Professional Documents
Culture Documents
Pressure Control Valve - Remove and Install (UENR1353)
Pressure Control Valve - Remove and Install (UENR1353)
Removal Procedure
PIP
Start By:
-
202 1018
1
a. Remove the seat.
4
05: 07/0 735
/
3
UE 2:00+ 8
Personal injury can result from hydraulic oil pressure and hot
N
oil.
© 2 R13 03:00
Hydraulic oil pressure can remain in the hydraulic system after
024 53
the engine has been stopped. Serious injury can be caused if
this pressure is not released before any service is done on the
hydraulic system.
Cat
erp
Make sure all of the attachments have been lowered, oil is cool
before removing any components or lines. Remove the oil filler
illa
cap only when the engine is stopped, and the filler cap is cool
rI
enough to touch with your bare hand.
nc.
NOTICE
Care must be taken to ensure that fluids are contained during
performance of inspection, maintenance, testing, adjusting, and
repair of the product. Be prepared to collect the fluid with
suitable containers before opening any compartment or
disassembling any component containing fluids.
Note: Mark all components for correct installation. When you disconnect the hoses, plug the hoses and
cap the connections in order to keep the system clean.
Illustration 2 g03402432
5. Remove three bolts (3) and remove pressure control valve (5).
Installation Procedure
1. Install pressure control valve (5).
PIP-10181735
2024/07/08
05:31:54+03:00
i05376753
© 2024 Caterpillar Inc.