Professional Documents
Culture Documents
20GE205 BEEE QB
20GE205 BEEE QB
Part B
1. Determine the three mesh currents in the circuit show below use mesh analysis.
5. Calculate the power dissipated in the 4Ω resistor given in network using superposition
theorem.
6. For the circuit shown in Fig below, determine all mesh currents as indicated.
7. Using Thevenin’s model determine the current through the load resistor of 3Ω connected
across terminals A&B of the circuit shown in Fig below
8. Explain the construction and working principle of DC Motor with neat diagram and derive
the Torque equation of DC Motor.
9. Explain the construction and working principle of DC Generator with neat diagram and
derive the expression its induced EMF equation of DC Generator.
10. With neat diagram, explain the construction and working principle of Transformer and
derive the expression its induced EMF equation of single-phase Transformer.
11. Explain electricity generation using Solar thermal System with its merits and demerits
12. Explain electricity generation using kinetic energy of Wind with its merits and demerits
13. Explain the operation of domestic refrigerator and describe each component and its working
with a neat diagram.
14. Explain the construction and working of a PN junction diode and explain its V-I
characteristics with a neat diagram.
15. With neat diagram, explain the operation of Zener diode and its forward and reverse
characteristics. Also distinguish between Avalanche and Zener Break down.
16. Explain the operation of NPN Transistor and draw the circuit for Common Emitter
Configuration and explain the input and output characteristics.
17. Explain the operation of PNP Transistor and draw the circuit for Common Base
Configuration and explain the input and output characteristics.
18. Explain in detail about the integrator and differentiator circuits using Op-amp and derive the
expression for output voltage.
19. Explain in detail about the inverting and non inverting amplifier circuits using Op-amp and
derive the expression for output voltage.
20.i) Perform the following code conversions:
(10111 .101)2 →(?)10 →(?)8 →(?)16
(CE)16 → (?)10 →(?)2 → (?)8
ii) Subtract the unsigned number (10100)2 from (11011)2 using 1’s complement & 2’s
complement method.
iii) Perform the following conversions:
i) (34.25)10 = (?)2
ii) (1101.111)2 = (?)10
iii) (202.52)10 = (?)8
iv) (FACE)16 = (?)10
iv) Realize XOR gate using NAND gates only & NOR gates only.