Professional Documents
Culture Documents
عبده
عبده
عبده
2- .Before soldering, the soldering Iron tip should be tinned to remove any
oxidation .
4- Applying flux to the surfaces being soldered helps Improve the flow and
.wetting of the solder
5- One safety concern when using a soldering Iron is the risk of burns from
the hot tip.
6- The recommended way to store a soldering Iron when not in use is to
unplug stand it and place It in a
8- .When soldering, the heat should be applied to the joint for 2-3 seconds
9- .To clean the soldering Iron tip, it should be wiped on a damp sponge
10- The purpose of tinning the soldering Iron tip is to improve the transfer of
heat to .the joint
11- A multimeter has three parts: Display, Selection Knob, and ports .
13- The selection knob on a multimeter allows the user to set It to read
different things such as milliamps (mA) of current, voltage (V), and
Resistance (Ω)
Ohmmeter
18- The most common output waveforms are sine, square, triangular, ramp,
and Pulse .
19- A function generator provides a variety of output waveforms over a
wide Frequency range.
20- In a DC power supply, there are three output studs: pos, neg,
and Ground .
21- Two control knobs on a DC power supply are used to adjust Voltage
and current.
22- A digital multimeter may also have functions such as diode test,
continuity test, transistor test, TTL logic test, and Frequency test.
27- The dual power supply has two outputs with fixed polarities, while the
single power supply has a fixed polarity either Positive or negative.
28- The built-in amp/volt meter In a power supply helps in monitoring the
Voltage and current levels.
What are the two control knobs on a power supply used to adjust?
A) Voltage and Current
B) Frequency and Resistance
C) Brightness and Contrast
D) Temperature and Humidity
Answer: A) Voltage and Current
What does the selection knob on a multimeter allow the user to switch
between?
A) Voltage and Current
B) Frequency and Resistance
C) Brightness and Contrast
D) Temperature and Humidity
Answer: A) Voltage and Current
What is the recommended way to store a soldering iron when not in use?
A. Leave it plugged in and standing upright
B. Unplug it and place it in a stand
C. Wrap the cord around the iron and store it in a drawer
D. None of the above
Answer: B. Unplug it and place it in a stand