Professional Documents
Culture Documents
LED RED 0805
LED RED 0805
LED
COLOR SURFACE
OPTIONS MOUNT MSL
2
Application
• Wearable and Portable Devices • Home and Smart Appliance • Health Care Application
• Automotive Features • Backlit Keypads • Industrial Control Systems
• Navigations Systems • Medical Devices • Status Indicator
Key Features
CMD17-21 SRC/TR8
VGC/TR8 Green/Clear
Product Dimensions
Notes:
1. All dimensions are in mm
2. Tolerance is ±0.1 mm unless otherwise noted
3. The specifications, characteristics and technical data described in the datasheet are subject to change without prior notice.
Electrical-Optical Characteristics
CMD17-21SRC/TR8 Super Red Clear 20 10.0 21.0 1.7 2.4 660 140
CMD17-21VYD/TR8 Yellow Yellow Diffused 20 2.5 4.0 2.0 2.8 505 140
Over-current-proof
• Customer must apply resistors for protection, otherwise slight voltage shift will cause big current change
(Burn out will happen).
Storage
• Do not open moisture proof bag before the products are ready to use.
• After opening the package: The LEDs should be kept at 30°C or less and 60%RH or less.
• The LEDs should be used within 168 hours (7days) after opening the package. If unused LEDs remain, it should be
stored in moisture proof packages.
• If the moisture absorbent material (silica gel) has faded away or the LEDs have exceeded the
storage time, baking treatment should be performed using the following conditions. Baking treatment : 60±5°C
for 24 hours.
Soldering Condition
• Pb-free solder temperature profile
Soldering Iron
• Each terminal is to go to the tip of soldering iron temperature less than 350°C for 3 seconds within once in less than
the soldering iron capacity 25W. Leave two seconds and more intervals, and do soldering of each terminal. Be careful
because the damage of the product is often started at the time of the hand solder.
Repairing
• Repair should not be done after the LEDs have been soldered. When repairing is unavoidable, a double-head soldering
iron should be used (as below figure). It should be confirmed beforehand whether the characteristics of the LEDs will or
will not be damaged by repairing.
Notes:
1. All dimensions are in mm
2. Tolerance is ±0.1 mm unless otherwise noted
3. The specifications, characteristics and technical data described in the datasheet are subject to change without prior notice.