Professional Documents
Culture Documents
MC-10189619-0001
MC-10189619-0001
Work Instructions
General Information
NOTE: Cascadia and New Cascadia vehicles have entirely different electrical architecture.
Cascadia vehicles have an accessible fused battery power and ground location inside the cab. The SAM
CAB has a variety of fuse locations available for customer access.
Additionally, ground splice packs are available for a clean ground-return termination point.
1
Daimler Trucks
North America LLC Customer Advisory Letter
03/26/2021 CAL FTL 54-004
2
Daimler Trucks
North America LLC Customer Advisory Letter
03/26/2021 CAL FTL 54-004
3
Daimler Trucks
North America LLC Customer Advisory Letter
03/26/2021 CAL FTL 54-004
2.6. Select the Power Distribution option. See Fig. 6.
4
Daimler Trucks
North America LLC Customer Advisory Letter
03/26/2021 CAL FTL 54-004
2.8. The top side of the SAM Cab Pin layout will display. See Fig. 8. Selecting any of the
connector options will display the correct pins for each cavity in the connector.
Note the link to view the SAM Pin Layout Wall Chart (previously mentioned in Service
Solution 3672) at the top of the screen.
2.9. Select the SAM Pin Layout Wall Chart Link and look at fuse 32. See Fig. 9.
As the vehicles addressed in this customer advisory letter do not have a cab load
disconnect (CLDS) switch, this location will have constant battery power.
Note that connector X15 pins 1 and 2 are fed by fuse 32.
5
Daimler Trucks
North America LLC Customer Advisory Letter
03/26/2021 CAL FTL 54-004
2.10. Return to the view of the top side of the SAM Cab Pin layout. Note that connector X15
is a four pin connector with reasonable access. See Fig. 10.
Fig. 10, Connector X15 on Top Side View of SAM Cab Pin Layout
2.11. Select the X15 connector to view its respective terminals. See Fig. 11.
6
Daimler Trucks
North America LLC Customer Advisory Letter
03/26/2021 CAL FTL 54-004
Ground Access
1. Open Parts Pro and select module 320 to access the installation diagram print INSTL-SRVC,
DASH HARN D06-56742-000 for the physical location of the auxiliary ground splice
PWR_DASH_O_SP_GND_AUX_1A. See Fig. 12.
2. Also in Parts Pro, select module 285 for the schematic WRG-PWR, IN CAB AUX PDB, G66-02258-
000 and note splice pack PWR_DASH_O_SP_GND_AUX_1A. See Fig. 13. Note the part number of
the splice pack: 23-13141-018.
7
Daimler Trucks
North America LLC Customer Advisory Letter
03/26/2021 CAL FTL 54-004
3. Open DTNA Connect and navigate to EZWiring and select the EZWiring icon. See Fig. 14.
4. In EZWiring under ‘Drawing View’ type the above noted splice pack part 23-13141-018 into the
Diagram Part Number field and select the ‘View’ button. See Fig. 15.
5. Scroll all the way down until the 23-13141-018 option is visible. Note the terminals intended for
this connector. See Fig. 16.
These terminals are available for viewing individually in EZWiring to determine their respective
gauge and alloy.