Draw and explain the working of N-P-N transistor in common
b. Emitter configuration with its suitable characteristic graph. 2 ABES Institute of Technology, Ghaziabad BEC 101: Fundamentals of Electronics Engineering Draw and explain the working of Center-Taped full wave 1st YEAR- All Branches c. 1 rectifier. Also calculate efficiency and ripple factor. Test (ODD SEMESTER 2023-24) Explain unity gain amplifier. Determine the output voltage of [Time: 3 Hours] [Total Marks: 70] the following network. COURSE OUTCOMES CO Statements Understand the concept of KVL, KCL, and PN Junction to solve various 1 circuits. d. 3 Explain the characteristics of Bipolar Junction Transistors and Field Effect 2 transistors. Illustrate op-amp as Adder, differentiator, integrator and Subtractor by 3 applying the Virtual Ground Concept. 4 Apply the concept of K-Map to minimize the expressions up to 6 variables. Understand the concept of modulation and determine the expression for an Explain construction and operation of NPN BJT. Derive the 5 amplitude-modulated signal. relationship between current amplification factor for common e. 2 emitter and common base configuration of bipolar junction SECTION-A transistor. Q.1 Attempt all Questions (2×7=14) CO a. What do you mean by Varactor diode? Write its one application. 1 b. Why FET is a voltage-controlled device? 2 SECTION-C c. Write down the characteristics of Ideal OP-AMP. 3 d. The output of OP-AMP increases 8V in 12μs.What is the slew rate? 3 Q.3 Attempt any one Question of the following (7 x 1= 7) CO Derive relation between current gain in CB and CE configuration of Explain the construction, working and characteristics of N- e. 2 a. 2 Transistor. channel depletion MOSFET. f. Define modulation index for AM wave. 5 Explain the construction, working and characteristics of N- b. 2 500W carrier is modulated to depth of 90%,calculate the total channel enhancement MOSFET. g. 5 power in modulated wave. Q.4 Attempt any one Question of the following (7 x 1= 7) CO SECTION-B a. Determine and draw the output voltage of given network. 1 Q. C Attempt any three Questions (7x3=21) 2 O Define the various elements of communication system and draw a. 5 its functional block diagram. Draw the block diagram of op-amp and list all the ideal b. 3 characteristics of op-amp.
Determine the range of input voltage (Vs) for the Zener diode to remain in ON state shown in figure.
b. 1
Q.5 Attempt any one Question of the following (7 x 1= 7) CO
a. With the help of the circuit diagram, explain the working of OP- 3 AMP as a non-Inverting summer. b. With the help of the circuit diagram, explain the working of OP- 3 AMP as an Integrator.
Q.6 Attempt any one Question of the following (7 x 1= 7) CO
An audio frequency signal 10Sin2π x 500t is used to amplitude modulate a carrier of 50Sin 2π x 105t. Calculate: (i) Modulation index a. 5 (ii) Amplitude of Each side band (iii) Total power delivered to the load of 2 KΩ. (iv) Bandwidth Derive the transmission efficiency and total power of amplitude b. modulated wave assuming message and carrier wave as sinusoidal 5 wave.
Q.7 Attempt any one Question of the following (7 x 1= 7) CO
Explain Satellite and RADAR communication using suitable a. 5 block diagram.