Professional Documents
Culture Documents
PLANT AND SERVICE ENGINEERING LEVEL 6
PLANT AND SERVICE ENGINEERING LEVEL 6
PLANT AND SERVICE ENGINEERING LEVEL 6
WRITTEN ASSESSMENT
Time: 3 hours
INSTRUCTIONS TO CANDIDATES
Maximum marks for each question are indicated in brackets ().
This paper consists of THREE sections: A, B and C.
Answer questions as per instructions in each section.
You are provided with a separate answer booklet.
Page 1 of 6
©TVET Curriculum Development, Assessment and Certification Council July/August 2024
Candidates should check the question paper to ascertain that all pages
are printed as indicated and that no questions are missing
3. In electrical circuit networks analysis Kirchhoff’s theorem is important. What does it state
regarding Voltage and current? (4 Marks)
Page 2 of 6
©TVET Curriculum Development, Assessment and Certification Council July/August 2024
10. A 400m aluminum conductor has a diameter of 4mm.if the resistivity of aluminum is
28.5µΩmm, find the resistance of the conductor. (6marks)
11.
a. With the aid of a circuit diagram, derive an expression for total capacitance for three
capacitors: C 1 , C 2 and C 3 corrected in series across a DC source of V volts.
(10 Marks)
12.
a. Figure below shows an electric circuit. (10 marks)
Calculate,
i. the total circuit resistance,
ii. circuit current,
iii. Voltage across 3Ω resistor
iv. Voltage across 5Ω
Page 3 of 6
©TVET Curriculum Development, Assessment and Certification Council July/August 2024
Page 4 of 6
©TVET Curriculum Development, Assessment and Certification Council July/August 2024
Page 5 of 6
©TVET Curriculum Development, Assessment and Certification Council July/August 2024
Page 6 of 6