501
J516
J510
C543
C544
C503
R505
R506
R610 3 2 1
R510
J559
R511
R509 D563
19 20 21 22 23 24 25 26 R550 Q511 Q512 C573 D564
B C E B C E
A B C D E F G
CAUTION
1 RISK OF ELECTRIC SHOCK
AC VOLTAGE LINE. PLEASE DO NOT
AC INLET P.C.B. (REPX0436A) TOUCH THIS P.C.B
2
FC501 FC502
Z501
F1 125V 6A
C500
JK500 T502(SUB TRANSFORMER)
3 L500 2 1 RLY501
J500
J525
1 3
J501 R58
2
Q519 R57
AC IN B
1
120V 60HZ
R590
C
J502 E
D500
R579
2 4
J503
B Q515
4 C
C559
3 4 5 E
4 3
J529
R500
J527
J523
J526
R401
R580
J540 J522
PbF
CN502
7 6 5 4 3 2 1
7 3
4
R577 3
5
D524 2
6
1
7
PbF H505A
8 /W505
9
10
11
8 12
13
14
15
CAUTION
RISK OF ELECTRIC SHOCK
AC VOLTAGE LINE. PLEASE DO NOT
9 SECONDARY PRIMARY PbF TOUCH THIS P.C.B
G H I J K L M
RIC SHOCK
NE. PLEASE DO NOT
C.B
W2A W1A
(BLU) (BRW)
Z501
C500
R)
Q516
RLY501
E C B
C555
R589
2
Q519 R578
B C557
1
R590
C
J524
R588
D525
E
D500
R579
R587
B Q515
C
D528
Q517
C559
E E C B
C571
4 3
J529
J527 C556
J523
R580
J522
ED P.C.B.
REPX0436A)
2
1
H505A
/W505
RIC SHOCK
NE. PLEASE DO NOT
C.B
SCHEMATIC DIAGRAM-1
: -B SIGNAL LINE : MAIN SIGNAL LINE
POWER CIRCUIT : +B SIGNAL LINE
C551 IC501
DISP HMUT
+VCC LOW
-VCC LOW
0.01 IC501
+Di SENS
-Di SENS
+VCC HI
RSN311W64B-P
-VCC HI
IN GND
SUB_O
IH DET
RELAY
SUBin
SR_O
AC IN
FR_O
SL_O
FL_O
POWER HIC
FRin
GND
SRin
FLin
C_O
SLin
+VD
-VD
Cin
E501 26 25 24 23 22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
K4CZ01000027
R501 R513
4.7K 56K
C505 1000P
C506 1000P
R523
120K
C508 18P R524
120K
R506 D501-D502
D502
D501
15K B0JAPG000019
R516 56K
C504 1000P
R526
C510 22P 120K
R505
15K R525
150K
C503
1000P R515 56K
4.7K
R511
R550 15K
10K
R540
R539
R543
CN501
R522
R521
56K
56K
AC1 R512
1 R551 15K
R519
820K
10K C513
DC_DET
6.3V100
2 C516 0.047
C514
R529
R520
22K
AC2 0.01 C515 22K
3 0.01
C517
SYS6V 0.01
4
R530 1
HP_CNT
5
D.GND R544 R531 1
6 R402
100 1K
FL
7 R541
SUB+B 100 R532
8
A.GND
Q520 4.7K Q503 Q503
9 R542 B1GCCFJJ0015
A.GND 100 INTERFACE SWITCH KTC3199GRTA
10 SWITCH
FR
11
TO SL
12
MAIN CIRCUIT A.GND
13
(JK2000) OF
SA-HT920P/PC-S SR
14 Q506
D504
15
C
B0AACK000004 B1GCCFJJ0015
INTERFACE SWITCH
A.GND D503
16
MA2C700A0F
R546 1K
17 SW R545
220K
KTC3199GRTA
A.GND
18 R547
C529 0.1
D503
390K
3.9K
PCONT
SWITCHING
19
B0AACK000004
Q501-Q502
Q505
SWITCH
R549
SYNC
21
FL C534 R548
22 50V33 330K
AC2
23
FL
24
AC1
25
Q557
R611 D562
R603 2SD0592ARA 10K B0AACK000004 C580
50V 2.2
10K FAN MOTOR DRIVE
6.3V 470
Q552
C647
D560
R581 B1ACCF000063
6.8K FAN MOTOR DRIVE
Q557 Q554
1 FAN_DRV D560 R562 R558
L_in B0AACK000004 B1ACCF000063 C574 4.7K 100K
2 FAN MOTOR DRIVE R564
0.01
TO 3 GND 220K R559
D558,D559
Q553 Q552
B1ACCF000063
R_in 10K
AMPILIFER CIRCUIT 4 B0AACK000004
FAN MOTOR DRIVE
B0EAKM000117
C575 D556
D557
+
SRRch
-
2
R575 C561 5 6 7 8
6.8K 50V2.2
C566
3
+
0.1
SRLch
-
4
R596
47K 5
+
CENTER
-
C519 C518 6
0.047 0.047
R534 R533
10 10 CN506
TO
3 AMPLIFIER
2
CIRCUIT
(H605/W605) ON
R595 R573 1 SCHEMATIC
100 0.1 DIAGRAM-4
H505B/W505 R577
C523 1.5K
0.047 3 3
C522 C569 2 2 D524
0.047 0.047 SLI325URCT31
1 1
R537 R538
10 10 H505A/W505
LED
CIRCUIT
1000P
1000P
1000P
1000P
C530
C531
C532
C533
CP502
1
PCONT 2
DGND TO
3 AC INLET
SYNC CIRCUIT
4
SYS6V (CN502) ON
5 SCHEMATIC
HELP DIAGRAM-3
R598 R608 6
D509, D533 1.5K 1.5K
7
B0BA5R100013 C550
0.01
R567 R609 E500
C567 1.5K 1.5K K4CZ01000027
C560 D509 50V10 D533 CN601
50V10
10
9
8 TO
Q511 C546
100V3300
C547 C548
AMPLIFIER
100V4700 100V4700 7
B1BACG000009 C545 CIRCUIT
VOLTAGE REGULATOR 0.1 6
C549 (H601/W601) ON
100V3300 5 SCHEMATIC
R570 R565 3.9K 4 DIAGRAM-4
C543 10K
1000P R569
3.9K 3
R568 D599 B0FBAM000009 D598 B0FBAM000009 2
150 1
B0BA5R700008
CN503
D510
C544 1
50V100 C554
0.1
2
3
B0BA01100004
4
D561
C572 5
D597 B0FBAM000009
50V100 R560
150 6 TO
TRANSFORMER
7
CIRCUIT
C573
8 (H503/W500) ON
C553 SCHEMATIC
1000P R561 0.1 9
3.9K FP1 DIAGRAM-3
K5G502AA0002 10
R610
Q512 4.7
11
B1BCCG000021 FP1 5A
12
VOLTAGE REGULATOR
13
R600
47K D563 D564 14
15
R601 D563-D566
47K B0BA01900005
D565 D566
SCHEMATIC DIAGRAM-3
: -B SIGNAL LINE
: +B SIGNAL LINE
R589 C555
10K 35V4.7
Q516 R578
KRC102MTA 10K
SYNC SWITCH
CN502
1 R580 D528
PCONT 22 B0EAKM000122
2
TO DGND
POWER CIRCUIT 3 Q517 R587
B1BACG000009 2.7K D528
(CP502) ON 4
SYNC
25V1000
VOLTAGE REGULATOR
SCHEMATIC
C571
SYS6V
DIAGRAM-2 5 C559
HELP 0.01
6 C556
0.01 R588
7 150
C557 D525
16V47 B0BA6R600008
R401
220K
R590 R579
1K 3.3K
W1
W2
H503 T501 4 2
/W500 G4C8AHD00001
1 RLY501
D500
B0AACK000004 D500 RSY0040M-0
2 3 1
3
C500
4 1000P
5
7
TO 8
POWER CIRCUIT F1 L500
(CN503) ON 9 RLQZ371 JK500
125V 6A
SCHEMATIC 10
DIAGRAM-2 FC502 FC501
11
12
13 Z501
ERZV10V511CS AC IN
14 120V/60Hz
15
IC601
OVER LOAD
DISP HMUT
+VCC LOW
IC601
-VCC LOW
+Di SENS
-Di SENS
+VCC HI
RSN312H24-P
-VCC HI
IN GND
DCDET
R_OUT
IH DET
L_OUT
RELAY
AC IN
POWER HIC
R_IN
GND
L_IN
+Hin
+VD
-Hin
-VD
22 21 20 19 18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
C612
B0JAPG000019
B0JAPG000019
1000P R619 56K
D603
C607 18P
D604
R620 56K
C608 18P
C611
820K
1000P
C619 0.01
3.9K
R633
R623
3.9K
C610 0.01
R624
C609 0.01
H602
/W602
FAN_DRV 1
L 2
R626 15K INGND 3
TO
R 4
POWER
R621 ACin 5 CIRCUIT
27K HMUTE 6 (CN602) ON
R622 DCDET 7 SCHEMATIC
H603A 10K R625 15K GND 8 DIAGRAM-1
JK601 /W603
R628 150K
SPEAKER
1 1 1 Rch
2 2 2 GND R627
120K H605
3 3 3 Lch /W605
4 4 4 GND 1 TO
H603B 2
POWER
/W603
C615 C616
3
CIRCUIT
0.047 0.047
(CN506) ON
SCHEMATIC
R631 R632 DIAGRAM-2
10 10
CN606
SPEAKER 1
2
TO
SUB
INTERFACE 3 WOOFER
CIRCUIT
Q601 C604
100V3300
C603 C602
100V4700 100V4700
B1BACG000009
VOLTAGE REGULATOR
C601
100V3300
R615 R613 R611
47K C613 2.7K 4.7
Q603 0.01
R616
2SD1859QRTV2
VOLTAGE REGULATOR D601 B0FBAM000009
4.7K
H601
R617 /W601
8.2K +VCCHI
C605 1
D605
B0BA01200008 0.1
R618 2
47K
D606 +VCCLO 3
B0BA01200008
4
GND
5
D607 D602 B0FBAM000009
B0BA02300017 6 TO
-VCCLO POWER
7
CIRCUIT
C614
8 (CN601) ON
R614 C606 -VCCHI SCHEMATIC
0.01 0.1 9
2.7K DIAGRAM-2
10
R612
Q602 4.7
B1BCCG000021R634
VOLTAGE REGULATOR D608 D609
47K
D610 D611
E AMPLIFIER P.C.B. -
SPEAKER
+ WOOFER
H601/ H602/W602
W601 8............1
10 CN606 1...3
.
.
. SPEAKER
.
.
H605
/W605
3
2
1
F INTERFACE P.C.B.
1
H603A 4.
W603 H603B
. JK601 SURROUND RIGHT
1 /W603
4 SPEAKER
4. 3
. 2
1 SURROUND LEFT
1
PbF PbF SPEAKER
SOLDER SIDE SOLDER SIDE
CN501
PbF
24 25
TO MAIN UNIT . .
. . 7. . . . . .1 CN503
. . 1.....................8
. . CP502 CN601 15
. . .
. . CN602 10 .
2 . . .
1 . .
CENTER . .
SPEAKER . .
SURROUND
6
. 5
FAN .
.
.
.
RIGHT SPEAKER . . . .
2 .
1 1 1
SURROUND
LEFT SPEAKER
JK501 CN507
LED P.C.B.
1 H505B/
2 W505
1 3 1
2 2 2 PbF
3 1 3
CN506 H505A/W505
SOLDER SIDE
SOLDER SIDE
POWER P.C.B.
W2 W1
W2 W1 H503/W503 BRW
BLU
1
.
BLU BRW .
.
T502(SUB TRANSFORMER) .
.
.
.
AC IN JK500
AC INLET .
.
120V 60HZ P.C.B. 15
SOLDER SIDE
CN502 T501(POWER TRANSFORMER)
PbF
7. . . . . .1 SOLDER SIDE
PbF
TRANSFORMER P.C.B.
IC501
RSN311W64B-P
POWER HIC
+
-
-
POWER CONTROL
CIRCUIT
POWER CONTROL/PROTECTION CIRCUIT
DISP HMUT
+VCC LOW
-VCC LOW
+DI SENS
-DI SENS
+VCC HI
FL_O(R)
SL_O(R)
-VCC HI
SLIN(R)
FLIN(R)
IN GND
SUB_O
IH DET
SUBIN
AC IN
C_O
+VD
CIN
-VD
26 22 23 18 15 20 3 6 1 8 11(12) 5 24 13 9 14 7 21 4 16
TO MAIN (25) (19) (2)
BLOCK B B
(JK2000) OF D501
SA-HT920P/PC-S B B B
Q506
INTERFACE
SWITCH D502
A
Q505
SWITCHING
SL(R)
FILTER JK501
SURROUND
SPEAKER
C
FILTER
JK501
CENTRE
SPEAKER
FILTER
SUBWOOFER
FRONTL(R)
FILTER
Q602 JK601
VOLTAGE
FRONT
Q501, B
B Q502 REGULATOR D601
SPEAKER
DC_DET
SWITCH Q601 T501
VOLTAGE
IC502 D508 B REGULATOR
POWER TRANSFORMER
DRIVE B
OP AMP
M
Q512 D598,D599
Q520 Q503 VOLTAGE
B REGULATOR
HP_CNT INTERFACE SWITCH
SWITCH
Q511
VOLTAGE
REGULATOR
SUBAC1
SUBAC2
FL1
FL2
B
RLY501
Q515,Q519
PCONT DCDET
SWITCH
B T502
B
Q517
D528 Z501 JK500
TRANSFORMER
VOLTAGE
REGULATOR AC INLET
L500
SUB
Q516
SYNC SYNC F1
SWITCH
E500
D602
B B
20 6
(21) 11 19 2 18 1 (3) 7
D604
4
DISP HMUT
-VD
-VCC HI
+VD
+VCC HI
AC IN
FLIN(R)
FLIN(R)
+VCC LOW
IC601 13
+DI SENS
RSN312H24-P 14
POWER HIC -DI SENS
D603
5
IH DET
-VCC LOW
12
SIGNAL LINES
( ) Indicates Pin No. of Right Channel Note : Signal Lines are applicable to the Left Channel only.
C0AABB000055 RSN311W64B-P RSN312H24-P KTC3199GRTA B1GCCFJJ0015
KRC102MTA
5
8
1 ..
....
.... 1
4 ....
....
B
C
1 26 E
12
18
A
E
C E
B C Anode
B
A Ca Anode
Anode
B0BA01900005 B0AACK000004
A B C D E F G
1
E AMPLIFIER P.C.B. (REPX0435A)
H602/W602
H601 8 7 6 5 4 3 2 1
J616
/W601
2 10
9
R634
J675
CN606
1 2 3
J615
8 J665
D608 D609
J617
J679
7
6 H605
R635 D602 /W605
R628
5
C604
R627
C601
1 2 3 4
J625
4 3
R625
R626
C606
D610
2
D611
3
2 R631 1
J626
J676
J677
1
C615 H603A
/W603
J687
J688
J618
3
C603
C602
D601
J698
R622
4
J689
J640
1 2 3 4 3
J678
R621
J696 J699
J628
2
J629
J655
C605
J627 1
R624
R632
J631
J644 J686
J630
R623
C607
D604 C616
D606
J619 C608 D605
R612
C619
R620 J700
C609
D603 R633
R611
C613
C611
D607
R619
C610
J642 B C E
C612
J643 J690 R616 R614
J621 Q603
J620
J695 J691 R613
4 PbF
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22
R615
J656
R618
R617
C614
B C E B C E
IC601 Q601 Q602
5
F SPEAKER INTERFACE
P.C.B. (REPX0435A)
6 H603B
/W603
JK601
4
4 SURROUND RIGHT
3 3 SPEAKER
2 2
1
1 SURROUND LEFT
SPEAKER
PbF