Professional Documents
Culture Documents
RiverRapidsQuiltPatternbyKohatuPatterns
RiverRapidsQuiltPatternbyKohatuPatterns
RiverRapidsQuiltPatternbyKohatuPatterns
River Rapids is a jelly-roll friendly quilt pattern that is suitable for beginner quilters. Once
finished your Quilt should measure approximately 53" x 80".
General Notes:
Materials Required: Tip: This Pattern is great for Jelly Rolls! I used a
Jelly Roll of Blueberry Park by Karen Lewis Textiles.
(Yardage is based on 112cm (42") fabric width).
Cutting Instructions:
Square up and cut selvages off ONE end of each of the WOF jelly roll strips
Put your coloured jelly roll strips in the order you wish them to go into the quilt from top to bottom.
With RST sew a Contrast/White 14" strip to the squared end of each of the jelly roll strips using a ¼"
seam. Keep them in order.
Iron each strip ensuring the seam is pressed open and then move to the cutting table.
Take the first strip and measure 12" from the seam onto your long strip and cut where the dotted line
indicates.
12"
12"
Selvedge
Tip: Leave selvages on one side of your strips until all 40 strips have been sewn together. This will help you remember
which side you are using to line up when joining the next strip.
Take your next strip, measure and cut 13" from the seam at the dotted line as per the diagram as below:
13"
Once again take the selvage end and sew it RST to the other end of the Contrast/White:
13"
Press the seams open and then line both strips up from the cut edge and join as shown:
12"
13"
14"
12"
13"
14"
Tip: Line up each row against the cut side to get a straight edge and
evenly spaced steps.
For the fourth and consequtive strips cut using the measurements in the table below:
Selvedge
Sew the two halves back together along the selvedge edge using a ¼” seam and press the seam to one
side.
Selvedge
Selvedge
Place your backing fabric with right side down on a large flat surface. Lay your quilt batting /wadding on
top of the backing followed by your quilt top (right side up).
Sandwich your top with wadding and fabric backing and use safety pins or fabric basting glue to hold it in
place. Then quilt in the ditch using straight lines across the width of your quilt.
As a purchaser of this pattern you may make copies for your personal use only. Please do not
copy or redistribute this pattern to other people without explicit permission from Rachel Julia.
Please ask them to purchase their own copy and support an independent designer.
It is absolutely fine if you would like to share photos of your completed quilt on social media,
your blog or sell items made using this pattern online as long as they have been handmade and
not mass-produced. It's not essential, but any credit given to Alexa & Me for the design is most
appreciated. Thank you for supporting an independent designer.
Please feel free to contact me at kohatupatterns@mail.com with any queries regarding this
pattern or if you would like your quilting work featured on my blog!
Instagram: @kohatupatterns
TikTok: @kohatuquilts