Professional Documents
Culture Documents
K31 Installation Instruction
K31 Installation Instruction
K31 Installation Instruction
V1.00
2019.01.09
深圳合众思壮科技有限公司
www.kingsine.com.cn
Contents K31 Installation instructions
V1.00 2019-01-09
Contents K31 Installation instructions
Remove the 8 screws in the RED arrow mark place as figure above
Figure 1 Figure2
Tools needed:-----
Step3:Remove Bottom Cover Panel K31 Installation instructions
Method:Erect up the chassis on its feet ,and then open the bottom panel。
Tools needed:-----
Step4: Remove Wiring connection Terminals K31 Installation instructions
Remove the 3 wiring connection terminals as above,and then use a electric soldering iron to
have out the yellow,black,blue wires melt off the PCB。
User shall remember(take photo/make mark) which points the colored wires connects to
before user replace the new amplifier. Because later user shall connect the colored wires in
the same order as being yellow/black/blue.
Tools in need:Electric soldering iron 。
Step5: Remove the amplifier screws K31 Installation instructions
Erect up the device on the opposite of its feet(keep fan outlets upside)
Remove the 8 screws of amplifier as marked.
Tools needed:------
Contents K31 Installation instructions
Figure 1 Figure 2
Tools needed:------
Step2 : Fixed up the amplifier K31 Installation instructions
This step requires two men, one man erect up the device on its feet(fan outlets is
downside) or lay device flat in horizontal level, then move the amplifier slowly till they
are all aligned for those screw holes on the bottom plates(make observation by the
other man), then fix the screws tight 。
Slide the bottom cover panel of the chassis through the side slots on
both two sides to ensure the cover is in right place.
Tools needed:-----
Step5: install top cover panel K31 Installation instructions
Slide the top cover panel of the chassis through the side slots on both two
sides to ensure the cover is in right place。
Tools needed:-----
Step6 :install Base Feet and fix screws K31 Installation instructions
Align the feet with the screw holes, first install the small screws pointed by the
red arrow, and then install the big screws pointed by the blue color arrow.