MSDS WP580

You might also like

Download as docx, pdf, or txt
Download as docx, pdf, or txt
You are on page 1of 3

MATERIAL SAFETY DATA SHEET TILE GROUT-WP580/ WP582/ WP584

1 Product and company identification


Synonyms: Tile Grout SG –WP580, Tile Grout HG-WP582, Tile grout HS-WP584

Produced /Distributed by:


Armin Josef Wuensch Plaster Factory Co.
P.O. Box 355 734 – Riyad 11384 KSA
Tel. +966 5000 65 799 Fax +966 121 47 706

2. Composition / Information on Ingredients


Chemical characterization
Blend of OPC, chemical additives and mineral aggregates

3. Potential Hazards
Hazard Information
Hazardous ingredients content – Nil
Prolonged exposure may cause irritation to respiratory system and skin sensitization

4. First Aid Measures


a) Eye contact-
Flush immediately with plenty of potable water for at least 15minutes.Get Medical help.
b) Skin contact-
Remove contaminated clothes immediately. Wash affected area with soap and plenty of
potable water.
c) Inhalation-
Remove affected person to fresh air. If symptoms persist obtain medical Attention.
d) Ingestion-
If swallowed obtain medical attention. Induce vomiting only on the advice of Physician.

5. Accidental release measurers


After spillage-
Release if possible. Or mix with water and allow hardening and disposing in landfill.
Flush contaminated area with plenty of water. In addition, please refer to local regulations
regarding disposal.

6. Handling and storage


Technical protective measures:
Store out direct sunlight, clear of ground on pallets protected from rainfall.
Avoid excessive compaction.
Protection against fire and explosion - N/A
7. Exposure controls / Personal Protection
Exposure limits: Mak (DFG, 1997)
Personal protective equipment
Respiratory equipment Dust mask
Eye protection Safety goggles
Skin protection Gloves
Other Observe usual precaution
Industrial hygiene Avoid formation of dust, wash hands
before break and after finishing the work

8. Physical and Chemical Properties

Form Powder Powder


Color Grey
Odour No Odour
Change in physical state N/A
Boiling oC (mm Hg) N/A
Melting point oC N/A
Flash point oC N/A
Auto ignition temperature N/A
Explosion limits N/A
-lower
-upper
Thermal decomposition Non decomposable
Bulk density Approx. 1350 (+- 25)
Specific gravity (oC) N/A
Vapour pressure, m bar (oC) N/A
Viscosity (oC) N/A
pH value (oC) N/A
Solubility in water Insoluble

9. Stability and Reactivity


Hazardous decomposition products N/A
Hazardous reactions N/A

10. Information on Toxicity


Information on toxicity general Dust act as skin, respiratory and eye irritant.
Wet mix act as eye and skin irritant in case of contact
with it for long time. (Please follow the protective
measures for the above as mentioned in clause no.7)

11. Information on Ecological effects


Ecological effect information: Do not discharge product in bulk
quantities into sewers and drains
as it might block flow of sewage water.
Other information:

12. Disposal
Disposal: Mix the water, allow to harden and
dispose in landfill. In addition, please
follow the local regulations or dispose with
the responsible local authority.
13. Transport
RID/ADR
UN No. N/A
IMDG Code
GGVE/GGVS
ICAO/IATA
ADNR, other information

14. Regulations
Labelling N/A
Symbol

15. Further Information


The above data are based on our present knowledge. However, they shall not constitute a
guarantee for any specific features and shall not establish a legally valid contractual
relationship.

For Armin Josef Wuensch Plaster Factory Co.

Quality Controller

You might also like