Professional Documents
Culture Documents
Differential Lock Pressure - Check
Differential Lock Pressure - Check
Differential Lock Pressure - Check
Page 1 of 2
Shutdown SIS
Previous Screen
! " #
$ % & '(
) *
!" #$ $ % &' ( ) ) % ( *+ ) ) %
+ ,
When testing and adjusting the transmission and power train, move the
machine to an area clear of obstructions, with safe exhaust ventilation
for the exhausts. Sudden movement of the machine or release of oil
under pressure can cause injury to persons on or near the machine. To
prevent possible injury, do the procedure that follows before testing and
adjusting the transmission and power train.
NOTICE
Care must be taken to ensure that fluids are contained during
performance of inspection, maintenance, testing, adjusting, and repair
of the machine. Be prepared to collect the fluid with suitable containers
before opening any compartment or disassembling any component
containing fluids.
Before you begin the test, refer to Systems Operation, Testing and Adjusting, "Machine Preparation for
Troubleshooting".
Table 1
Required Tools
https://198.101.110.37:8443/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sis... 5/12/2008
120H Motor Grader 5FM00001-UP (MACHINE) POWERED BY 3116 Engine(SEBP25... Page 2 of 2
1. Operate the machine until the transmission oil is at operating temperature of 51 °C (124 °F).
2. Stop the machine on a hard level surface. Engage the parking brake. Turn the engine OFF.
Illustration 1 g00921021
View of the differential lock valve
3. Remove the dust cap. Attach 8T-0856 Pressure Gauge (0 to 6,000 kPa (0 to 870 psi)) to test port
(1) .
4. Remove the differential drive shaft. Operate the machine in first gear forward at high idle. Engage
the differential lock valve. The gauge should read a minimum of 2620 kPa (380 psi).
5. Stop the machine. Turn the engine OFF and install the differential drive shaft. Remove the test
equipment.
-. / ,,) 0 - # 1 . 8 )8 )+! 9 + 0
/2 2 3 1
3 $ 4 5 6#67 2 21
https://198.101.110.37:8443/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sis... 5/12/2008