Professional Documents
Culture Documents
v240MT_Initialization Check_Troubleshooting Guide_1.0
v240MT_Initialization Check_Troubleshooting Guide_1.0
v240MT_Initialization Check_Troubleshooting Guide_1.0
Approval:
Revision History:
Table of Contents
1. Introduction ................................................................................................................................................. 2
2. Perform Initializing Test .............................................................................................................................. 3
1. Overview
START
Power On
Sensor box
Initialize END
Tri-Band
EL Initialize
Initialize
2. Introduction
To verify the antenna mechanic & parts problem, perform initializing the antenna
while looking at the sequence inside the radome.
Use the power switch on the power box inside the radome as shown below.
BUC ANT.
Sensor box
EL Initialize
4. Move the antenna elevation to adjust the sensor box in the horizontal
position.
EL Initialize
Note
The antenna elevation is set as “target satellite EL position” while conducting the
step 3 to 4.
Ku Skew
Home Sensor
Tri-Band Motor
11. Azimuth sensor detects home flag (indicated by red LED inside the sensor)
and stops smoothly after moving about 30 degree.
Note : Relative AZ Angle is set through the step 8 to 9.
AZ Assembly
Home Sensor
Please contact your local TS team should you have any trouble while conducting initializing
test.