Professional Documents
Culture Documents
Transmission Charging Pump Pressure-test
Transmission Charging Pump Pressure-test
Transmission Charging Pump Pressure-test
Page 1 of 3
Shutdown SIS
Previous Screen
! " #
$ % & '(
) *
!" #$ $ % &' ( ) ) % ( *+ ) ) %
+ ,--*
When testing and adjusting the transmission and power train, move the
machine to an area clear of obstructions, with safe exhaust ventilation
for the exhausts. Sudden movement of the machine or release of oil
under pressure can cause injury to persons on or near the machine. To
prevent possible injury, do the procedure that follows before testing and
adjusting the transmission and power train.
NOTICE
Care must be taken to ensure that fluids are contained during
performance of inspection, maintenance, testing, adjusting, and repair
of the machine. Be prepared to collect the fluid with suitable containers
before opening any compartment or disassembling any component
containing fluids.
Before you begin the test, refer to Systems Operation, Testing and Adjusting, "Machine Preparation for
Troubleshooting".
Table 1
Required Tools
https://198.101.110.37:8443/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sis... 5/12/2008
120H Motor Grader 5FM00001-UP (MACHINE) POWERED BY 3116 Engine(SEBP25... Page 2 of 3
1. Operate the machine until the transmission oil is at an operating temperature of 51 °C (124 °F).
2. Stop the machine. Engage the parking brake and turn off the engine.
Illustration 1 g00109926
Left Rear of the Machine
3. Attach 8T-0856 Pressure Gauge (0 to 6,000 kPa (0 to 870 psi)) to pressure tap (1) on transmission
pump (2) .
4. Start the engine. Set the throttle control to high idle. Turn the differential lock to the ON position .
Refer to Table 3 for the correct transmission oil pressure. Record the gauge reading in Table 4.
Table 2
https://198.101.110.37:8443/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sis... 5/12/2008
120H Motor Grader 5FM00001-UP (MACHINE) POWERED BY 3116 Engine(SEBP25... Page 3 of 3
Table 3
5. Operate the engine at low idle and repeat Step 1 through Step 4.
./ 0 11) - . # 2 / , -, ! 9 + -
03 3 4 2
4 $ 5 6 7#78 3 32
https://198.101.110.37:8443/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sis... 5/12/2008