Professional Documents
Culture Documents
Weld Toe Gauge
Weld Toe Gauge
+ ÷
examples of conforming and nonconforming welds.
The guide is not an interpretation of the standard, as only the national standardi-
zation organizations are authorized to perform interpretations of standards.
Therefore in case of doubt or contradiction the standard shall prevail.
Assessment Guide for imperfection type incorrect transition profile according to Assessment Guide for imperfection type incorrect transition profile according to
EN ISO 5817:2007 quality level B EN ISO 5817:2007 quality level B
Sketches in this column are all Sketches in this column are all Sketches in this column are all Sketches in this column are all
acceptable to EN ISO 5817-B not acceptable to EN ISO 5817-B acceptable to EN ISO 5817-B not acceptable to EN ISO 5817-B
+ ÷ + ÷
Multi- run weld This weld reinforcement do not have
The transition profile at the weld The angle at the weld toe is less a smooth transition (the angle is
toe is acceptable than 150° approximately 110°)
+ ÷ + ÷
If the weld has a smooth transition, This weld reinforcement do not have
for example. Obtained by grinding, a smooth transition (the angle is A borderline example, but Angle approximately 130°, measured
this has to be accepted. approximately 90°) acceptable at a thickness reduced area
+ ÷ + ÷
Dressed weld reinforcement Incorrect angle in connection with Multi- run weld
the weld run completion Angle approximately 110°
+ ÷ + ÷
If the weld has a smooth transition,
for example. Obtained by grinding, Incorrect angle in connection with Angle approximately 110°, measured
this has to be accepted. the weld run start at a thickness reduced area