Professional Documents
Culture Documents
GL3000-control unit of BS-SZB
GL3000-control unit of BS-SZB
INSTRUC
DIGITAL LIMIT SWITCH
Gl3000
1
1. Descriptions
AC 220V 50/60Hz
-30℃ ~85℃
Remote frequency 433.92MHz
2
2. Electrical connections
DIGITAL PANEL
Setting Buttons
SET >> O_SPEED C_SPEED MODEL LEARN
Control Buttons
EncoderA
Relay
Relay1
Relay2
Relay3
Relay3
Power GND
Power GND
Power GND
Power GND
Power GND
+12V +12V
+5V +5V
+
-
OPEN
LOOP
STOP
PHO
NO3
NO2
NC3
CLS
NO1
CM
PT
A2
B2
B
A
3
Control box of BS-SZB L
N N N N O S C P
C O P
O O O C P T L H
M O T
1 2 3 3 N P S O
P
G + G G G G +
P A B
L N U V W N 5 N N N N 12 A B
E 2 2
D V D D D D V
220V AC
G +
P
U V W N 12 A B
E
D V
Adapter board
Alarm light G +
P
U V W N 12 A B
E
D V
M ENCODER
Motor cover Inverter Motor
Alarm light
Accessories
~ ~ G
12 12 A N B
V V D
POWER MAX485
Note: Pls connect external accessories as alarm light or photocell as above drawing, working
current should be less than 2.5A, working voltage should be no more than 250V AC/30V DC
4
4. Remote controller operation
Note: 1、The original transmitters has been matched the code, and users
do not need to do this.
2、New transmitters need to be set the steps as above.
5
5. Limits setting
Note: For the controller initially installed, manually adjust sliding gate to middle
position before power on.
Power on
Press and hold “OPEN” button till gate reaches open position
Yes
No
Note:
: Push ”STOP” button
Press and hold “CLOSE” button and watch the sliding gate to quit during setting
process, but no record.
No
After the quick setup as
Is the gate closing till the close position
above, the sliding gate can
Yes
run normally, please
Press”SET” button to confirm operate to open and
close the gate one time,
inspect if the limits setting
Press “STOP” button to quit is satisfied.
End
6
6. Delay automatically close setting
Function description: The sliding gate will automatically close after setting
when the gate is open fully.
Note1: The factory default value is “0”, means that the function is cancelled.
Note2: The maximum delay value is 99 seconds.
Power on
End
7
7. Open / Close Speed setting
Power on
9. Factory reset
Power on
Press and hold “SET” button, display value”1” Press “STOP” to quit.
press “CLOSE” to decrease the value to “0”
End
8
8
9. Trouble Shooting
Display error code Refer to Error codes table Refer to Error codes table
Motor can’t run Motor wires are short circuit Check the wiring
9
9.Soft start
control boxsetting(Just
have this the single phase
function)
10. Function Codes Table
10
Code Description Mark
11