Professional Documents
Culture Documents
02 ECQ-D24 QATAR RAIL utility layout
02 ECQ-D24 QATAR RAIL utility layout
OPERATIONAL LRT
TELECOM MANHOLE 1- Datum of 0.00 Equal to +2.80 on QND ( Qatar National Datum )
PIN 69040240
1 2- Maximum depth of excavation for shoring piles within RPZ is -9.950m QND
QR-300 3- Proposed works has no influence on QR assets. However, all safety guidelines
Z A B C E F G D H I to be strictly followed.
4- Any document that is not part of the submittal to RKH will not be covered
through this permit and the associated works will be treated as violation.
E 229372.684 5- Drilling or boring is STRICTLY prohibited within critical zone.
T N 405447.140 A 6- From the edge of elevated QR structures, 10m distance must be considered as
U
INTERFACE LINE E 229315.184 FH Crane free zone where no crane movement/erection or boom reach or material
handling by crane is allowed.
7- Approved QR PTW should be always kept at the site.
E 229311.932 E 229318.468
S N 405443.000
N 405444.476
N 405444.917 8- Dewatering Aassesment Report to be submitted at the PTW stage to confirm
NO impact on the Qatar Rail tunnel before construction commence.
E 229309.065 6199 6300 6375 11350
N 405441.175 KEY PLAN
R JRC 12
42
DOWN TO BASEMENT 01
SHORING SYSTEM
E 229306.740 E 229374.987
Q N 405438.559
N 405438.176 Qatar Integrated Railways Project
B Governmental Interfaces & Permits Department
E 229305.082 GARBAGE STORE
39 m²
P N 405435.477
D AINAGE 7
MANHOLE
N
E 229304.179
O N 405432.095 OPEN TO ABOVE
FUEL TANK
7 16 m²
REV DESCRIPTION DATE
RAIL PROTECTION 00 DC1 2022-10-17
GENERAOTPEONRTO ABOVE
6
ZONE LIMIT ROOM
E 229304.082 29 m² E 229377.040
N N 405428.597 N 405428.384
C
6
E 229304.450
N 405426.631
M LV ROOM
59 m²
E 229305.948 E 229378.635
N 405419.323
L TX ROOM
1
QR-300
N 405418.512
D QR-Code MUNICIPALITY STAMP
HV CABLE
36 m²
LAYOUT
8349
11824
-4.60
Maximum depth for all works
-4.20 - There is no work Within Critical zone
4 FH MV ROOM
4 - Out of Critical Zone is -11750 mm QND(95)
75 m²
3475
Important Conditions (operational Rail)
3 E 229307.237 3 1- The building Permit from the Municipality
does not PERMIT to proceed with WORKS. PTW
2275
N 405411.427
from Qatar Rail must be approved before any
K
1200
1693 works in the site.
2 2 2- The following works are NOT allowed and
require separate approval from Qatar Rail:
F.F LOBBY F.F LOBBY E 229379.891
LIFT LOBBY · Drilling Geotechnical investigation/ boreholes
7 m² 7 m²
14 m² N 405408.591 / wells
375 PUMP ROOM
28 m²
E · Drilling for earthing rods / Pits (earth boring).
ENQUIRY No. : Application No :
488 STAIR-2 · Any unapproved Dewatering works. CONSULTANT REG. No : GRADE: CONSULTANT REG. No : GRADE:
8600
CORRIDOR CONSULTANT STAMP & SIGNATURE : CONSULTANT STAMP & SIGNATURE :
m² nailing, Piling, Diaphragm etc.
DN FF TANK1 18 m²
· Installation/replacement of unapproved
POTABLE
PLOT BOUNDARY
depth.
ETS I
6- The design, construction and operation of the ENGINEERING
9900
94 m²
permitted works shall be perform strictly in CONSULTANCY
TM-219-G01 TM-220-G01
BALL VALVE
E 229309.064
ROAD CROSSING FOULSEWER HOUSE CONNECTION WITH
END CAP ( 150mm, 200mm, 250mm VC PIPE)
STRAIGHT JOINT
This drawing needs to be read in conjunction with all
Qatar Rail guidance documents , manuals and
ECQ-D24-OFFICE BUILDING
H N 405389.693 conditions of the mentioned below approval form