Professional Documents
Culture Documents
SAEJ663v001
SAEJ663v001
REV.
JUL94
VEHICLE
400 Commonwealth Drive, Warrendale, PA 15096-0001
STANDARD Issued 1948-02
Revised 1994-07
Superseding J663b
Submitted for recognition as an American National Standard
(R) RIVETS FOR BRAKE LININGS AND BOLTS FOR BRAKE BLOCKS
Foreword—This Document has not changed other than to put it into the new SAE Technical Standards Board
Format.
1. Scope—This SAE Standard specifies the dimensions of semitubular rivet and bolts for brake linings/blocks.
3. Semitubular Rivets for Brake Linings—Table 1 and Figure 1 give the dimensions for semitubular rivets used
for brake linings/blocks.
The eccentricity between the rivet head and shank must be no greater than 0.010 in., and the eccentricity
between the hole in the shank and the shank must be no greater than 0.010 in.
4. Bolts Used for Blocks—Table 2 and Figures 2 and 3 give the dimensions for standard bolts used for brake
linings/bolts.
All dimensions given are in inches due to the historical nature of the development and identification of these
components.
SAE Technical Standards Board Rules provide that: “This report is published by SAE to advance the state of technical and engineering sciences. The use of this report is entirely
voluntary, and its applicability and suitability for any particular use, including any patent infringement arising therefrom, is the sole responsibility of the user.”
SAE reviews each technical report at least every five years at which time it may be reaffirmed, revised, or cancelled. SAE invites your written comments and suggestions.
-2-
SAE J663 Revised JUL94
-3-
SAE J663 Revised JUL94
-4-
SAE J663 Revised JUL94
-5-
SAE J663 Revised JUL94
5. Notes
5.1 Marginal Indicia—The change bar (l) located in the left margin is for the convenience of the user in locating
areas where technical revisions have been made to the previous issue of the report. An (R) symbol to the left
of the document title indicates a complete revision of the report.
-6-
SAE J663 Revised JUL94
Rationale—Not applicable.
Application—This SAE Standard specifies the dimensions of semitubular rivet and bolts for brake linings/
blocks.