Professional Documents
Culture Documents
Software manual
Software manual
Software manual
0
Simcenter Flomaster V9.0 delivers the accuracy, CAD2FM can be used directly from
flexibility and speed you demand within the CAD environment (Siemens
NX and Solid Edge, PTC Creo and
Dassault CATIA V5) and allows you to
control the fidelity level of the
abstracted models as well as the num-
New to V9 • Multiple compressors within the AC ber of Simcenter Flomaster components
circuit created to represent the piping geom-
Air conditioning system modeling
Building on the existing enthalpy solver • Investigation TXV and evaporator etry for efficient thermo-fluid
and waste heat recovery system func- interaction simulation.
tionality, the new AC systems modeling
• System operation across a range of
capability enables you to model a wide
operating points using Simcenter
range of systems, from traditional
Flomaster’s parametric tools.
automotive and building services sys-
tems, through to more complex When used in combination with compo-
multiple loop, multi component systems nents in the Vapor Cycle library,
for advanced EV cooling solutions and additional thermal cycles such as the
aerospace applications. Transcritical Rankine, Goswami and
Trilateral Flash Cycles can be modelled.
Simcenter Flomaster™ V9 software
provides a user friendly environment so
CAD to Simcenter Flomaster
AC systems can be designed from the
The new CAD to Simcenter Flomaster
earliest possible stage while being
(CAD2FM) functionality is a fully auto-
robust and requiring minimal compo-
mated function to convert 3D MCAD
nent data. Features include:
piping geometry into an equivalent
• Minimal component data for early Simcenter Flomaster sub-system,
system simulation bypassing data re-entry errors and
compressing the time required for such
• Multiple loops
a conversion from hours to minutes.
www.siemens.com/simcenter
N-Arm component User experience • New output parameter
The scripted N-Arm component allows A number of new functionalities have
-- Allows for monitoring of parame-
you to create custom components been added to Simcenter Flomaster V9
ters at the end of a run
based on your own IP. The N-Arm to make it a powerful and robust
component characterizes the hydraulic System of Systems application with a
and thermal behavior of the compo- Designer Level user experience: “Design efficiency is key over
nent. The capabilities of the N-Arm
include:
• Results post-processing our short 18 month design
• Up to 45 fluid arms
-- Review results at a glance in the and manufacture cycle, and
new dashboard and Gas Turbine TBR19 is looking forward to
• Five signal inputs viewer
using the new CAD2FM
• Customizable data forms • Schematic annotation
package to provide vital
• No requirement for the user to linear- -- Highlight area of interest by draw-
ize the equations behind the fluid ing lines and shapes
timesaving and design
behavior flexibility.”
• Three new sample systems
• Running with all Simcenter Flomaster Joe Willey
-- Automotive AC Project Manager
simulation types and fluid models
Team Bath Racing 19
-- Pipe line systems
The addition of signals and the writing
of custom results in Simcenter -- Marine cooling systems
Flomaster V9 extend the N-Arm capa-
bilities allowing a full range of
behaviors to be modelled.
reduction in radiator face Amesim, LMS Samtech Samcef, LMS Samcef Caesam,
Simcenter SCADAS, Simcenter Testxpress, Simcenter
area as a result, with 16.8% Soundbrush, Simcenter Sound Camera, Simcenter Testlab,
LMS Virtual.Lab, Simcenter FLOEFD, Simcenter Flomaster,