Professional Documents
Culture Documents
task no 34
task no 34
task no 34
task no 34
task no 34
MECH. INSP.
A. Referenced Information
REFERENCE DESIGNATION
Ref. AMM Closing of the Fan Cowls
71-13-00-410-010 437AL(447AL),438AR(448AR)
Ref. AMM Operational Test of the FADEC SYSTEM on
73-22-00-710-040 the Ground
Ref. ASM 73-25-16
Ref. AMM Operational Test of the Thrust Reverser
78-31-00-710-041 System with the CFDS
Ref. AMM Removal of the Thrust Reverser Hydraulic
78-31-51-000-010 Control Unit (HCU)
Ref. AMM Installation of the Thrust Reverser Hydraulic
78-31-51-400-010 Control Unit (HCU)
Ref. Fig. Thrust Reverser (Engine 1)
3. Fault Confirmation
SUBTASK 78-30-00-710-258-A
task no 34
MECH. INSP.
(3) If the fault code readout in (1) does not give one of the above
listed fault codes:
- continue with fault confirmation by Engine Ground Run
Section 4.B below.
SUBTASK 78-30-00-710-066-A
B. Test
(1) Do the operational test of the thrust reverser system with the
CFDS (FADEC 1A and 1B) Ref. AMM 78-31-00-710-041.
4. Fault Isolation
Ref. Fig. Thrust Reverser (Engine 1)
SUBTASK 78-30-00-810-058-A
A. If the test gives the maintenance message PERM SW/HCU/HC1:
- Read the fault code shown on the FLIGHT DATA and
GROUND DATA of the FADEC (1A and 1B) menu on the
MCDU (Ref. 70-00-00 Page Block 301 Task Supporting Data).
- Make a record of the fault code.
(1) If the FADEC 1A menu gives the fault code DCVWAF:
- Replace the HCU-THRUST REV (4101KS) Ref. AMM
78-31-51-000-010 and Ref. AMM 78-31-51-400-010.
task no 34
MECH. INSP.
task no 34
MECH. INSP.
task no 34
MECH. INSP.
SUBTASK 78-30-00-710-259-A
B. Repeat the fault confirmation as given in Para. 3 using the same
method (FADEC Ground Test or Engine Ground Run) as before and
confirm fault elimination.
5. Close-up
SUBTASK 78-30-00-860-058-A
A. Make sure that the fan cowls 437AL and 438AR are closed Ref. AMM
71-13-00-410-010.
task no 34
MECH. INSP.
2 A
9 8
A 4
B 5
D 2
C 3
C 7
k 6
C 7
k 6
C 3
D 2
B 5
A 4
9 8
2 1
4 B