Download as pdf or txt
Download as pdf or txt
You are on page 1of 3

Post-Repair

Vehicle Diagnostic Report

Repair Shop
Shop Name:Tims Autoelec
Address:East London East London easterncape
Zip Code:5247
Telephone:
Email:timsautoelec@gmail.com
SN:989140412236
Test Time:2024-06-05 15:50:01
Notes:tcm plug connection (fault)

Vehicle Information
Make:Mercedes-Benz
VIN:ABJ96342460256483
Vehicle Software Version:V18.80
Diagnostic Application Version:V2.00.027
Diagnostic path:Automatic Detection > 16Pin Socket>Actros(963)>963
Notes:tcm plug connection (fault)

System fault code

The following systems is abnormal:

CGW - Central Gateway 2 problems exist

1.EFFEFF CAN Communication With Component ''{0}'' Is STORED


Interrupted.
2.13FFFF CAN Communication With Component ''A35 (Tire CURRENT And STORED
Pressure Monitor (TPM) Control Unit)'' Is Interrupted.

CPC - Drive Control 1 problem exist

1.EC020C The CAN Signal From Control Unit ''A11 (Retarder STORED
Control (RCM) Control Unit)'' Is Missing.

EAPU - Electronic Air-Processing Unit 3 problems exist

1.2EF3E3 Component ''B26 (Condensation Sensor)'' Has A Short CURRENT And STORED
Circuit To Positive.
2.54F3E0 A Leak In The Brake Circuit For Transmission Control CURRENT And STORED
And Automatic Clutch Operation Has Been Detected.
3.53F3E0 A Leak Was Detected In The Brake Circuit For Trailer CURRENT And STORED
Control.

EBS - Electronic Brake System 3 problems exist


1.180306 Component ''B16 (Right Rear Axle rpm Sensor)'' Has A CURRENT And STORED
Short Circuit.
2.150301 The Air Gap Between Component ''B13 (Left Front Axle CURRENT And STORED
rpm Sensor)'' And The Sensor Rotor Is Too Large.
3.170307 The Sensor Rotor At Component ''B15 (Left Rear Axle CURRENT And STORED
rpm Sensor)'' Has A Mechanical Fault.

MS - Maintenance System 3 problems exist

1.FE2C3F Unequal Brake Wear On Front Axle 1 (excessive CURRENT And STORED
Deviation Between Values)
2.FE2C9F Unequal Brake Wear On Rear Axle 2 (excessive CURRENT And STORED
Deviation Between Values)
3.08F1FF CAN Message ''Hill Holder'' From Component ''A10 CURRENT And STORED
(Antilock Brake System (ABS) Control Unit, 4-channel)'' Is Faulty
Or Unavailable.

SCA/SSAM - Single Signal Acquisition And Actuation Module 8 problems exist

1.97F5E5 Component ''Right Side Turn Signal Lamp'' Has An Open CURRENT And STORED
Circuit.
2.F5F4E5 Component ''Right Front Fog Lamp'' Has An Open CURRENT And STORED
Circuit.
3.F4F4E5 Component ''Left Front Fog Lamp'' Has An Open Circuit. CURRENT And STORED
4.59F7E2 The Battery Management Function Is Not Available. CURRENT And STORED
5.52F7EC Software Error CURRENT And STORED
6.4CF7E2 Control Unit ''A7a (Single Signal Acquisition And CURRENT And STORED
Actuation Module (SSAM) Control Unit)'' Has Received No LIN
Message From Component ''G1a (Battery Sensor (IBS))''.
7.94F5E5 Component ''Left Front Turn Signal Lamp'' Has An Open CURRENT And STORED
Circuit.
8.84FAF1 One Or More Switches In A Switch Module Is Missing. CURRENT And STORED
The following systems are OK:
1.CCM/RCM - Turbo/retarder Clutch/Retarder
2.CLCS - Level Control
3.DCMD - Door Module ''Driver''
4.DCMP - Door Module ''Front Passenger''
5.EIS - Electronic Ignition Lock
6.HVAC - Heating, Ventilation And Air Conditioning
7.ICUC - Instrument Cluster
8.MCM - Engine Management
9.MPC - Multifunction Camera
10.PSM - Parameterizable Special Module
11.SAS - Steering Wheel Angle Sensor
12.SRS - Supplemental Restraint System
13.TCC - Truck Control Center
14.TCM - Transmission Control

You might also like